Engine And Engine CoolingFuel System, GasolinePower Train
4 EGR VALVES (AND I HAVE GOT TO PUT THE 5TH ONE ON NOW) IN THE LAST 3 YEARS $200.00 EACH. 2 CMFI UNITS BECAUSE OF THE FUEL PRESSURE REGULATOR LEAKING THE WHOLE UNIT HAS TO BE REPLACED $500.00 EACH. FUEL PUMPS $80.00 EACH TRANSMISSION HAS SLIPPED AT DIFFERENT TIMES. COOLING IS A PROBLEM IT HAS NEVER OVERHEATED BUT IT WOULD LIK…
Read full complaint
4 EGR VALVES (AND I HAVE GOT TO PUT THE 5TH ONE ON NOW) IN THE LAST 3 YEARS $200.00 EACH. 2 CMFI UNITS BECAUSE OF THE FUEL PRESSURE REGULATOR LEAKING THE WHOLE UNIT HAS TO BE REPLACED $500.00 EACH. FUEL PUMPS $80.00 EACH TRANSMISSION HAS SLIPPED AT DIFFERENT TIMES. COOLING IS A PROBLEM IT HAS NEVER OVERHEATED BUT IT WOULD LIKE TO IN THE SUMMER. I AM A MECHANIC AND ALL OF MY CARS ARE TAKEN CARE OF TO THE SLIGHTEST DETAIL BUT IT IS NOT NORMAL TO REPLACE THIS STUFF MORE THAN A COUPLE OF TIMES IN THE LIFE OF A CAR MUCH LESS A COUPLE OF TIMES A YEAR. *JB
NHTSA ODI #10005131
21,000 miles · Jan 31, 2003
Engine And Engine CoolingService Brakes, Hydraulic
GAS RECIRCULATION VALVE (EGR) FAILED 5 TIMES SINCE PURCHASE OF THE VEHICLE. BRAKES FAILED BY THE TIME VEHICLE GOT TO DEALERSHIP. *TT
NHTSA ODI #10003829
77,450 miles · Jan 9, 2003
Engine And Engine Cooling
WE PURCHASED A 95 CHEVY BLAZER FROM A DEALER USED AT THE END OF OCTOBER 2002. LESS THAN 60 DAYS LATER, THE OIL COOLER LINE FELL APART AND ALL OIL DRAINED FROM THE ENGINE IN 30-60 SECONDS, CAUSING COMPLETE ENGINE FAILURE. THE VEHICLE SEIZED UP IN TRAFIC IN A DANGEROUS AREA AND THERE WAS NOT TIME TO DRIVE TO A SAFE AREA TO INSPE…
Read full complaint
WE PURCHASED A 95 CHEVY BLAZER FROM A DEALER USED AT THE END OF OCTOBER 2002. LESS THAN 60 DAYS LATER, THE OIL COOLER LINE FELL APART AND ALL OIL DRAINED FROM THE ENGINE IN 30-60 SECONDS, CAUSING COMPLETE ENGINE FAILURE. THE VEHICLE SEIZED UP IN TRAFIC IN A DANGEROUS AREA AND THERE WAS NOT TIME TO DRIVE TO A SAFE AREA TO INSPECT THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO TOLD US THAT THIS WAS A FACTORY DEFECT AND SUGGESTED THAT WE CONTACT THE DEALER AS THE ENGINE MUST BE REPLACED. THE DEALER CONTACTED CHEVROLET WHO HAS DECLINED ALL RESPONSIBILITY AND KNOWLEDGE OF THIS PROBLEM, YET THERE ARE NUMEROUS CONSUMER COMPLAINTS ABOUT THE OIL HOSE. DESPITE THE FACT THAT THE VEHICLE WAS PURCHASED LESS THAN 60 DAYS BEFORE, WE NOW ARE FACING A REPAIR BILL THAT IS HALF THE COST OF THE VEHICLE AND THE DEALER'S RESPONSE WAS "TOO BAD."
NHTSA ODI #10000874
Mileage unknown · Nov 13, 2002
Engine And Engine Cooling
THE VEHICLE WAS PURCHASED IN 1999, TOOK IN TO DEALER FOR A ROUTINE CHECK AND MECHANIC STATES THAT CARBON IS BUILDING IN ERG VALVE, CAUSING VEHICLE TO STALL. TOOK TO DEALER AND THEY REPLACED ERG VALVE. MR
NHTSA ODI #8022698
Mileage unknown · Oct 23, 2002
Engine And Engine Cooling
CONSUMER STATES ENGINE LIGHT IS COMING ON. VEHICLE RUNS ROUGH. CONSUMER STATES VEHICLE HAS HAD 5 FUEL INJECTORS INSTALLED. MR
NHTSA ODI #8021505
Mileage unknown · Sep 30, 2002
Engine And Engine Cooling
SMOKE COMING FROM THE ENGINE AND THEN SOON AFTER THE VEHICLE CAUGHT ON FIRE. CONTACTED DEALER. *MR
NHTSA ODI #8019748
Mileage unknown · Aug 12, 2002
Engine And Engine Cooling
WHILE TRAVELING ABOUT 65MPH ON HIGHWAY AND WITHOUT PRIOR WARNING ENGINE FROZE UP, AND VEHICLE LOST ALL POWER. DEALERSHIP IS AWARE OF THE PROBLEM.*AK CONSUMER WAS INFORMED THAT THE OIL COOLER LINES HAD COMPLETELY SEPARATED AND THE OIL MUST HAVE PUMP OUT OF THE ENGINE ONTO THE FREEWAY, WHICH IN TURN CAUSED THE ENGINE TO SEIZE UP
NHTSA ODI #8016021
Mileage unknown · May 21, 2002
Engine And Engine CoolingFuel System, Gasoline
ENGINE WOULD START TO HESITATE AFTER SMELLING GAS FUMES. VEHICLE BEEN TO DEALER ON TWO OCCASIONS AND PROBLEM HAS BEEN REOCCURRING. *AK CONSUMER STATES WORK ALSO PERFORMED ON EXHAUST GAS RECALCULATION AND IDLER AIR CONTROL VALVE. *YD
NHTSA ODI #8010198
Mileage unknown · May 20, 2002
Engine And Engine CoolingUnknown Or Other
VEHICLE SHUT DOWN WITHOUT PRIOR WARNING, AND ENGINE CHECK LIGHT APPEARED ON DASHBOARD. DEALERSHIP WAS AWARE OF PROBLEM.*AK
NHTSA ODI #8010196
Mileage unknown · May 17, 2002
Engine And Engine Cooling
MAIN OIL COOLER LINE CAME APART FROM COUPLING, CASUING OILTO LEAK OUT VERY QUICKLY WITHOUT WARNING. CONTACTED DEALER.*AK
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Remedy: DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99024 · Loss Of Power Assist Braking
Opened Apr 5, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
CONSUMERS ALLEGE A PARTIAL LOSS OF BRAKING ABILITY
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1995 Chevrolet Blazer Problems, Complaints & Recalls | Skip That Year
Illustration