NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
10 reportsClear category filter250,000 miles · Feb 26, 2018
Service BrakesSteering
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 45 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE PUMP FAILED AND NEEDED TO BE …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 45 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V043000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.
NHTSA ODI #11074968
190,000 miles · Feb 2, 2016
Steering
VEHICLE DEVELOPED A CLUNKING , WHILE DRIVING, THAT CAN BE FELT IN THE STEERING WHEEL. IT DOES NOT MATTER THE TYPE OF ROAD. MECHANIC ADVISED THAT IT WAS THE STEERING SHAFT.
NHTSA ODI #10823717
35,000 miles · Jun 3, 2009
Steering
LOUD POPPING SOUND FROM CROSSMEMBER AND, DEFECTIVE INTERMEDIATE SHAFT ON STEERING. 2004 CHEVY AVALANCHE. *TR
NHTSA ODI #10272792
Mileage unknown · Mar 3, 2009
Steering
THE STEERING GEAR BOXES ON MOST GM TRUCKS. THEY HAVE TO BE TAKEN TO DEALER FOR SERVICE EVERY 30,000 MI 150 DOLLAR CHARGE. IT MAKES YOU THINK THERE IS SOMETHING LOOSE IN THE FRONT END. HAD MINE REPLACES BUT AFTER 30,000 MI. IT'S BACK. *TR
NHTSA ODI #10260624
86,000 miles · Feb 6, 2009
Service Brakes, HydraulicSteeringStructure
TL*THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. THE CONTACT STATED THAT THE TAILGATE STRAPS WERE RUSTY AND BEGINNING TO FAIL. IN ADDITION, THE ABS SPEED SENSOR WAS SLOW AT STOPPING THE VEHICLE. THE ABS WOULD PULSE AND THE VEHICLE WOULD TAKE LONGER TO STOP. THE STEERING WHEEL WAS LOOSE AND VIBRATED WHEN DRIVING OVER A BU…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE 1500. THE CONTACT STATED THAT THE TAILGATE STRAPS WERE RUSTY AND BEGINNING TO FAIL. IN ADDITION, THE ABS SPEED SENSOR WAS SLOW AT STOPPING THE VEHICLE. THE ABS WOULD PULSE AND THE VEHICLE WOULD TAKE LONGER TO STOP. THE STEERING WHEEL WAS LOOSE AND VIBRATED WHEN DRIVING OVER A BUMP. THE SHAFT BUSHING IS ALSO FAILING IN THE STEERING WHEEL COLUMN. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS FOR THE FAILURES; THEREFORE, THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS. THE FAILURE MILEAGE WAS 86,000. UPDATED 3/5/09 *CN UPDATED 03/10/09. *JB
NHTSA ODI #10257709
80,000 miles · Oct 24, 2008
EquipmentService Brakes, HydraulicSteering
I AM UNABLE TO DRIVE MY 2004 CHEVY AVALANCHE DUE TO THE HYDRAULIC BRAKE SYSTEM GOING OUT WHICH MAKES THE POWER STEERING GO OUT AS WELL. PRIOR TO THE SYSTEM GOING COMPLETELY OUT IT OCCASIONALLY IT WOULD BE HARD TO TURN THE STEERI NG WHEEL UPON STARTING UP THE VEHICLE I CONTACTED THE RECALL DEPARTMENT IN REFERENCED TO THIS BUT THE…
Read full complaint
