1999 Chevrolet Astro

WE HAVE A 1999 CHEVY ASTRO VAN. WE HAD A FACTORY RE-MANUFACTURED TRANSMISSION WHICH WAS SUPPLIED BY GUARANTY CHEVROLET ON 8-30-02, INSTALLED. THE VAN HAD 67,532 MILES. WE ARE ORIGINAL OWNERS AND NEVER TOWED ANYTHING. WE ALSO PAID TO HAVE A SEPARATE NEW COOLING SYSTEM INSTALLED FOR THE TRANSMISSION AND ALSO HAD THE DRIVESHAFT REBUILT AND BALANCED. NOW, OUR 2ND TRANSMISSION HAS FAILED AT 44,547 MORE MILES SINCE INSTALLED IN 2002. WE HAVE SPENT $5,700.00. OUR TRANSMISSION PLACE WROTE GM. MARK DOWLER OF CHEVY CALLED ME AND SAID SORRY, WE WON'T HELP YOU. WE ARE GOING TO SMALL CLAIMS COURT IF NEED BE. THANK YOU. *JB

1999 CHEVROLET ASTRO WITH 65000 MILES. TOWED A LIGHT TRAILER (1500 LBS) FROM COLORADO TO KANSAS, ABOUT 500 MILES. A COUPLE OF WEEKS LATER THE TRANSMISSION OCCASIONALLY STARTED SHIFTING VERY HARD FROM 1ST TO 2ND; ONCE IT STARTED, IT WOULD CONTINUE TO DO SO UNTIL THE IGNITION WAS TURNED OFF. ODBII CODE P1870 SET. APPARENTLY THE COMPUTER MONITORS SLIPPAGE IN THE TRANS AND IF IT THINKS IT'S SLIPPING TOO MUCH IT APPLIES FULL LINE PRESSURE TO THE SHIFT. HARD ON ENTIRE DRIVELINE AND DEVASTATING TO THE TRANS - WE'RE HAVING TO HAVE IT COMPLETELY REBUILT ALTHOUGH IF WE WOULD HAVE REPLACED THE VALVE BODY WHEN IT FIRST STARTED IT MIGHT HAVE BEEN OKAY.*AK

PURCHASED USED ASTRO VAN AND NOTED ON 2ND DAY WHEN PUTTING IN REVERSE THEN TO DRIVE A LOUD CLUNK AND HARD JUMP FORWARD UNLESS YOU DELAY TAKING FOOT OFF BRAKE OR APPLYING GAS UNTIL YOU CAN FEEL THE GEAR ENGAGE (APPROX. 5-10 SECONDS). THIS IS DANGEROUS WHEN BACKING UP, AS I HAVE ALMOST BEEN HIT TWICE NOW. IT NEEDS TO BE FIXED CORRECTLY OR REPLACED.*AK

WHILE DRIVING THE VEHICLE WOULD SURGE AND JERK THEN CLUNK, THE DEALER HAS ATTEMPTED TO REPAIR THE VEHICLE SEVERAL TIME BUT THE PROBLEM RESURFACES, OTHER FAILURES INCLUDE PCM FAILED CAUSING THE CHECK ENGINE LIGHT TO ILLUMINATE, THE GAS GAUGE JUMPS FROM FULL TANK TO EMPTY CAUSING THE VEHICLE TO RUN OUT OF GAS, REAR DOOR HANDLE BROKE TWICE, DRIVERS SIDE WINDOW MOTOR WAS REPLACED AND THE AIR BAG LIGHT WOULD FLICKER ON AND OFF. *TS *NLM

BRAKES HAVE BEEN SEVERLY WORN OUT*AK CONSUMER STATED THE SEATBELTS, ARM RESTS, CONSOLE THE TRIM ON THE SEAT CUSHION HAS TORN, THERE IS WIND NOISE FROM HIGH TOP ROOF, WINDOW IS LOOSE, RADIO IS INOPERATIVE, POWER STEERING FLUID LEAKING, STEERING COOLUMN IS MAKING A NOISE, WEATHERSTRIP COMING OFF OF BACK DOOR, TIRES SHAKE, THERE IS A HARD THUMP WHE GOING OVER BUMPS, CIGARETTE LIGHTER IS INOPERATIVE,TRANSMISSION SHIFTS HARD, PRESSURE GUAGE GETS STUCK, WINDOW GETS STUCK, THERE ARE NO LOW BEAM LIGHTS, WINDSHIELD WIPERS ARE INOPERATIVE, DOOR LOCK DO NOT COME ALL THE WAY UP, THE FRONT END OF VEHICLE DIPS, AND THE SHOCKS FEEL WEAK, THE LIFGATE DOES NOT STAY OPEN, INTERIOR LIGHTS STAY ON TO LONG, VEHICLE REMOTE IS INOPERATIVE, SLIDING DOOR IS HARD TO OPEN AT TIMES, OIL PRESSURE GUAGE READS HIGH, REFRIGERATOR NOT OPERATING FROM REAR SOCKET, HEATING SYSTEM IS INOPERATIVE, BATTERY GOES DEAD.*SLC

NO REVERSE ! WHILE DRIVING, SLOWED DOWN TO MAKE A RT. TURN HEARD A LOUD NOISE . THE VAN THEN STARTED TO SHIFT DIFFERENTLY, LIKE THERE WASN'T A FIRST GEAR . DROVE VAN HOME PARKED IT . NEXT DAY STARTED VAN UP WENT TO SHIFT IN REVERSE VAN WOULD NOT MOVE. SHIFTED TO DRIVE AND WENT FORWARD. PARK VAN IN GARAGE AND LOOKED AT LINKAGE UNDER VAN SAW NO PROBLEMS. MUST BE INTERNAL.*AK