NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
206 reports84,000 miles · Apr 2, 2013
EngineSteeringVehicle Speed Control
AS I BEGAN TO ACCELERATE ONTO THE HIGHWAY, I FELT THAT MY CAR WAS NOT PICKING UP, I COULD ONLY GET TO AROUND 40-45MPH ON A HIGHWAY THAT IS 65MPH. I NEARLY GOT REAR-ENDED BY CARS FLYING UP ON ME AND I QUICKLY PULLED OFF TO THE SHOULDER JUST IN TIME AS THE POWER STEERING ALSO WENT OUT AND THE CAR APPEARED TO HAVE STOPPED RUNNING. …
Read full complaint
AS I BEGAN TO ACCELERATE ONTO THE HIGHWAY, I FELT THAT MY CAR WAS NOT PICKING UP, I COULD ONLY GET TO AROUND 40-45MPH ON A HIGHWAY THAT IS 65MPH. I NEARLY GOT REAR-ENDED BY CARS FLYING UP ON ME AND I QUICKLY PULLED OFF TO THE SHOULDER JUST IN TIME AS THE POWER STEERING ALSO WENT OUT AND THE CAR APPEARED TO HAVE STOPPED RUNNING. I COULD NOT GET THE CAR TO START AGAIN. THE DIAGNOSTICS CAME BACK THAT THE TIMING BELT HAD GONE AND IT COULD BE FIXED FOR ANYWHERE BETWEEN $800 TO NEEDING A BRAND NEW MOTOR. THIS FLOORED ME AS I ALWAYS HAD THE OIL AND FLUIDS REPLACED AND THE CAR ONLY HAD 84K MILES ON IT. I BEGAN TO RESEARCH THE AVEO AND BAM, THERE IT WAS, OVER AND OVER AGAIN ON-LINE. OWNERS ALL COMPLAINING OF THE SAME PROBLEM WITH THEIR AVEO. THE TIMING BELT ON THE AVEO, ESPECIALLY THE 04-07 MODELS GO AND WILL REQUIRE ANYWHERE FROM A MAJOR FIX TO A BRAND NEW ENGINE. THIS IS A BIG PROBLEM ON A LITTLE CAR. I WENT ON CRAIGSLIST TO LOOK FOR A NEW ENGINE, BUT INSTEAD FOUND 10 AVEOS IN ONE HOUR... THAT WERE BEING SOLD FOR PARTS BECAUSE THEIR TIMING BELT WENT! PLEASE TAKE A LOOK AT THIS PROBLEM, I BELIEVE THERE IS A MAJOR PROBLEM WITH THE AVEO DESERVING OF A RECALL, AND OWNERS SHOULD BE MADE AWARE OF THIS SERIOUS PROBLEM AND THE PERSISTENT NEED TO HAVE THEIR TIMING BELT REPLACED OR FACE A TOTAL ENGINE REPLACEMENT. I COULD HAVE EASILY BEEN REAR-ENDED OR WORSE BECAUSE OF THE LOSS OF POWER AND POWER STEERING. THANK YOU. *TR
NHTSA ODI #10505451
68,000 miles · Nov 2, 2012
Engine
THE TIMING BELT BROKE IN OUR VEHICLE WHILE WE WERE DRIVING. THE CAR MADE A HORRIBLE RACKET, THEN COMPLETELY LOST POWER BEFORE IT DIED COMPLETELY, WHEN IT BROKE, IT BENT THE RODS AND PISTONS IN THE HEADS. NOW JUST TWO WEEKS AGO, IT HAS DONE THE SAME THING. CHEVY NEEDS TO MAKE A RECALL ON THIS BECAUSE ITS GOING TO END UP KILLING S…
Read full complaint
THE TIMING BELT BROKE IN OUR VEHICLE WHILE WE WERE DRIVING. THE CAR MADE A HORRIBLE RACKET, THEN COMPLETELY LOST POWER BEFORE IT DIED COMPLETELY, WHEN IT BROKE, IT BENT THE RODS AND PISTONS IN THE HEADS. NOW JUST TWO WEEKS AGO, IT HAS DONE THE SAME THING. CHEVY NEEDS TO MAKE A RECALL ON THIS BECAUSE ITS GOING TO END UP KILLING SOMEONE AND THIS ISN'T THE ONLY AVEO TO HAVE DONE THIS. *TR
NHTSA ODI #10482944
103,000 miles · Oct 10, 2012
Air Bags
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION BUT THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILE…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION BUT THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 103,000.
