RECALL 04069 2004 CHEVY AVEO. I CALLED SERVICE AT ANDEAN CHEVY(CUMMING GA) TO SCHEDULE THIS RECALL WORK. I DROPPED THE CAR OFF IN THE MORNING AND PICKED THE CAR UP THAT EVENING. WHEN I PICKED UP THE CAR AT NO TIME DID ANYONE EVER MENTION TO ME THAT THE RECALL WORK WAS NOT COMPLETE. THIS IS A SEAT BELT ISSUE. WHY WAS I ALLOWED T…
Read full complaint
RECALL 04069 2004 CHEVY AVEO. I CALLED SERVICE AT ANDEAN CHEVY(CUMMING GA) TO SCHEDULE THIS RECALL WORK. I DROPPED THE CAR OFF IN THE MORNING AND PICKED THE CAR UP THAT EVENING. WHEN I PICKED UP THE CAR AT NO TIME DID ANYONE EVER MENTION TO ME THAT THE RECALL WORK WAS NOT COMPLETE. THIS IS A SEAT BELT ISSUE. WHY WAS I ALLOWED TO BRING IN A CAR FOR A RECALL WHEN THE PART WAS NOT IN STOCK? ANDEAN KNEW EXACTLY WHY THE APPOINTMENT WAS SCHEDULED. RATHER THAN BE UP FRONT AND TELL ME THE WORK WAS NOT DONE, THEY ALLOWED ME TO DRIVE AWAY THINKING THE WORK WAS COMPLETE, THEREBY GIVING ME THE IMPRESSION THE CAR WAS SAFE AND SEAT BELT WORKED. *JB
NHTSA ODI #10153597
14,000 miles · Feb 21, 2006
Seat Belts
DT*: THE CONTACT STATED THE DRIVER SEAT BELT RETRACTS SLOWLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION AND REPAIR.
NHTSA ODI #10150747
Mileage unknown · Dec 2, 2004
Power TrainSeat Belts
WHILE DRIVING 20 MPH VEHICLE STALLED. CONSUMER WAS ABLE TO RESTART VEHICLE. ALSO, REAR SEAT BELT MALFUNCTIONED, IT DID NOT RETRACT. *AK
NHTSA ODI #10102054
6,000 miles · Nov 17, 2004
Seat Belts
IT WOULD BE HARD FOR THE CONSUMER TO UNLOCK THE REAR SEAT BELTS FROM THE BUCKLE. DEALER WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.*AK
NHTSA ODI #10101167
7,989 miles · Oct 18, 2004
Fuel System, GasolineSeat Belts
THE GAS CAP BROKE WEEKS AFTER PURCHASING THE VEHICLE. THE CONSUMER WAS UNABLE TO REMOVE THE GAS CAP TO FILL THE TANK. THE DEALER STATED THAT THE SPRING BROKE.. THE DEALER TOOK IT OFF SO THAT THE CONSUMER COULD PLACE GAS IN THE TANK. THE CONSUMER WAS UNABLE TO GET ANOTHER CAP BECAUSE THE DEALER WAS UNABLE TO OBTAIN ONE. THE R…
Read full complaint
THE GAS CAP BROKE WEEKS AFTER PURCHASING THE VEHICLE. THE CONSUMER WAS UNABLE TO REMOVE THE GAS CAP TO FILL THE TANK. THE DEALER STATED THAT THE SPRING BROKE.. THE DEALER TOOK IT OFF SO THAT THE CONSUMER COULD PLACE GAS IN THE TANK. THE CONSUMER WAS UNABLE TO GET ANOTHER CAP BECAUSE THE DEALER WAS UNABLE TO OBTAIN ONE. THE RIGHT REAR PASSENGER SEAT BELT RETRACTOR WAS DEFECTIVE AND A RECALL WAS ISSUED, HOWEVER NO PARTS WERE AVAILABLE. NHTSA RECALL 04V407000. *JB
NHTSA ODI #10097028
4,300 miles · Oct 14, 2004
Seat BeltsCrashInjury
THE CONSUMER WAS INVOLVED IN A VEHICLE ACCIDENT WHEREBY THE SEAT BELTS DID NOT WORK. THE DRIVER SEAT BELT BROKE AND A TODDLER WAS THROWN TO THE FRONT SEAT. AFTER COMPLAINING TO THE MANUFACTURER ABOUT THE FAILURE, GM STILL DID NOT COOPERATE. THE CONSUMER JUST RECEIVED A RECALL ON THE SEAT BELT. NHTSA RECALL 04V407000. *JB
NHTSA ODI #10096852
Mileage unknown · Sep 20, 2004
Seat Belts
CONSUMER STATED THAT WHEN GETTING INTO VEHICLE AND SITTING IN THE BACK SEAT AND WHEN PUTTING THE SEAT BELT ON THERE WAS NO WAY TO ADJUST THE SEAT BELT. INSTEAD THE SEAT BELT KEPT GETTING TIGHTER AND TIGHTER. CONSUMER TOOK VEHICLE TO THE DEALER, AND THEY CLAIMED THERE WAS NOTHING THAT THEY COULD DO. THIS WAS VERY UNCOMFORTABL…
Read full complaint
CONSUMER STATED THAT WHEN GETTING INTO VEHICLE AND SITTING IN THE BACK SEAT AND WHEN PUTTING THE SEAT BELT ON THERE WAS NO WAY TO ADJUST THE SEAT BELT. INSTEAD THE SEAT BELT KEPT GETTING TIGHTER AND TIGHTER. CONSUMER TOOK VEHICLE TO THE DEALER, AND THEY CLAIMED THERE WAS NOTHING THAT THEY COULD DO. THIS WAS VERY UNCOMFORTABLE FOR PERSONS RIDING IN THE REAR OF VEHICLE.*AK
NHTSA ODI #10092882
Mileage unknown · Aug 27, 2004
Seat Belts
BOTH REAR SEAT BELTS WERE NOT WORKING. VEHICLE WAS TAKEN TO THE DEALERSHIP, WHO INDICATED TO THE CONSUMER THAT THEY DIDN'T HAVE ANY RESPONSIBILITY FOR THE SEAT BELTD DUE TO CONSUMER MISUSE OF THE SEA TBELTS. *AK
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence & remedy
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
ON CERTAIN PASSENGER VEHICLES, THE REAR SAFETY BELT CAN BECOME TWISTED.
Consequence & remedy
Consequence: IF THIS OCCURS THE SAFETY BELT RETRACTOR MAY LOCK IN POSITION SO THAT THE BELT CANNOT BE USED. IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO THE SEAT OCCUPANT COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SAFETY BELT WEBBING GUIDE TO PREVENT THE BELT FROM TWISTING. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438. VEHICLE OWNERS LOCATED IN GUAM SHOULD CONTACT GM CUSTOMER ASSISTANCE AT 1-671-648-8453.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08005 · Stuck Throttle Valve
Opened Feb 14, 2008 · Closed Oct 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07051 · Stuck Throttle Valve
Opened Oct 19, 2007 · Closed Feb 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
2004 Chevrolet Aveo Problems, Complaints & Recalls | Skip That Year
Illustration