NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
115 reportsClear category filter37,000 miles · Oct 18, 2005
Parking BrakeService Brakes, Hydraulic
DT: THE CONTACT OWNS A 2002 AVALANCHE SPECIAL EDITION. AT 37,000 MILES HE HEARD THE BRAKES RUBBING. HE NOTICED THE INSIDE OF THE REAR BRAKES WORE OUT, NOT ON THE OUTSIDE. THE CONTACT STATED ABOUT ONE YEAR AGO HE HAD THE REAR BRAKES PADS REPLACED. IN ADDITION, THE CONTACT STATED THE EMERGENCY BRAKE WORE A GROOVE INSIDE THE R…
Read full complaint
DT: THE CONTACT OWNS A 2002 AVALANCHE SPECIAL EDITION. AT 37,000 MILES HE HEARD THE BRAKES RUBBING. HE NOTICED THE INSIDE OF THE REAR BRAKES WORE OUT, NOT ON THE OUTSIDE. THE CONTACT STATED ABOUT ONE YEAR AGO HE HAD THE REAR BRAKES PADS REPLACED. IN ADDITION, THE CONTACT STATED THE EMERGENCY BRAKE WORE A GROOVE INSIDE THE REAR ROTORS. HE CALLED A DEALER, AND THE DEALER TOLD HIM TO BRING THE CAR IN SO THEY COULD LOOK AT IT. THE CONTACT DID NOT WANT TO TAKE THE CAR TO DEALER. HE TOOK THE ROTORS AND THE BRAKE SHOES OFF THE CAR AND TOOK THEM TO THE DEALER. THE DEALER TOLD HIM HE SHOULD HAVE BROUGHT THE CAR IN AND LET THEM CHECK THE CAR OUT. THE CONTACT STATED HE HAS NEVER USED THE EMERGENCY BRAKE. HE DID WANT TO PAY FOR THE NEW ROTORS BECAUSE OF THE DAMAGE DONE TO THE ROTORS BY THE EMERGENCY BRAKE. *AK
NHTSA ODI #10140076
37,000 miles · Oct 6, 2005
Service Brakes, Hydraulic
MY 2002 AVALANCHE HAS, THREE TIMES THIS YEAR, EXPERIENCED THE PROBLEM NOTED IN THE BRAKE RECALL WHERE , AT LOW SPEEDS, THE BRAKES FAIL TO APPLY. IT IS A VERY SCARY FEELING AND OCCURS MOSTLY IN STOP AND GO TRAFFIC. THE FIRST 2 TIMES IT HAPPENED I THOUGHT I HAD PLACED MY LEFT FOOT SIDEWAYS UNDER THE BRAKE PEDAL, BECAUSE NO MATT…
Read full complaint
MY 2002 AVALANCHE HAS, THREE TIMES THIS YEAR, EXPERIENCED THE PROBLEM NOTED IN THE BRAKE RECALL WHERE , AT LOW SPEEDS, THE BRAKES FAIL TO APPLY. IT IS A VERY SCARY FEELING AND OCCURS MOSTLY IN STOP AND GO TRAFFIC. THE FIRST 2 TIMES IT HAPPENED I THOUGHT I HAD PLACED MY LEFT FOOT SIDEWAYS UNDER THE BRAKE PEDAL, BECAUSE NO MATTER HOW HARD I PUSHED THE PEDAL, NOTHING HAPPENED. I WAS PRETTY SURE I DIDN'T HAVE MY FOOT UNDER THE PEDAL. NOW I KNOW I HADN'T. MY PROBLEM IS THAT NOW I HEAR THAT THIS RECALL DOES NOT INCLUDE MY STATE BECAUSE WE DON'T USE ENOUGH SALT OR THERE ARE NOT ENOUGH COMPLAINTS! YOU GOT TO BE KIDDING! I WILL GUARANTEE GM THAT THIS WILL COST THEM HUGE IF I GET IN AN ACCIDENT. I DON'T CARE WHAT THE EXTENT OF DAMAGE IS. THIS IS RIDICULOUS, SHORTSIGHTED AND IDIOTIC. I HAVE CONTACTED THE DEALER, THE ZONE OFFICE, MY INSURANCE COMPANY AND MY ATTORNEY. MY INSURANCE COMPANY AND ATTY STATED THAT I NEED TO KEEP GOOD NOTES AND DO AS MUCH RESEARCH AS POSSIBLE. MY DEALER SAID "BRING IT IN" BUT PROBABLY WON'T COVER IT - MAYBE LATER. I STILL HAVEN'T HEARD FROM THE ZONE OFFICE. MY WIFE CAN'T BELIEVE HOW UPSET I AM OVER THIS. I AM CURRENTLY RESEARCHING HOW MUCH SALT IS USED IN THE WINTERS HERE. I WILL NOT STAND FOR THIS. *NM