NHTSA ODI #10479671
78,423 miles · Aug 28, 2012
EnginePower Train
DRIVING AT 55 MPH THE CAR FELT LIKE CAME OUT OF 5TH GEAR. I CHECKED TO MAKE SURE THE CAR WAS IN GEAR. PUSHED THE CLUTCH IN (VERY TIGHT). THE CAR WAS LOOSING POWER BUT TACH WAS STILL AT 3000. I COASTED TO THE SIDE OF THE ROAD AND THE CAR HAD NO SPARK. LIGHTS STILL WORKED. I HAD THE CAR TOWED AND FOUND THAT THE TIMING BELT F…
Read full complaint
DRIVING AT 55 MPH THE CAR FELT LIKE CAME OUT OF 5TH GEAR. I CHECKED TO MAKE SURE THE CAR WAS IN GEAR. PUSHED THE CLUTCH IN (VERY TIGHT). THE CAR WAS LOOSING POWER BUT TACH WAS STILL AT 3000. I COASTED TO THE SIDE OF THE ROAD AND THE CAR HAD NO SPARK. LIGHTS STILL WORKED. I HAD THE CAR TOWED AND FOUND THAT THE TIMING BELT FAILED WHICH TOOK OUT THE WATER PUMP AND DAMAGED MY HEAD. THERE WAS NO WARNING AT ALL. AT THIS TIME I HAVE BEEN TOLD BY MECHANIC AND 2 CHEVROLET DEALERSHIPS THAT THIS IS A COMMON OCCURRENCE. THANK GOD IT WAS 5:15 AM AND NOT A LOT OF TRAFFIC ON THE ROAD. *TR
NHTSA ODI #10472847
63,000 miles · Aug 27, 2012
Engine
TIMING BELT BROKE WHILE ON A MAJOR HIGHWAY DOING 65 MPH. CAUSING THE CAR TO SHUT OFF AND LEAVE ME STRANDED WHEN IT BROKE IT CRUSHED ALL 4 CYLINDER HEADS. *TR
NHTSA ODI #10472696
87,000 miles · Aug 9, 2012
Seat Belts
WE PURCHASED THIS CAR FROM A USED CAR DEALERSHIP THIS YEAR. THE REAR SEAT BELTS DON'T EXTEND OR RETRACT. THERE WAS A SAFETY RECALL ISSUED ON OCTOBER 15, 2004 (RECALL # 04V407000). CHEVROLET'S RECALL CENTER HAS TOLD ME IT'S NO LONGER THEIR RESPONSIBILITY TO REPAIR THE REAR SEAT BELTS, BECAUSE ALTHOUGH THIS IS A PASSENGER SAFETY C…
Read full complaint
WE PURCHASED THIS CAR FROM A USED CAR DEALERSHIP THIS YEAR. THE REAR SEAT BELTS DON'T EXTEND OR RETRACT. THERE WAS A SAFETY RECALL ISSUED ON OCTOBER 15, 2004 (RECALL # 04V407000). CHEVROLET'S RECALL CENTER HAS TOLD ME IT'S NO LONGER THEIR RESPONSIBILITY TO REPAIR THE REAR SEAT BELTS, BECAUSE ALTHOUGH THIS IS A PASSENGER SAFETY CONCERN, THIS RECALL ITEM IS NOW IN A, "CLOSED" STATUS. MY QUESTIONS IS, "REALLY"?! DEFECTIVE PASSENGER SEAT BELTS ARE NO LONGER CHEVY'S RESPONSIBILITY AFTER A CERTAIN TIME PERIOD? PLEASE LOOK INTO THIS AND PLEASE ADVISE ME AS TO WHAT MY RIGHTS ARE AS A CHEVY OWNER. *TR
NHTSA ODI #10470014
58,995 miles · Jun 28, 2012
Engine
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE HEARD A KNOCKING SOUND FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER ADVISED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE HEARD A KNOCKING SOUND FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER ADVISED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE AND CURRENT MILEAGE WAS 58,995.
