Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1425–50K
1050–75K
1175–100K
16100–150K
4150K+
62 reports with mileage · 9 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports3 injury reports
What owners actually said
71 reports
16,900 miles · Aug 6, 2021
Air Bags
The contact owns a 2005 Chevrolet Avalanche. The contact stated that while starting the vehicle, the passenger’s side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger’s side air bag was faulty and needed to be replaced. The vehicle was not repaired. The manu…
Read full complaint
The contact owns a 2005 Chevrolet Avalanche. The contact stated that while starting the vehicle, the passenger’s side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger’s side air bag was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 16,900.
NHTSA ODI #11428108
Mileage unknown · Feb 29, 2016
Electrical SystemEngineSeat Belts
CLUSTER GAUGE IS NOT READ PROPERLY ALL READING ARE ALL OVER THE PLACE.
NHTSA ODI #10839019
220,000 miles · Dec 14, 2015
Service Brakes
CATASTROPHIC BRAKE FAILURE BECAUSE OF FOUR CORRODED BRAKE LINES. ALL FOUR LINES CORRODED IN THE BRACKET HOLDING THE LINES TO THE DRIVER SIDE FRAME RAIL. I WAS DRIVING THE VEHICLE AND WHEN I ATTEMPTED TO APPLY THE BRAKES THERE WAS INITIAL RESISTANCE AND THEN THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR. I ATTEMPTED TO APPLY THE BRA…
Read full complaint
CATASTROPHIC BRAKE FAILURE BECAUSE OF FOUR CORRODED BRAKE LINES. ALL FOUR LINES CORRODED IN THE BRACKET HOLDING THE LINES TO THE DRIVER SIDE FRAME RAIL. I WAS DRIVING THE VEHICLE AND WHEN I ATTEMPTED TO APPLY THE BRAKES THERE WAS INITIAL RESISTANCE AND THEN THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR. I ATTEMPTED TO APPLY THE BRAKES AGAIN BUT THE VEHICLE WOULD NOT STOP. I HAD TO APPLY THE PARKING BRAKE TO STOP.
NHTSA ODI #10809980
215,000 miles · Dec 8, 2015
Fuel/propulsion SystemUnknown Or Other
THE FUEL LINES RUBBING TOGETHER CAUSING FUEL TO DUMP EVERY WHERE RIGHT NEXT TO THE CAT ON THE DRIVER SIDE OF THE TRUCK N THIS IS NOT A RECALL. THEN I SAY ITS ATTEPMED MURDER CHARGE AGAISNT CHEVY....
NHTSA ODI #10808951
203,000 miles · Nov 23, 2015
Exterior LightingUnknown Or Other
THE INSTRUMENT PANEL CLUSTER DOES NOT LIGHT UP. CANNOT TELL WHAT GEAR I AM SHIFTING IN AND OUT OF. THE DIC BUTTONS ON MY STEERING WHEEL DO NOT LIGHT UP, CANNOT TELL IF I HAVE A MALFUNCTION WHEN DRIVING DURING THE DARK. I DID CHECK FOR A RECALL ON THIS AND SAW THAT THERE WAS AN OLDER ONE ISSUED IN 2005 AND THAT IT CLOSED IN 2011.…
Read full complaint
THE INSTRUMENT PANEL CLUSTER DOES NOT LIGHT UP. CANNOT TELL WHAT GEAR I AM SHIFTING IN AND OUT OF. THE DIC BUTTONS ON MY STEERING WHEEL DO NOT LIGHT UP, CANNOT TELL IF I HAVE A MALFUNCTION WHEN DRIVING DURING THE DARK. I DID CHECK FOR A RECALL ON THIS AND SAW THAT THERE WAS AN OLDER ONE ISSUED IN 2005 AND THAT IT CLOSED IN 2011. I WAS NOT AWARE OF ANY RECALLS BUT NONE THE LESS I FEEL THAT WITH BOTH COMPONENTS FAILING AND NOT WORKING PROPERLY CAN CAUSE A POTENTIAL PROBLEM WHEN IN OPERATION (DRIVING)
NHTSA ODI #10806367
124,000 miles · Oct 19, 2015
Engine
CYLINDER HEADS CRACKED DUE TO POOR CASTING (KNOWN ISSUE BY GM). THIS LED TO COOLANT IN THE ENGINE CAUSING DAMAGE TO LIFTERS. EXPECTED COST TO FIX IS APPROXIMATELY $1,500 IN PARTS UP TO $4,000 IN LABOR.