NHTSA ODI #10138925
52,000 miles · Sep 30, 2005
Service Brakes, Hydraulic
VEHICLE = 2002 CHEVROLET AVALANCHE 52000 MILES -- AT A SLOW RATE OF SPEED THE BRAKES DO NOT STOP THE VEHICLE AND THE ANTI LOCKS CHATTER... WHEN ASKING MY DEALER THEY HAVE TOLD ME THE RECALL DOES NOT INCLUDE MARYLAND...... I HAVE DISABLE MY ANTI LOCK BRAKES FOR NOW AND THIS RELIEVED THE PROBLEM, BUT WHEN REACTIVATED THE PRO…
Read full complaint
VEHICLE = 2002 CHEVROLET AVALANCHE 52000 MILES -- AT A SLOW RATE OF SPEED THE BRAKES DO NOT STOP THE VEHICLE AND THE ANTI LOCKS CHATTER... WHEN ASKING MY DEALER THEY HAVE TOLD ME THE RECALL DOES NOT INCLUDE MARYLAND...... I HAVE DISABLE MY ANTI LOCK BRAKES FOR NOW AND THIS RELIEVED THE PROBLEM, BUT WHEN REACTIVATED THE PROBLEM REMAINS -- WILL YOU PLEASE INCLUDE MARYLAND IN YOUR RECALL CAMPAIGN # 05V37900 THANK YOU FOR YOUR CONSIDERATION IN THIS MATTER. P.S. I LIVE IN THE NORTH / WEST PART OF MARYLAND ELEVATION AROUND 26000 TO 29000 FEET AND WE GET LOTS OF SNOW AND ICE NOT UNLIKE THE OTHER AREAS OF THE RECALL. THANKS AGAIN, RANDY. *JB
NHTSA ODI #10138208
Mileage unknown · Sep 28, 2005
Service Brakes, Hydraulic
CONSUMERS 2002 AVALANCHE ROTORS CORRODED PREMATURELY WHICH LED TO HAVING THE ROTORS AND PADS REPLACED. *TS THE CONSUMER RECEIVED RECALL # 05V379000 WHICH WAS IN REFERENCE TO THE ROTORS AFTER THE ROTORS WERE ALREADY REPLACED. BASED ON THE CONSUMER'S RESEARCH HE BELIEVES THAT THE ROTORS ON THE VEHICLE'S SOLD IN THE SALT BELT WER…
Read full complaint
CONSUMERS 2002 AVALANCHE ROTORS CORRODED PREMATURELY WHICH LED TO HAVING THE ROTORS AND PADS REPLACED. *TS THE CONSUMER RECEIVED RECALL # 05V379000 WHICH WAS IN REFERENCE TO THE ROTORS AFTER THE ROTORS WERE ALREADY REPLACED. BASED ON THE CONSUMER'S RESEARCH HE BELIEVES THAT THE ROTORS ON THE VEHICLE'S SOLD IN THE SALT BELT WERE NOT PROPERLY TREATED WITH A CORROSION INHIBITOR. THE ROTORS ON THE CONSUMER'S VEHICLE HAD TO BE REPLACED AFTER ONLY 28 MONTHS OF USE. THE PREMATURE ROTOR CORROSION LED TO PREMATURE CORROSION OF THE BACKING PLATE ON THE RIGHT REAR. *NM
NHTSA ODI #10138847
40,000 miles · Sep 19, 2005
Parking BrakeService Brakes, Hydraulic
DT: THE CONTACT STATED THE PARKING BRAKE ON 2002 CHEVROLET AVALANCHE WAS BAD. THE PADS WERE COMPLETELY WORN OUT .THE BRAKE WAS NONFUNCTIONAL. THIS HAPPENED BECAUSE OF A DEFECT IN THE DESIGN, NOT BECAUSE OF THE BRAKE. THE PADS NEEDED TO BE CHANGED, AND THE ROTORS NEEDED TO BE SANDED. THE MECHANIC SAID THE DESIGN WAS SUCH THAT …