I AM UNABLE TO DRIVE MY 2004 CHEVY AVALANCHE DUE TO THE HYDRAULIC BRAKE SYSTEM GOING OUT WHICH MAKES THE POWER STEERING GO OUT AS WELL. PRIOR TO THE SYSTEM GOING COMPLETELY OUT IT OCCASIONALLY IT WOULD BE HARD TO TURN THE STEERI NG WHEEL UPON STARTING UP THE VEHICLE I CONTACTED THE RECALL DEPARTMENT IN REFERENCED TO THIS BUT THEY STATED THAT EVEN THOUGH MY VEHICLE IS THE YEAR AND MODEL FITTING THE RECALL MY VIN DOES NOT FALL IN THE BATCH. WHY IS THIS WHEN I AM HAVING THE PROBLEM WHICH ALMOST CAUSED ME TO HAVE AN ACCIDENT DUE TO THE BRAKES GOING OUT. CAN THIS BE RECTIFIED. I HAD THE PROBLEM REPAIRED BUT IT STARTED AGAIN. *TR
NHTSA ODI #10246610
56,000 miles · Jan 28, 2008
Steering
THERE IS POPPING AND TWISTING MOTIONS IN THE STEERING COLUMN OF MY 04 AVALANCHE, IT CAME FROM THE FACTORY LIKE THAT AS I WAS TOLD. MY STEERING WHEEL EVENTUALLY TWISTED ALL THE WAY AROUND WITHOUT TURNING THE TIRES ONE DAY... THANK GOD NO ACCIDENT. VERY SERIOUS ISSUE WAS TOLD ALL AVALANCHES IN THIS YEAR POP AND TWIST LIKE THAT. HA…
Read full complaint
THERE IS POPPING AND TWISTING MOTIONS IN THE STEERING COLUMN OF MY 04 AVALANCHE, IT CAME FROM THE FACTORY LIKE THAT AS I WAS TOLD. MY STEERING WHEEL EVENTUALLY TWISTED ALL THE WAY AROUND WITHOUT TURNING THE TIRES ONE DAY... THANK GOD NO ACCIDENT. VERY SERIOUS ISSUE WAS TOLD ALL AVALANCHES IN THIS YEAR POP AND TWIST LIKE THAT. HAD TO REPLACE STEERING COLUMN. OLD PART IS AT LANDFILL. *TR
NHTSA ODI #10216313
41,016 miles · Aug 27, 2007
Steering
STEERING SOME TIMES MAKING A KNOCKING TYPE NOISE, BROUGHT TO DEALER STEERING SHAFT NEEDED TO BE REPLACED WAS TOLD CHEVY KNOWS ABOUT THE PROBLEM. *TR
NHTSA ODI #10200843
92,000 miles · Jun 21, 2007
Steering
AT IDOL OR LOW SPEEDS LIKE PULLING INTO A PARKING SPACE, IT WAS AS IF MY 2004 AVALANCHE HAD NO POWER STEERING TO THE RIGHT AND ONLY THE RIGHT. UPON TAKING IT TO A MECHANIC, THEY PULLED UP A SERVICE BULLETIN STATING THERE IS A PROBLEM WITH THE STEERING BOX AND THERE IS A REDISIGNED STEERING BOX AND SHOULD BE REPLACED , I DONE TH…
Read full complaint
AT IDOL OR LOW SPEEDS LIKE PULLING INTO A PARKING SPACE, IT WAS AS IF MY 2004 AVALANCHE HAD NO POWER STEERING TO THE RIGHT AND ONLY THE RIGHT. UPON TAKING IT TO A MECHANIC, THEY PULLED UP A SERVICE BULLETIN STATING THERE IS A PROBLEM WITH THE STEERING BOX AND THERE IS A REDISIGNED STEERING BOX AND SHOULD BE REPLACED , I DONE THAT AND $732.96 LATER THE PROBLEM IS FIXED AT MY EXPENCE WHEN IT IS THEIR POOR DISIGN. SIDE KNOTE: MY WIFES A CANCER PATIENT, I SHOULD BE PAYING DR. BILLS WITH THAT MONEY!!!!!
NHTSA ODI #10193881
61,500 miles · Feb 6, 2007
Steering
IN THE MORNING - BELOW SAY ABOUT 55 DEGREES WHEN I FIRST GET IN AND DRIVE, I HAVE TO TURN THE WHEELS TO THE LEFT TO EXIT MY DRIVEWAY. FOR THE FIRST MINUTE OR TWO, THE STEERING IS VERY STIFF, ALMOST LIKE MANUAL - THEN IT GOES NORMAL FOR THE REMAINDER OF THE DAY.
NHTSA ODI #10181812
Illustration