NHTSA ODI #10783541
30,268 miles · Jul 21, 2015
Air Bags
8/15/2014 - SERVICE AIR BAG LIGHT DISPLAYED. DEALER DIAGNOSED THE ISSUE AS CRASH SENSOR (10370149). DEALERSHIP REPLACED SENSOR - COST $419. 07/10/2015 - SERVICE AIR BAG LIGHT DISPLAYED. DEALER DIAGNOSE THE ISSUE AS ANOTHER CRASH SENSOR (10370149). DEALERSHIP REPLACED SENSOR - COST $473. I FIND IT CONCERNING THAT AIR BA…
Read full complaint
8/15/2014 - SERVICE AIR BAG LIGHT DISPLAYED. DEALER DIAGNOSED THE ISSUE AS CRASH SENSOR (10370149). DEALERSHIP REPLACED SENSOR - COST $419. 07/10/2015 - SERVICE AIR BAG LIGHT DISPLAYED. DEALER DIAGNOSE THE ISSUE AS ANOTHER CRASH SENSOR (10370149). DEALERSHIP REPLACED SENSOR - COST $473. I FIND IT CONCERNING THAT AIR BAG SENSORS ARE FAILING ON A VEHICLE WITH LESS THAN 35,000 MILES. I'M NOT SURE IF THE SYSTEM IS FUNCTIONAL WHEN THESE SENSORS FAIL.
NHTSA ODI #10735600
41,500 miles · Jun 27, 2015
Air Bags
SERVICE AIRBAG MESSAGE APPEARS IN THE DIC (DIGITAL INFORMATION CENTER). SEEMS TO BE A VERY COMMON ISSUE ON THE CHEVROLET AVALANCHE.
NHTSA ODI #10730739
108,784 miles · Mar 13, 2015
Electrical System
THE SPEEDOMETER STICKS AT A SPEED AND WILL DROP TO THE 6 O'CLOCK POSITION. THIS IS A KNOW ISSUE AMONG OWNERS BUT GM NOR THE DEALERSHIPS ARE WILLING TO ACKNOWLEDGE OR FIX IT. THIS IS THE SECOND ISSUE WITH MY VEHICLE THAT GM IS NOT WILLING TO FIX OR TAKE RESPONSIBILITY. I WILL NEVER PURCHASE ANOTHER GM VEHICLE AGAIN. *TR
NHTSA ODI #10694091
110,600 miles · Mar 13, 2015
Fuel/propulsion System
AFTER DRIVING THE SMELL OF FUEL COMES FROM THE ENGINE BY THE DRIVERS DOOR. I CONTACTED GM AND MY VEHICLE DOES NOT SHOW ON THE LIST OF THIS KNOWN RECALL. THEY PASSED ME TO A LOCAL DEALERSHIP WHICH STATED MY VEHICLE IS NOT ONE THAT FALLS UNDER THE RECALL AND ADMITTED THEY HAD FIXED OTHERS WITH SIMILAR ISSUES. THIS IS APPALLING TH…
Read full complaint
AFTER DRIVING THE SMELL OF FUEL COMES FROM THE ENGINE BY THE DRIVERS DOOR. I CONTACTED GM AND MY VEHICLE DOES NOT SHOW ON THE LIST OF THIS KNOWN RECALL. THEY PASSED ME TO A LOCAL DEALERSHIP WHICH STATED MY VEHICLE IS NOT ONE THAT FALLS UNDER THE RECALL AND ADMITTED THEY HAD FIXED OTHERS WITH SIMILAR ISSUES. THIS IS APPALLING THAT A MANUFACTURE CAN ASSIST SOME CUSTOMERS BUT NOT ALL. I WILL NEVER PURCHASE ANOTHER GM VEHICLE AGAIN. *TR
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Avalanche Problems, Complaints & Recalls | Skip That Year
Illustration