Read full complaint
DT: THE CONTACT STATED THE PARKING BRAKE ON 2002 CHEVROLET AVALANCHE WAS BAD. THE PADS WERE COMPLETELY WORN OUT .THE BRAKE WAS NONFUNCTIONAL. THIS HAPPENED BECAUSE OF A DEFECT IN THE DESIGN, NOT BECAUSE OF THE BRAKE. THE PADS NEEDED TO BE CHANGED, AND THE ROTORS NEEDED TO BE SANDED. THE MECHANIC SAID THE DESIGN WAS SUCH THAT THE PARKING BRAKE WILL WEAR OUT EVEN IF IT WAS NOT USED. THE CONTACT HAS NOT BEEN USING THE PARKING BRAKE. HE WAS TOLD THAT THE PADS NEEDED TO BE CHANGED WHEN HE TOOK THE VEHICLE TO DEALER FOR INSPECTION ON SEPTEMBER 1, 2005. *AK
NHTSA ODI #10136964
79,000 miles · Sep 7, 2005
Service Brakes, Hydraulic
2002 CHEVROLET AVALANCHE ABS RECALL NOTICE...MINNESOTA NOT INCLUDED IN RECALL DUE TO SALT CORROSION. *JB
NHTSA ODI #10135697
Mileage unknown · Sep 5, 2005
Service Brakes, Hydraulic
NHTSA CAMPAIGN ID NUMBER : 05V379000 MY AVALANCHE SUFFERS FROM THIS EXACT SYMPTOM. UNFORTUNATELY I LIVE IN MINNESOTA... AND THE NHTSA HAS DECIDED TO LEAVE MINNESOTA AND WISCONSIN OFF THE "SALT BELT" LIST. THE STATE OF MINNESOTA USES MORE SALT AND CACL ON OUR ROADS THAN ANY OF THOSE 2 STATES COMBINED. FOR PROOF YOU CAN LOO…
Read full complaint
NHTSA CAMPAIGN ID NUMBER : 05V379000 MY AVALANCHE SUFFERS FROM THIS EXACT SYMPTOM. UNFORTUNATELY I LIVE IN MINNESOTA... AND THE NHTSA HAS DECIDED TO LEAVE MINNESOTA AND WISCONSIN OFF THE "SALT BELT" LIST. THE STATE OF MINNESOTA USES MORE SALT AND CACL ON OUR ROADS THAN ANY OF THOSE 2 STATES COMBINED. FOR PROOF YOU CAN LOOK AT THE BOTTOM OF MY RUSTING TRUCK. PLEASE ADD MY STATE TO THIS RECALL OR AT LEAST CONTACT ME ON HOW I CAN HAVE MY TRUCK SERVICED UNDER THIS RECALL. DETAILS: 2002 CHEVROLET AVALANCHE 2500 4X4 [XXX] PLEASE CONTACT ME ABOUT WHAT I CAN DO TO BE INCLUDED IN THIS RECALL. UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10135349
29,350 miles · Sep 2, 2005
Parking BrakeService Brakes, Hydraulic
DT: CONTACT STATED THE BRAKES HAD A GRINDING NOISE. CONTACT REPLACED THEM ON 7-23-05. HE PULLED THE WHEEL OFF, AND EVERY SINGLE BRAKE AND ROTOR WAS DEFECTIVE. THE PADS WERE DEFECTIVE. HE TOOK A SLEDGE HAMMER TO GET THEM OFF. THERE WAS INCH PAD TOUCHING THE BRAKES, AND THAT WAS THE ONLY THING STOPPING THE VEHICLE. REPLAC…
Read full complaint