NHTSA ODI #10463476
127,000 miles · Jun 21, 2012
Service Brakes
MY PASSENGER REAR SHOE BROKE IN HALF. IN THE FOLLOWING MONTHS, APPROXIMATELY ONCE EVERY WEEK TO TWO WEEKS MY SPRINGS AND SELF ADJUST FALL OFF. WHEN THE DRUM IS PULLED OFF THEY ARE EITHER COMPLETELY DETACHED OR HANGING BY A HAIR. THEY ARE NOT CONNECTED NOR ARE THEY DOING ANY GOOD FOR THE BRAKING SYSTEM. IN THE 7 MONTHS THAT I HAV…
Read full complaint
MY PASSENGER REAR SHOE BROKE IN HALF. IN THE FOLLOWING MONTHS, APPROXIMATELY ONCE EVERY WEEK TO TWO WEEKS MY SPRINGS AND SELF ADJUST FALL OFF. WHEN THE DRUM IS PULLED OFF THEY ARE EITHER COMPLETELY DETACHED OR HANGING BY A HAIR. THEY ARE NOT CONNECTED NOR ARE THEY DOING ANY GOOD FOR THE BRAKING SYSTEM. IN THE 7 MONTHS THAT I HAVE HAD THE CAR, I HAVE HAD IT WORKED ON 18 OR MORE TIMES ON THE EXACT SAME BRAKE. *TT
NHTSA ODI #10462676
39,500 miles · Jun 15, 2012
Electrical SystemEngine
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE ENGINE WAS RESTARTED AFTER THE FIRST ATTEMPT AND THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED NINE TIMES ON SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO AN…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE ENGINE WAS RESTARTED AFTER THE FIRST ATTEMPT AND THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED NINE TIMES ON SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND THEY WERE UNABLE TO DETECT A CAUSE OF FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 39,500. UPDATED 07/25/12*LJ THE CONSUMER STATED THE DEALER KEPT THE VEHICLE FOR EIGHT DAYS. UPDATED 07/25/12
NHTSA ODI #10461886
88,000 miles · Jun 2, 2012
Engine
MY STEPDAUGHTER AND HER FRIEND WERE TRAVELING CROSS-COUNTRY FROM CALIFORNIA TO ILLINOIS. CAR HAD JUST BEEN CHECKED BY A MECHANIC PRIOR TO TRIP AND SAID WAS OK. ON I-40, ABOUT 40 MILES WEST OF ALBUQUERQUE NM, SHE REALIZED THE CAR WAS GETTING WARM, THEN THEY SAW STEAM FROM HOOD, CHECK ENGINE LIGHT CAME ON. SHE IMMEDIATELY PULLE…
Read full complaint
MY STEPDAUGHTER AND HER FRIEND WERE TRAVELING CROSS-COUNTRY FROM CALIFORNIA TO ILLINOIS. CAR HAD JUST BEEN CHECKED BY A MECHANIC PRIOR TO TRIP AND SAID WAS OK. ON I-40, ABOUT 40 MILES WEST OF ALBUQUERQUE NM, SHE REALIZED THE CAR WAS GETTING WARM, THEN THEY SAW STEAM FROM HOOD, CHECK ENGINE LIGHT CAME ON. SHE IMMEDIATELY PULLED TO THE SIDE OF THE ROAD AND CALLED ME, IN ILLINOIS. THEN SHE CALLED AAA FOR TOWING, AND WAS TOWED TO GALLES CHEVROLET IN ALBUQUERQUE. THE NEXT DAY THEY DIAGNOSED TOTAL ENGINE FAILURE DUE TO OVERHEATING; CAUSE OF FAILURE LIKELY A BROKEN THERMOSTAT HOUSING. I SEARCHED FOR THIS ISSUE AND FOUND MANY SIMILAR COMPLAINTS IN EDMUNDS FORUM; THIS CERTAINLY SEEMS TO BE A COMMON PROBLEM. IN THE END THE GIRLS WERE SAFE, THANK GOD. NOT ONLY WAS THIS A VERY EXPENSIVE INCIDENT (~$5000), BUT IT COULD HAVE BEEN A VERY SERIOUS SAFETY ISSUE, LEAVING TWO YOUNG COLLEGE GIRLS STRANDED IN A REMOTE DESERT LOCATION ON A HOT DAY, VERY VULNERABLE. THE NEXT PERSON THIS HAPPENS TO MIGHT NOT BE SO FORTUNATE. I URGE YOU TO TAKE ACTION TO REQUIRE GM TO RECALL AND FIX THIS ISSUE. THANK YOU. *TR
NHTSA ODI #10460333
NHTSA investigations
2EA08005 · Stuck Throttle Valve
Opened Feb 14, 2008 · Closed Oct 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07051 · Stuck Throttle Valve
Opened Oct 19, 2007 · Closed Feb 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Illustration