IllustrationGAS FUMES WERE GETTING INTO VEHICLE WHILE DRIVING. VEHICLE BEEN TO DEALER ON TWO OCCASIONS, AND PROBLEM HAS BEEN REOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *AK
1995 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1995 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 64 of 1,224 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 513 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports25 fire reports63 injury reports
Fuel System, Gasoline complaints
106 reportsCONSUMER STATES THAT THE VEHICLE IS LEAKING FUEL ONTO THE ENGINE. CONTACTED DEALER AND THE DEALER NOTED THAT THE VEHICLE IS NOT INCLUDED IN THE RECALL.*JB
THIS CPI UNIT HAS BEEN REPLACED SEVERAL TIMES BY OTHERS OWNING THIS SAME VEHICLE. *AK
ENGINE CHECK LIGHT ON CONSTANTLY, BROUGHT TO DEALER, REPLACED EGR VALVE, SECOND TIME CLEANED EGR VALVE,THIRD TIME REPLACED FUEL INJECTOR, FOURTH TIME REPLACED EGR VALVE AGAIN,FIFTH TIME REPLACED FUEL INJECTOR AGAIN. JUST PICKED UP FROM DEALER TODAY, AND SERVICE ENGINE LIGHT IS STILL ON. . DEALER DOES NOT SEEM TO BE ABLE FIX THE…
Read full complaint
ENGINE CHECK LIGHT ON CONSTANTLY, BROUGHT TO DEALER, REPLACED EGR VALVE, SECOND TIME CLEANED EGR VALVE,THIRD TIME REPLACED FUEL INJECTOR, FOURTH TIME REPLACED EGR VALVE AGAIN,FIFTH TIME REPLACED FUEL INJECTOR AGAIN. JUST PICKED UP FROM DEALER TODAY, AND SERVICE ENGINE LIGHT IS STILL ON. . DEALER DOES NOT SEEM TO BE ABLE FIX THE PROBLEM. I NEED SOME HELP, THERE HAS BEEN TOO MANY PROBLEMS WITH THIS VEHICLE. *AK
VEHICLE STALLS WHEN COMING TO A STOP, HAS STALLED 5 TIMES. CONSUMER RECEIVED LETTER FORM CHEVROLET STATING LEG VALVE NEEDS TO BE REPLACED. THIS HAS BEEN DONE, BUT IT DID NOT REMEDY PROBLEM.*AKTHE FUEL INJECTION ASSEMBLY WAS REPLACED IN JUNE OF 2002. *JG
THIS IS THE SECOND TIME I'VE REPLACED INJECTOR. THE FIRST TIME WAS A FEW YEARS BACK.*AK
VEHICLE MAKES A CLUNKING NOISE WHEN TURNING OR RIDING OVER BUMPY STREETS. DEALER CONFIRMED THAT UPPER AND LOWER BALL JOINTS ON EACH SIDE NEEDED REPLACING, AND 1995 MODELS WERE HAVING A COMMON PROBLEM. SERVICE TECHNICIAN STATED PROBLEM HAS CAUSED ACCIDENTS AND REFERRED CONSUMER TO PERSONNEL.*AK CONSUMER ALSO COMPLAINS THAT GA…
Read full complaint
VEHICLE MAKES A CLUNKING NOISE WHEN TURNING OR RIDING OVER BUMPY STREETS. DEALER CONFIRMED THAT UPPER AND LOWER BALL JOINTS ON EACH SIDE NEEDED REPLACING, AND 1995 MODELS WERE HAVING A COMMON PROBLEM. SERVICE TECHNICIAN STATED PROBLEM HAS CAUSED ACCIDENTS AND REFERRED CONSUMER TO PERSONNEL.*AK CONSUMER ALSO COMPLAINS THAT GASOLINE WAS LEAKING OUT OF THE INJECTION BULK HEAD, CAUSING THE FUEL INJECTION TO FAIL, CONSUMER REPAIRED AT OWN EXPENSE, WHEN CONSUMER NOTIFIED MANUFACTUER HOT LINE OF CONDITION, MANUFACTURER WAS ONLY AWARE OF THIS CONDITION IN THE STATE OF CALIFORNIA WHERE THERE ARE RECALLS FOR THE FUEL INJECTION SYSTEM. *TT
WE HAVE HAD REPEATED PROBLEMS WITH THIS VEHICLE FROM APPROXIMATELY 4000 AND GOING FORWARD. THE FIRST INDICATION OF PROBLEMS WITH ELECTRICAL WAS WHEN THE EMERGENCY FLASHERS WERE USED THE FIRST TIME AND IT BLEW THE ELECTRICAL SYSTEM AT APPROXIMATELY 4000 MILES WE HAD OWNED THE BLAZER LESS THAN 6 MONTHS AT THIS TIME. WE HAVE HAD …
Read full complaint