DT: CONTACT STATED THE BRAKES HAD A GRINDING NOISE. CONTACT REPLACED THEM ON 7-23-05. HE PULLED THE WHEEL OFF, AND EVERY SINGLE BRAKE AND ROTOR WAS DEFECTIVE. THE PADS WERE DEFECTIVE. HE TOOK A SLEDGE HAMMER TO GET THEM OFF. THERE WAS INCH PAD TOUCHING THE BRAKES, AND THAT WAS THE ONLY THING STOPPING THE VEHICLE. REPLACED THEM, AND HE BROUGHT THE PARTS TO THE DEALER, WHO SAID THERE WAS NOTHING HE COULD DO. ALSO, CALLED GENERAL MOTORS, WHO INDICATED THAT THIS WAS NORMAL. THE CAR ONLY HAD 29,000 MILES ON IT. CONTACT HAD A BRAKE PROBLEM SINCE HE BOUGHT THE CAR. THERE WERE MORE PADS LEFT ON THE FRONT BRAKES, WHICH WAS UNCOMMON. THE BRAKE PADS WERE HARDER THAN THE ROTORS. IN ADDITION, THE REAR BRAKES WERE DEFECTIVE. THE DUST COVERS FOR THE REAR BRAKES WERE GONE . *AK THE BRAKES GAVE NO WARNING THAT THERE WAS A PROBLEM. THE EMERGENCY BRAKE DID NOT WORK. *JB
NHTSA ODI #10130446
67,000 miles · Aug 31, 2005
Service Brakes, Hydraulic
DT: WHEN APPLYING THE BRAKES THERE WAS A DELAY IN STOPPING. THE CONSUMER FIRST EXPERIENCED THE PROBLEM ON 7-15-05. THE CONSUMER TOOK VEHICLE TO THE DEALERSHIP AND THEY TOLD HIM THAT THE ABS CONTROL MODULE NEEDED TO BE REPLACED. ALSO, THERE WAS CONSTANT NOISE COMING FROM THE ABS CONTROL MODULE EVEN WHEN THE VEHICLE WAS …
Read full complaint
DT: WHEN APPLYING THE BRAKES THERE WAS A DELAY IN STOPPING. THE CONSUMER FIRST EXPERIENCED THE PROBLEM ON 7-15-05. THE CONSUMER TOOK VEHICLE TO THE DEALERSHIP AND THEY TOLD HIM THAT THE ABS CONTROL MODULE NEEDED TO BE REPLACED. ALSO, THERE WAS CONSTANT NOISE COMING FROM THE ABS CONTROL MODULE EVEN WHEN THE VEHICLE WAS TURNED OFF. THE CONSUMER HAD TO REPLACE A BATTERY BECAUSE OF THIS. THE DEALERSHIP UNHOOKED THE FUSE TO MAKE IT STOP. THE CONSUMER EXPERIENCED THE SAME PROBLEM THAT WAS INCLUDED IN NHTSA RECALL 05V379000/GM RECALL 05068 . WHEN CONTACTING THE MANUFACTURER, THEY TOLD CONSUMER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
NHTSA ODI #10135010
42,000 miles · Aug 31, 2005
Service Brakes, Hydraulic
NHTSA DOCUMENT 05V379000 DESCRIBES THE EXACT ABS PROBLEM I HAVE ON MY 2002 CHEVROLET AVALANCHE 1500 TRUCK. THE CURRENT GM RECALL IS NOT BROAD ENOUGH TO CONSIDER THE CONDITIONS WE HAVE IN FL, AND RESTRICTING THIS TO NORTHERN STATES IS LUDICROUS IF THIS IS A CONSISTENT MANUFACTURER DEFECT ACROSS ALL STATES/VEHICLES. SALT AIR AND…
Read full complaint
NHTSA DOCUMENT 05V379000 DESCRIBES THE EXACT ABS PROBLEM I HAVE ON MY 2002 CHEVROLET AVALANCHE 1500 TRUCK. THE CURRENT GM RECALL IS NOT BROAD ENOUGH TO CONSIDER THE CONDITIONS WE HAVE IN FL, AND RESTRICTING THIS TO NORTHERN STATES IS LUDICROUS IF THIS IS A CONSISTENT MANUFACTURER DEFECT ACROSS ALL STATES/VEHICLES. SALT AIR AND TOWING A BOAT (IE DIRECT WHEEL CONTACT WITH SALT WATER ON THE RAMP) VERY POSSIBLY HAVE LED TO MY PROBLEM. WHEN APPLYING THE BRAKES AT APPROX 4-5 MPH THE ABS WENT ON AND I VERY NARROWLY MISSED HITTING A VEHICLE IN FRONT OF ME BECAUSE THE TRUCK DID NOT WANT TO BRAKE/SLOW DOWN. *NM
NHTSA ODI #10134943
NHTSA investigations
7PE10010 · Brake Line Corrosion Failure
Opened Mar 30, 2010 · Closed Jan 5, 2011
