IllustrationWHILE VEHICLE WAS PARKED IT CAUGHT ON FIRE UNDER THE DASH DUE TO AN ELECTRICAL SHORT. *AK
1990 Chevrolet Blazer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1990 Chevrolet Blazer do not stand out strongly from the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 32 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports7 fire reports4 injury reports
What owners actually said
32 reportsONGOING/INTERMITTENT PROBLEM WITH ABS LOCKING UP WHILE APPLYING BRAKE PEDAL. DEALER/MANUFACTURER WERE NOT CONTACTED. *AK
GMC INSTALLED A MOTOR. UPON STARTING VEHICLE, IT BURST INTO FLAMES, INJURING SEVERAL PEOPLE. *AK
CONSUMER STATES THAT GMC INSTALLED A MOTOR IN TRUCK. WHEN CONSUMER WENT TO START VEHICLE, TRUCK BURST INTO FLAMES, INJURYING SEVERAL PEOPLE. *AK
WHILE DRIVING HEARD THINGS UNDER THE HOOD MAKING NOISE. PULLED OVER AND OPENED HOOD, AND THERE WAS A FIRE UNDERNEATH. CALLED THE POLICE, BUT THE FIRE WAS THEN PUT OUT. *AK
DEFECTIVE ABS IS CAUSING LOSS OF BACK BRAKES WITHOUT WARNING. DEALER HAS REPLACED DUMP VALVES 5 TIMES, DEFECT IS STILL REOCCURRING. *AK
WHILE DRIVING HOME IN A HEAVY RAIN STORM CAME TO A STOP AT TOP OF STEEP HILL, GETNLY TEPPED THE BRAKES, BRAKES FAILED TO STOP VEHICLE. VEHICLE SLID INTO THE BACK OF A TRUCK, CAUSING EXTENSIVE DAMAGE. *AK
CONSUMER WAS DRIVING APPROX. 15 MPH WHEN HE PRESSED THE BRAKES TO SLOW DOWN FOR VEHICLE IN FRONT MAKING A TURN, AND THE BRAKES FAILED. CONSUMER CRASHED INTO THE CAR IN FRONT OF HIM, THEN HE WAS HIT FROM BEHIND DURING THE SAME CRASH. THERE WAS DRIZZLES OF RAIN AT TIME OF INCIDENT. CONSUMER HAS EXPERIENCED BRAKE FAILURE MORE THAN…
Read full complaint
CONSUMER WAS DRIVING APPROX. 15 MPH WHEN HE PRESSED THE BRAKES TO SLOW DOWN FOR VEHICLE IN FRONT MAKING A TURN, AND THE BRAKES FAILED. CONSUMER CRASHED INTO THE CAR IN FRONT OF HIM, THEN HE WAS HIT FROM BEHIND DURING THE SAME CRASH. THERE WAS DRIZZLES OF RAIN AT TIME OF INCIDENT. CONSUMER HAS EXPERIENCED BRAKE FAILURE MORE THAN FIVE TIMES. *AK
WHEN APPLYING BRAKES, NOTICED SEATS MOVE DUE TO LOOSENESS. THE BOLTS WERE TIGHTENED. CHECKED UNDERNEATH & NOTICED MOUNTING PLATE METAL FOR SEAT WAS RUSTY & HAD CORRODED AWAY. HAVE NOT TAKEN TO DEALER. *AK
WHEN APPLYING THE ABS BRAKES, WHILE GOING DOWN A HILL, THE ABS LIGHT CAME ON AND BRAKES FAILED TO STOP THE VEHICLE, CAUSING AN ACCIDENT.*AK
Official recalls
193V119000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 2, 1993
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.
EA92015 · High Idle Flare
Opened May 22, 1992 · Closed May 28, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92001 · High Idle Flare
Opened Jan 7, 1992 · Closed May 22, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91028 · Brake Failure
Opened Jun 10, 1991 · Closed Jun 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
PE91057 · Headlight Switch Failure
Opened Mar 6, 1991 · Closed Jul 12, 1991
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE91052 · Brake Failure
Opened Feb 22, 1991 · Closed Jun 10, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available