WE HAVE HAD REPEATED PROBLEMS WITH THIS VEHICLE FROM APPROXIMATELY 4000 AND GOING FORWARD. THE FIRST INDICATION OF PROBLEMS WITH ELECTRICAL WAS WHEN THE EMERGENCY FLASHERS WERE USED THE FIRST TIME AND IT BLEW THE ELECTRICAL SYSTEM AT APPROXIMATELY 4000 MILES WE HAD OWNED THE BLAZER LESS THAN 6 MONTHS AT THIS TIME. WE HAVE HAD SERVICE ENGINE CHECK LIGHT INDICATOR PROBLEMS REPEATEDLY AND WAS TOLD EVERY TIME BUT 1 THAT IT WAS "NOTHING" AND LATER WE HAVE PROBLEMS THAT ARE CONVENIENTLY NOT COVERED UNDER THE WARRANTY ANY MORE. THE SOFT PLUGS BLEW IN THE ENGINE IN 9-1999 AND WE WERE TOLD BY THE GARAGE THAT REPAIRED THIS THAT HE HAD SEEN THIS BEFORE ... THE ANTIFREEZE USED DETERIORATES THE PLUGS AND THEY EVENTUALLY LEAK AND THE ENGINE OVERHEATS. THE GM DEALER THAT WE TOOK THE BLAZER TO ON THIS OCCASIONS FOR A SECOND OPINION 11-2000 --THIS DEALER HAD ANOTHER 1995 BLAZER IN THE SHOP AT THE SAME TIME WITH THE EXACT SAME PROBLEM. I THOUGHT THIS WAS ODD FOR A TOWN OF 25,000 PEOPLE AND OF COURSE THE 800 LINE TO GM CUSTOMER SERVICES ADVISED ME THAT IT WAN'T ANYTHING THAT COULD BE COVERED. WE ALSO HAD THE LEATHER SEAT REPLACED ON DRIVER SIDE 2 TIMES BUT CONTINUE TO HAVE PROBLEMS WITH LEATHER SPLITTING AND OF COURSE THIS IS NOT COVERED.. ALL WE ARE ABLE TO GET FROM GM IS THE ANSWER "NO" WHENEVER WE FEEL THAT SOMETHING SHOULD BE COVERED... WE HAVE PUT OVER 2000 .00 IN REPAIRS IN THE ENGINE AND WIPERS AND FUEL INJECTION SYSTEM IN THE PAST FROM 9-1999 THRU 11 28 2000.... AND THE PROBLEMS CONTINUES.. THE SERVICE ENGINE SOON LIFHT COMES ON AND THE AIR BAG LIGHT GOES OFF AND ON AND STAY S ON FOR LONG PERIODS OF TIME... AND OF COURSE WHEN I CALLED LAST WEEK ON THE AIR BAG... LITE IT WAS. *AK
BLAZER WAS PURCHASED IN 1998, 1ST PROBLEM IN 1999-REPLACED MUFFLERS.. 1999- REPLACED EGR VALVE- 2000 REPLACED EGR VALVE AND CATALYTIC CON. & 2 OXYGEN SENSORS DUE TO FAILURE OF EGR VALVE...JUNE 2000- ANOTHER EGR VALVE REPLACED & FUEL INJECTION SYSTEM REPLACED- 2000 ; EGR REPLACED AND SPARK PLUGS AND ALL WIRES REPLACED; 2001- NEED…
Read full complaint
BLAZER WAS PURCHASED IN 1998, 1ST PROBLEM IN 1999-REPLACED MUFFLERS.. 1999- REPLACED EGR VALVE- 2000 REPLACED EGR VALVE AND CATALYTIC CON. & 2 OXYGEN SENSORS DUE TO FAILURE OF EGR VALVE...JUNE 2000- ANOTHER EGR VALVE REPLACED & FUEL INJECTION SYSTEM REPLACED- 2000 ; EGR REPLACED AND SPARK PLUGS AND ALL WIRES REPLACED; 2001- NEED ANOTHER EGR VALVE -- ALL AT COST TO OWNER!!!!!!!!!!!!
TRUCK DID START LEAKING GAS FROM THE TANK, AND AM HAVING THAT REPLACED NOW. *AK
Official recalls
699V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V234000 · Fuel System, Gasoline:storage:tank Assembly
Nov 14, 1996
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
95V180000 · Engine And Engine Cooling:cooling System:fan
Sep 22, 1995
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
95V080000 · Suspension:front:control Arm:upper Ball Joint
Apr 24, 1995
THE UPPER BALL JOINT NUTS WERE UNDER-TORQUED RESULTING IN IMPROPER SEATING IN THE STEERING KNUCKLE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BALL JOINT STUD TO LOOSEN, AND FRACTURE RESULTING IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER BALL JOINT NUT ON BOTH SIDES OF THE VEHICLE TO THE CORRECT TORQUE VALUES.
94V242000 · Service Brakes, Hydraulic:pedals And Linkages
Dec 12, 1994
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Remedy: DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99024 · Loss Of Power Assist Braking
Opened Apr 5, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
CONSUMERS ALLEGE A PARTIAL LOSS OF BRAKING ABILITY
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.