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Additional source detail variants (2)
Service Brakes, Hydraulic
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
PE06016 · Crank Position Sensor Failure - Stall
Opened May 4, 2006 · Closed Sep 14, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE06-016) ON MAY 4, 2006 BASED ON ELEVEN VEHICLE OWNER QUESTIONNAIRES (VOQS) AND EARLY WARNING (EWR) DATA ALLEGING SUDDEN ENGINE SHUTDOWN WHILE DRIVING AS A RESULT OF CRANK POSITION SENSOR FAILURES IN MY 2001-2002 GENERAL MOTORS C/K PLATFORM VEHICLES EQUIPPED WITH 8.1L ENGINES.IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY ODI, GENERAL MOTORS (GM) PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA BASED ON A POPULATION OF 108,338 VEHICLES. THE DATA WAS CATEGORIZED BY ENGINE STALLS WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND CLAIMS WHERE IT WAS INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.GENERAL MOTOR'S RESPONSE INCLUDED 1,213 OWNER COMPLAINTS AND FIELD REPORTS OF WHICH 289 WERE CATEGORIZED AS ENGINE STALLS WHILE DRIVING ALLEGEDLY CAUSED BY CRANK POSITION SENSOR FAILURES. GENERAL MOTORS ALSO SUBMITTED WARRANTY CLAIMS FROM ITS REGULAR WARRANTY (5 YEARS/50,000 MILES) AND FROM ITS EXTENDED WARRANTY DATABASE. FROM THE REGULAR WARRANTY DATABASE THERE WERE 3,140 CLAIMS OF CRANK POSITION SENSOR REPLACEMENT OF WHICH 147 CLAIMS WERE FROM CONSUMERS ALLEGING ENGINE STALL WHILE DRIVING.GM STATED THAT 2,841 OF THE CLAIMS WERE INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.FROM ITS EXTENDED WARRANTY DATABASE, GM SUBMITTED 1,561 CLAIMS OF CRANK POSITION SENSOR FAILURE THAT IT ALSO STATED WERE INDETERMINATE AS TO WHETHER AN ENGINE STALL OCCURRED WHILE DRIVING.IN TOTAL, GM REPORTS 4,701 CLAIMS OF CRANK POSITION SENSOR FAILURE COMBINING REGULAR WARRANTY AND EXTENDED WARRANTY.SIMILAR TO GM'S STATISTICAL ANALYSIS, ODI'S ANALYSIS SHOWED THAT THE FAILURE RATE FOR WARRANTY CLAIMS OF ENGINE STALL WHILE DRIVING AT THREE YEARS IN SERVICE IS LOW (LESS THAN 1%).HOWEVER, FURTHER ANALYSIS DETERMINED THAT THE MY 2001 VEHICLE BUILD PERIOD FROM MAY 2000 THROUGH OCTOBER 2000 HAD SIGNIFICANTLY HIGHER (MORE THAN FOUR TIMES) CRANK POSITION FAILURE RATES IN BOTH CONSUMER COMPLAINT DATA AND WARRANTY CLAIM DATA THAN IN THE BUILD PERIOD FROM NOVEMBER 2000 THROUGH JULY 2001.ADDING THE CLAIMS OF KNOWN ENGINE STALL WHILE DRIVING AND CLAIMS WHERE ENGINE STALL WAS INDETERMINATE, THE FAILURE RATE AT THREE YEARS IN SERVICE FOR THIS POPULATION IS OVER 6%.AN ENGINEERING ANALYSIS (EA06-016) HAS BEEN OPENED TO FURTHER ASSESS THE FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN VEHICLES BUILT FROM MAY 2000 THROUGH OCTOBER 2000.
