SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2001 Chevrolet Astro

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2001 Chevrolet Astro do not stand out strongly from the model-year median of 69.

Counts are not adjusted for sales, age, mileage exposure or reporting. A lower count does not establish that a car is problem-free.

About this comparison →
91Owner complaints

Model-year median: 69

1Recall campaigns

View recall details →

1Investigations

View investigation details →

Check a VIN with NHTSA ↗ Model-level counts do not show whether a particular VIN is affected or repaired.

Inspection summary

2001 Chevrolet Astro

NHTSA snapshot: September 18, 2026. 91 owner complaints · 1 recall campaigns · 1 investigations.

Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.

Top reported categories (up to 5)

  • Service Brakes, Hydraulic: 28 reports
  • Exterior Lighting: 19 reports
  • Electrical System: 7 reports
  • Suspension: 6 reports
  • Power Train: 5 reports

Full reported-category list and vehicle report

Recall links

Check a VIN with NHTSA. Model-level history does not establish whether a particular VIN is affected or repaired.

Print the top reported categories, recall links, snapshot date and comparison limits.

How this year compares

Owner complaints by model year

Other model years Selected year
241
1998133
1999175
200091
200170
200262
200314
2004
Compare all Astro years →

Counts vary with age, sales, mileage exposure and reporting. They are not failure rates.

What owners reported most

Service Brakes, Hydraulic
28Exterior Lighting
19Electrical System
7Suspension
6Power Train
5
All reported categories
Seat Belts
5Structure
5Engine And Engine Cooling
4Fuel System, Gasoline
4Service Brakes
4Vehicle Speed Control
4Steering
3Air Bags
2Tires
2Visibility
2Equipment
1Fuel/propulsion System
1Latches/locks/linkages
1Service Brakes, Air
1Service Brakes, Electric
1Unknown Or Other
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

61 reports with mileage · 30 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports1 fire reports2 injury reports

Tires complaints

2 reports
Clear category filter
125,150 miles · Sep 15, 2009
Tires

NOTICED MY TIRE LOSING AIR AND HAVE TO FILL IT. UPON FILLING, I SAW A SPLIT IN THE TIRE AND SILVER METAL SHOWING THROUGH. THE TIRE IS SPLITTING ON THE SIDEWALL AND YET I HAVE LOTS OF TREAD LEFT ON THE TIRE. ALL THE OTHER TIRES ARE SHOWING A "RING" OF DETERIORATION AS WELL. YET THEY ALL HAVE SIGNIFICANT TREAD LEFT ON THEM. WE WER…

Read full complaint

NOTICED MY TIRE LOSING AIR AND HAVE TO FILL IT. UPON FILLING, I SAW A SPLIT IN THE TIRE AND SILVER METAL SHOWING THROUGH. THE TIRE IS SPLITTING ON THE SIDEWALL AND YET I HAVE LOTS OF TREAD LEFT ON THE TIRE. ALL THE OTHER TIRES ARE SHOWING A "RING" OF DETERIORATION AS WELL. YET THEY ALL HAVE SIGNIFICANT TREAD LEFT ON THEM. WE WERE TOLD THE TIRES WERE NEW WHEN WE PURCHASED THE VEHICLE IN FALL 2005. *TR

NHTSA ODI #10283979

152,306 miles · Sep 7, 2007
Tires

4 COOPER TRENDSETTER WERE PUT ON MY VAN 6/18/07. ON 9/6/07 I WAS DRIVING ON I4, AND THE LEFT REAR TIRE HAD A MAJOR FAILURE. I FELT THE VAN START TO WEAVE, AND AT THAT TIME I THOUGHT IT WAS THE WIND. THE TIRE THEN JUST WENT COMPLETELY FLAT. I WAS DOING ABOUT 70 MPH., AND MANAGED TO BRING THE VAN TO A STOP. A MAJOR ACCIDENT WAS AV…

Read full complaint

4 COOPER TRENDSETTER WERE PUT ON MY VAN 6/18/07. ON 9/6/07 I WAS DRIVING ON I4, AND THE LEFT REAR TIRE HAD A MAJOR FAILURE. I FELT THE VAN START TO WEAVE, AND AT THAT TIME I THOUGHT IT WAS THE WIND. THE TIRE THEN JUST WENT COMPLETELY FLAT. I WAS DOING ABOUT 70 MPH., AND MANAGED TO BRING THE VAN TO A STOP. A MAJOR ACCIDENT WAS AVERTED. WHEN I LOOKED AT THE TIRE, LARGE PIECES OF THE TREAD WERE MISSING, THE STEEL BELTS WERE VISIBLE AND BROKEN, AND A HOLE WAS IN THE SIDEWALL. I HAD RUN OVER NOTHING, AND THE TIRES HAD 970 MILES ON THEM. THE DOT NUMBER ON THE TIRE WAS 3DHF C2T 469 F13L. AFTER I GOT HOME, I CHECKED THE WEB, AND FOUND THAT THERE WAS A RECALL ON THIS STYLE TIRE. RECALL 147. THE DOT NUMBER DIDN'T MATCH. I DID CALL COOPER TIRE, AND THEY HAVE PUT IT IN AS A INSURANCE CLAIM. THERE WAS SOME DAMAGE TO THE REAR PANEL WHEN THE TIRE SEPARATED. I TOLD THEM THAT I WAS NERVOUS DRIVING ON THESE TIRES, BUT THEY KEPT IT AS A INSURANCE CLAIM. I AM REPLACING ALL THE TIRES FOR PEACE OF MIND.*JB UPDATED 12/12/07 *TR

NHTSA ODI #10202191

Recall campaigns

1

05V099000 · Exterior Lighting:brake Lights:switch

Mar 14, 2005

ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.

Consequence & remedy

Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Defect investigations

1

PE04072 · Loss Of Brake Lamp Illumination

Opened Oct 19, 2004 · Closed Mar 21, 2005

Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:hazard Flashing Warning Lights

IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.

Additional source detail variants (2)

Exterior Lighting:brake Lights

IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.

Exterior Lighting:hazard Flashing Warning Lights

IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.

An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.