TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE I…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD EXPERIENCED A FAILURE.
NHTSA ODI #10761184
Mileage unknown · Apr 3, 2015
Exterior LightingFire
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE CONTACT CALLED THE AUTHORIZED DEALER SEVERAL TIMES FOR MONTHS AND THEY INDICATED THAT THE PART WAS NOT AVAILABLE AND THAT THE REPAIR WAS NOT URGENT. UPON STARTING THE VEHICLE, GRAY SMOKE STAR…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE CONTACT CALLED THE AUTHORIZED DEALER SEVERAL TIMES FOR MONTHS AND THEY INDICATED THAT THE PART WAS NOT AVAILABLE AND THAT THE REPAIR WAS NOT URGENT. UPON STARTING THE VEHICLE, GRAY SMOKE STARTED TO EMIT FROM UNDER THE HOOD INTO THE INTERIOR OF THE VEHICLE. THE CONTACT RELEASED THE HOOD LATCH QUICKLY AND HAD A PASSENGER DISCONNECT THE BATTERY. HOWEVER, A FIRE ERUPTED NEAR THE FRONT OF THE VEHICLE AS SMOKE FILLED THE VEHICLE CAUSING POOR VISIBILITY THAT IMPACTED THE CONTACT'S BREATHING. THE CONTACT AND THE DRIVER WERE ABLE TO QUICKLY EXIT THE VEHICLE. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH A FIRE EXTINGUISHER. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND WAS PARKED AT THE CONTACT'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10703610
Mileage unknown · Apr 3, 2015
Exterior Lighting
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT EXPERIENCED AN INTERMITTENT FAILURE WITH THE EXTERIOR LIGHTING. THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT EXPERIENCED AN INTERMITTENT FAILURE WITH THE EXTERIOR LIGHTING. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10703520
150,000 miles · Feb 12, 2015
Electrical SystemExterior LightingCrashFire
TL* THE CONTACT OWNED A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V2610000 (EXTERIOR LIGHTING). WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT'S VEHICLE TAPPED ANOTHER VEHICLE. THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. THE VEHICLE BECAME ENGULFED IN FLAMES AND WAS DESTROY…
Read full complaint
TL* THE CONTACT OWNED A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V2610000 (EXTERIOR LIGHTING). WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT'S VEHICLE TAPPED ANOTHER VEHICLE. THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. THE VEHICLE BECAME ENGULFED IN FLAMES AND WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #10683015
Mileage unknown · Feb 12, 2015
Exterior Lighting
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISS…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10683007
Mileage unknown · Dec 30, 2014
Exterior Lighting
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VEHICLE SAT AT THE DEALER FOR TEN MON…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VEHICLE SAT AT THE DEALER FOR TEN MONTHS, DUE TO LACK OF PARTS. UPDATED 06/10/15.*JB
NHTSA ODI #10669145
15,000 miles · Dec 24, 2014
Exterior Lighting
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS FLICKERED INTERMITTENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS FLICKERED INTERMITTENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000. THE CONSUMER STATED THE RECALL STILL HAS NOT BEEN ADDRESSED. UPDATED 08/24/15*JB
NHTSA ODI #10668153
Mileage unknown · Nov 21, 2014
Exterior Lighting
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO INFORM WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONT…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO INFORM WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10660103
Mileage unknown · Sep 4, 2014
Exterior Lighting
2004 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO HEADLAMP SWITCH MODULE RECALL NOTICE. *SMD THE CONSUMER WAS INFORMED THE PARTS WERE NOT AVAILABLE. *JB
NHTSA ODI #10629758
50,000 miles · Jun 26, 2014
Exterior Lighting
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE TURNING SIGNAL LIGHTS ILLUMINATED INTERMITTENTLY. THE CONTACT MENTIONED THAT THE VEHICLE WAS EXHIBITING THE FAILURE SPECIFIED IN RECALL NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING).THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWA…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE TURNING SIGNAL LIGHTS ILLUMINATED INTERMITTENTLY. THE CONTACT MENTIONED THAT THE VEHICLE WAS EXHIBITING THE FAILURE SPECIFIED IN RECALL NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING).THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 50,000. UPDATED 8/11/4*CN
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence & remedy
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
ON CERTAIN PASSENGER VEHICLES, THE REAR SAFETY BELT CAN BECOME TWISTED.
Consequence & remedy
Consequence: IF THIS OCCURS THE SAFETY BELT RETRACTOR MAY LOCK IN POSITION SO THAT THE BELT CANNOT BE USED. IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO THE SEAT OCCUPANT COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SAFETY BELT WEBBING GUIDE TO PREVENT THE BELT FROM TWISTING. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438. VEHICLE OWNERS LOCATED IN GUAM SHOULD CONTACT GM CUSTOMER ASSISTANCE AT 1-671-648-8453.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08005 · Stuck Throttle Valve
Opened Feb 14, 2008 · Closed Oct 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07051 · Stuck Throttle Valve
Opened Oct 19, 2007 · Closed Feb 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
2004 Chevrolet Aveo Problems, Complaints & Recalls | Skip That Year
Illustration