Additional source detail variants (2)
Engine And Engine Cooling:engine
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE06-016) ON MAY 4, 2006 BASED ON ELEVEN VEHICLE OWNER QUESTIONNAIRES (VOQS) AND EARLY WARNING (EWR) DATA ALLEGING SUDDEN ENGINE SHUTDOWN WHILE DRIVING AS A RESULT OF CRANK POSITION SENSOR FAILURES IN MY 2001-2002 GENERAL MOTORS C/K PLATFORM VEHICLES EQUIPPED WITH 8.1L ENGINES.IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY ODI, GENERAL MOTORS (GM) PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA BASED ON A POPULATION OF 108,338 VEHICLES. THE DATA WAS CATEGORIZED BY ENGINE STALLS WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND CLAIMS WHERE IT WAS INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.GENERAL MOTOR'S RESPONSE INCLUDED 1,213 OWNER COMPLAINTS AND FIELD REPORTS OF WHICH 289 WERE CATEGORIZED AS ENGINE STALLS WHILE DRIVING ALLEGEDLY CAUSED BY CRANK POSITION SENSOR FAILURES. GENERAL MOTORS ALSO SUBMITTED WARRANTY CLAIMS FROM ITS REGULAR WARRANTY (5 YEARS/50,000 MILES) AND FROM ITS EXTENDED WARRANTY DATABASE. FROM THE REGULAR WARRANTY DATABASE THERE WERE 3,140 CLAIMS OF CRANK POSITION SENSOR REPLACEMENT OF WHICH 147 CLAIMS WERE FROM CONSUMERS ALLEGING ENGINE STALL WHILE DRIVING.GM STATED THAT 2,841 OF THE CLAIMS WERE INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.FROM ITS EXTENDED WARRANTY DATABASE, GM SUBMITTED 1,561 CLAIMS OF CRANK POSITION SENSOR FAILURE THAT IT ALSO STATED WERE INDETERMINATE AS TO WHETHER AN ENGINE STALL OCCURRED WHILE DRIVING.IN TOTAL, GM REPORTS 4,701 CLAIMS OF CRANK POSITION SENSOR FAILURE COMBINING REGULAR WARRANTY AND EXTENDED WARRANTY.SIMILAR TO GM'S STATISTICAL ANALYSIS, ODI'S ANALYSIS SHOWED THAT THE FAILURE RATE FOR WARRANTY CLAIMS OF ENGINE STALL WHILE DRIVING AT THREE YEARS IN SERVICE IS LOW (LESS THAN 1%).HOWEVER, FURTHER ANALYSIS DETERMINED THAT THE MY 2001 VEHICLE BUILD PERIOD FROM MAY 2000 THROUGH OCTOBER 2000 HAD SIGNIFICANTLY HIGHER (MORE THAN FOUR TIMES) CRANK POSITION FAILURE RATES IN BOTH CONSUMER COMPLAINT DATA AND WARRANTY CLAIM DATA THAN IN THE BUILD PERIOD FROM NOVEMBER 2000 THROUGH JULY 2001.ADDING THE CLAIMS OF KNOWN ENGINE STALL WHILE DRIVING AND CLAIMS WHERE ENGINE STALL WAS INDETERMINATE, THE FAILURE RATE AT THREE YEARS IN SERVICE FOR THIS POPULATION IS OVER 6%.AN ENGINEERING ANALYSIS (EA06-016) HAS BEEN OPENED TO FURTHER ASSESS THE FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN VEHICLES BUILT FROM MAY 2000 THROUGH OCTOBER 2000.
