TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR FLASHED AND REMAINED ILLUMINATED. THE DEALER STATED THAT THE DRIVER SIDE AIR BAG MODULE NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR FLASHED AND REMAINED ILLUMINATED. THE DEALER STATED THAT THE DRIVER SIDE AIR BAG MODULE NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.
NHTSA ODI #10723497
Mileage unknown · Nov 13, 2014
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, AN ELK JUMPED IN FRONT OF THE VEHICLE AND THE CONTACT ATTEMPTED TO AVOID A CRASH. AS A RESULT, THE CONTACT CRASHED INTO A DIRT MOUNTAIN. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT AND THE FRONT …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, AN ELK JUMPED IN FRONT OF THE VEHICLE AND THE CONTACT ATTEMPTED TO AVOID A CRASH. AS A RESULT, THE CONTACT CRASHED INTO A DIRT MOUNTAIN. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT AND THE FRONT PASSENGER SUSTAINED HEAD TRAUMA AND UPPER BODY INJURIES. THE CONTACT AND THE FRONT PASSENGER REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10654851
Mileage unknown · Sep 28, 2011
Air BagsCrashInjury
REAR ENDED A SUV AT 40 MPH WITHOUT BREAKING AND THE AIR BAGSA DID NOT DEPLOY. *TT
NHTSA ODI #10427782
47,000 miles · Jan 28, 2010
Air Bags
2004 CHEVY AVALANCHE SIR LIGHT (SERVICE AIRBAG) REMAINS ON CONSTANTLY AFTER SEVERAL ATTEMPTS TO REPAIR AT CHEVY DEALER. WHEN THE SERVICE AIRBAG LIGHT IS ON, THE AIRBAG SYSTEM WILL NOT DEPLOY AIRBAGS IF INVOLVED IN AN ACCIDENT. NO DEATH OR INJURY YET AND HOPEFULLY WILL NOT BE IN AN ACCIDENT WHILE DRIVING BACK AND FORTH TO THE DEA…
Read full complaint
2004 CHEVY AVALANCHE SIR LIGHT (SERVICE AIRBAG) REMAINS ON CONSTANTLY AFTER SEVERAL ATTEMPTS TO REPAIR AT CHEVY DEALER. WHEN THE SERVICE AIRBAG LIGHT IS ON, THE AIRBAG SYSTEM WILL NOT DEPLOY AIRBAGS IF INVOLVED IN AN ACCIDENT. NO DEATH OR INJURY YET AND HOPEFULLY WILL NOT BE IN AN ACCIDENT WHILE DRIVING BACK AND FORTH TO THE DEALER OVER AND OVER AGAIN. BUT HOW MUCH MONEY AND TIME SHOULD YOU SPEND ON SOMETHING THAT IS OUT OF YOUR CONTROL BUT COULD COST YOU YOUR LIFE IF AN EVENT OCCURS THAT YOU NEED THE AIRBAG TO DEPLOY. TW*
NHTSA ODI #10303079
45,000 miles · Apr 16, 2009
Air Bags
NO INJURIES. AIRBAG SYSTEM FLASHING ON AND OFF ON DASHBOARD DISPLAY INTERMITTENTLY. NO PARTICULAR PATTERN IN DRIVING CONDITIONS. TOOK TO DEALER AND PAID TO HAVE IT FIXED HOWEVER AFTER ABOUT 5 MONTHS IT STARTED AGAIN. BROUGHT IT IN A SECOND TIME AND AGAIN AFTER ABOUT 5 MONTHS STARTED AGAIN. DEALER CLAIMED IT WAS BAD WIRE AND…
Read full complaint
NO INJURIES. AIRBAG SYSTEM FLASHING ON AND OFF ON DASHBOARD DISPLAY INTERMITTENTLY. NO PARTICULAR PATTERN IN DRIVING CONDITIONS. TOOK TO DEALER AND PAID TO HAVE IT FIXED HOWEVER AFTER ABOUT 5 MONTHS IT STARTED AGAIN. BROUGHT IT IN A SECOND TIME AND AGAIN AFTER ABOUT 5 MONTHS STARTED AGAIN. DEALER CLAIMED IT WAS BAD WIRE AND REPLACED BUT WAS ALSO TOLD AIRBAGS WOULD NOT WORK IF IN A COLLISION. *TR
NHTSA ODI #10265689
34,000 miles · Jul 10, 2006
Air BagsSteeringCrash
DT*: THE CONTACT STATED WHILE DRIVING 20-35 MPH, THE VEHICLE VIOLENTLY VIBRATED. TOTAL CONTROL WAS LOST OF THE VEHICLE CAUSING THE VEHICLE TO VEER INTO THE OTHER LANE RESULTING IN THE VEHICLE HITTING THE SIDE OF A MOUNTAIN. THE AIR BAGS DID NOT DEPLOY. PRIOR TO THIS INCIDENT, POPPING NOISES WERE HEARD WHILE TURNING THE STEERIN…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 20-35 MPH, THE VEHICLE VIOLENTLY VIBRATED. TOTAL CONTROL WAS LOST OF THE VEHICLE CAUSING THE VEHICLE TO VEER INTO THE OTHER LANE RESULTING IN THE VEHICLE HITTING THE SIDE OF A MOUNTAIN. THE AIR BAGS DID NOT DEPLOY. PRIOR TO THIS INCIDENT, POPPING NOISES WERE HEARD WHILE TURNING THE STEERING WHEEL TO THE LEFT AND RIGHT GOING FORWARD AND IN REVERSE. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE THE DEALERSHIP DETERMINED THE PASSENGER SIDE TIE ROD WAS BROKEN. THERE WAS DAMAGE DONE TO THE VEHICLE. THERE WAS NOT A POLICE REPORT FILED.
NHTSA ODI #10161979
4,000 miles · Dec 30, 2005
Air Bags
DT: CONTACT COMPLAINED ABOUT AIR BAG SYSTEM PROBLEM. SINCE VEHICLE WAS NEWLY PURCHASED THE AIR BAG DASH LIGHT INTERMITTENTLY WENT ON AND OFF. AT ALLAN GREEN CHEVROLET SALES DEALER THEY TRIED TO CORRECT THE DEFECT THREE TIMES WITHOUT SUCCESS. CONTACT TOOK THE VEHICLE TO CAMINO REAL CHEVROLET, AND THEY COULD NOT CORRECT THE PROBL…
Read full complaint
DT: CONTACT COMPLAINED ABOUT AIR BAG SYSTEM PROBLEM. SINCE VEHICLE WAS NEWLY PURCHASED THE AIR BAG DASH LIGHT INTERMITTENTLY WENT ON AND OFF. AT ALLAN GREEN CHEVROLET SALES DEALER THEY TRIED TO CORRECT THE DEFECT THREE TIMES WITHOUT SUCCESS. CONTACT TOOK THE VEHICLE TO CAMINO REAL CHEVROLET, AND THEY COULD NOT CORRECT THE PROBLEM EITHER IN TWO ATTEMPTS. CONTACT DECIDED TO TAKE THE VEHICLE TO A THIRD DEALER, OSAMA CHEVROLET, THIS ONE TRIED FOUR TIMES, AND THE AIR BAGS LIGHT CONTINUES TO COME ON AND OFF. THE ROAD CONDITIONS AT EVERY INCIDENT HAVE BEEN NORMAL. CONTACT EXPRESSED CONCERN ABOUT THIS PROBLEM BECAUSE HE HAD NO CONFIDENCE THAT THE AIR BAGS SYSTEM WILL WORK IN CASE OF AN ACCIDENT . *AK UPDATED 02/07/06. *JB
NHTSA ODI #10146585
Mileage unknown · Oct 25, 2005
Air Bags
DT: THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT HAS BEEN HAVING PROBLEMS WITH AIR BAGS EVER SINCE LAST YEAR. THE AIR BAG LIGHT ILLUMINATED EVERY TIME HE TOOK THE VEHICLE TO THE DEALERSHIP. THEY SAID THEY FIXED IT AND LATER THE AIR BAG LIGHT CAME ON AGAIN. THE CONTACT TOOK VEHICLE BACK TO THE DEALERSHIP. THE DEAL…
Read full complaint
DT: THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT HAS BEEN HAVING PROBLEMS WITH AIR BAGS EVER SINCE LAST YEAR. THE AIR BAG LIGHT ILLUMINATED EVERY TIME HE TOOK THE VEHICLE TO THE DEALERSHIP. THEY SAID THEY FIXED IT AND LATER THE AIR BAG LIGHT CAME ON AGAIN. THE CONTACT TOOK VEHICLE BACK TO THE DEALERSHIP. THE DEALERSHIP TOLD HIM THAT THEY PUT SENSOR ON, AND DONE SOMETHING TO THE WIRING, AND EVERY TIME THE AIR BAG LIGHT CAME ON. THE AIR BAG LIGHT HAS BEEN COMING ON SINCE AUGUST 9, 2004. FROM THE TIME THAT THE DEALER SAID THAT THEY REPAIRED THE VEHICLE WAS ABOUT THREE WEEKS AND THE AIR BAG LIGHT CAME ON AGAIN. *AK EACH TIME THE VEHICLE WAS TAKEN TOT HE DEALER THEY REPLACED THE AIR BAG MODULE. *NM
NHTSA ODI #10136803
11,160 miles · May 16, 2005
Air Bags
DT: VEHICLE HAS HAD AIR BAG PROBLEMS, AND IT HAS BEEN IN AND OUT OF THE SHOP SINCE 12/29/2004. THEY HAVE NOT BEEN ABLE TO FIX IT. THE LIGHT COMES ON THAT SAYS TO SERVICE THE AIR BAGS. *TT
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
2004 Chevrolet Avalanche Problems, Complaints & Recalls | Skip That Year
Illustration