Engine And Engine Cooling
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE06-016) ON MAY 4, 2006 BASED ON ELEVEN VEHICLE OWNER QUESTIONNAIRES (VOQS) AND EARLY WARNING (EWR) DATA ALLEGING SUDDEN ENGINE SHUTDOWN WHILE DRIVING AS A RESULT OF CRANK POSITION SENSOR FAILURES IN MY 2001-2002 GENERAL MOTORS C/K PLATFORM VEHICLES EQUIPPED WITH 8.1L ENGINES.IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY ODI, GENERAL MOTORS (GM) PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA BASED ON A POPULATION OF 108,338 VEHICLES. THE DATA WAS CATEGORIZED BY ENGINE STALLS WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND CLAIMS WHERE IT WAS INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.GENERAL MOTOR'S RESPONSE INCLUDED 1,213 OWNER COMPLAINTS AND FIELD REPORTS OF WHICH 289 WERE CATEGORIZED AS ENGINE STALLS WHILE DRIVING ALLEGEDLY CAUSED BY CRANK POSITION SENSOR FAILURES. GENERAL MOTORS ALSO SUBMITTED WARRANTY CLAIMS FROM ITS REGULAR WARRANTY (5 YEARS/50,000 MILES) AND FROM ITS EXTENDED WARRANTY DATABASE. FROM THE REGULAR WARRANTY DATABASE THERE WERE 3,140 CLAIMS OF CRANK POSITION SENSOR REPLACEMENT OF WHICH 147 CLAIMS WERE FROM CONSUMERS ALLEGING ENGINE STALL WHILE DRIVING.GM STATED THAT 2,841 OF THE CLAIMS WERE INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.FROM ITS EXTENDED WARRANTY DATABASE, GM SUBMITTED 1,561 CLAIMS OF CRANK POSITION SENSOR FAILURE THAT IT ALSO STATED WERE INDETERMINATE AS TO WHETHER AN ENGINE STALL OCCURRED WHILE DRIVING.IN TOTAL, GM REPORTS 4,701 CLAIMS OF CRANK POSITION SENSOR FAILURE COMBINING REGULAR WARRANTY AND EXTENDED WARRANTY.SIMILAR TO GM'S STATISTICAL ANALYSIS, ODI'S ANALYSIS SHOWED THAT THE FAILURE RATE FOR WARRANTY CLAIMS OF ENGINE STALL WHILE DRIVING AT THREE YEARS IN SERVICE IS LOW (LESS THAN 1%).HOWEVER, FURTHER ANALYSIS DETERMINED THAT THE MY 2001 VEHICLE BUILD PERIOD FROM MAY 2000 THROUGH OCTOBER 2000 HAD SIGNIFICANTLY HIGHER (MORE THAN FOUR TIMES) CRANK POSITION FAILURE RATES IN BOTH CONSUMER COMPLAINT DATA AND WARRANTY CLAIM DATA THAN IN THE BUILD PERIOD FROM NOVEMBER 2000 THROUGH JULY 2001.ADDING THE CLAIMS OF KNOWN ENGINE STALL WHILE DRIVING AND CLAIMS WHERE ENGINE STALL WAS INDETERMINATE, THE FAILURE RATE AT THREE YEARS IN SERVICE FOR THIS POPULATION IS OVER 6%.AN ENGINEERING ANALYSIS (EA06-016) HAS BEEN OPENED TO FURTHER ASSESS THE FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN VEHICLES BUILT FROM MAY 2000 THROUGH OCTOBER 2000.
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
EA04005 · Tailgate Cable Breakage
Opened Feb 19, 2004 · Closed Sep 28, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Additional source detail variants (6)
Latches/locks/linkages:tailgate:latch
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Latches/locks/linkages:tailgate:latch
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
Illustration