IllustrationSECURITY LIGHT KEPT COMING ON. THEN CAR WOULD NOT START, THEN TOOK TO DEALER ,AND THE FUEL PUMP HAD TO BE CHANGED. ONE WEEK LATER, VEHICLE WOULD NOT START AGAIN , CHANGED THE SENSOR . TWO WEEKS LATER, VEHICLE WOULD NOT START ONCE AGAIN. TOWED TRUCK TO DEALER, AND THEY TOOK OUT THE DASH AND REPLACED A SWITCH. *AK
1998 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1998 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 55 of 241 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports7 fire reports14 injury reports
Fuel System, Gasoline complaints
26 reportsROBLEMS THAT I HAVE LISTED ARE ONLY THE ICING ON THE CAKE. I HAVE SEVERAL OTHER PROBLEMS AND SUCH AS : OIL COLLER INLET, REAR MAIN SEAL, EXTENTION HOUSING LEAKING.MY FRONT END ALIGNMENT WANDERS, PROBLEMS WITH KEYLESS REMOTE AND FACTORY ALARM.ROOF RACK WAS IMPROPERLY INSTALLED, CIGARETTTE LIGHTER FALLS OUT, GLOVE BOX LIGHT SWITC…
Read full complaint
ROBLEMS THAT I HAVE LISTED ARE ONLY THE ICING ON THE CAKE. I HAVE SEVERAL OTHER PROBLEMS AND SUCH AS : OIL COLLER INLET, REAR MAIN SEAL, EXTENTION HOUSING LEAKING.MY FRONT END ALIGNMENT WANDERS, PROBLEMS WITH KEYLESS REMOTE AND FACTORY ALARM.ROOF RACK WAS IMPROPERLY INSTALLED, CIGARETTTE LIGHTER FALLS OUT, GLOVE BOX LIGHT SWITCH DEFECTIVE,RAIDO SPEAKERS NOT PROPERTLY INSTALLLED. WHEN TENSIONER FAILED, THERE WAS A LOUD NOISE FROM THE FRONT END,SO I DECIDED TO GET OFF THE BUSY ROAD TO FIND OUT WHERE THE NOISE CAME FROM. MY STEERING ALSO WENT OUT;I HAD MY CHILDREN WITH ME ON A BUSY ROAD SPEED LIMIT 45.I WENT TO MAKE A LEFT HAD TURN AND HAD EXTREME DIFFICULTY IN TURNING MY WHEEL. I HAD TO UNBUCKLE MY SEATBELT; TO PULL ON THE STEERING WHEEL WITH ALL MY BODY WEIGHT, AND STILL COULDN'T MAKE THE TURN, I HAD TO BACK UP AND TRY TO TURN AGAIN.I CONTINUE TO HAVE FRONTEND,WINDOW,FUEL INJECTION, DOORS NOT WANTING TO LOCK AND UNLOCK PROPERLY AND I STILL CONTINUE TO HAVE THESE PROBLEMS. I FEEL THAT THIS CHEVROLET, ASTRO IS A VERY UNSAFE VEHICLE TO BE DRIVING. ANY INFO YOU CAN GIVE ME ON THIS VEHICLE WOULD BE GREATLY APPERICATED. THANK YOU LAURIE HOEKZEMA. *AK
ON THREE OCCASIONS FUEL INJECTORS FAILED, CAUSING STALLING. DEALER NOTIFIED.*AK
THE VEHICLE STALLED OUT AND DIED AT 55MPH. PRIOR TO THIS INCIDENT, THE DEALER FLUSHED THE INJECTORS OUT. THE DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK
FUEL INJECTOR.
FUEL INJECTION LINE NEEDED TO BE REPLACE DON TWO OCCASIONS WITHIN A YEA.; DEALER NOTIFIED AND INFORMED CONSUMER THAT NOTHING CAN BE DONE UNTIL THERE IS A CORRECTION IN THE GRADE OF FUEL USED IN CALIFORNIA. CAN NHTSA PROVIDE ADDITIONAL INFORMATION OR HELP IN THIS MATTER. HOW CAN THIS GO ON KNOWING WHAT IT CAN DO, BUT YET NO CORR…
Read full complaint
FUEL INJECTION LINE NEEDED TO BE REPLACE DON TWO OCCASIONS WITHIN A YEA.; DEALER NOTIFIED AND INFORMED CONSUMER THAT NOTHING CAN BE DONE UNTIL THERE IS A CORRECTION IN THE GRADE OF FUEL USED IN CALIFORNIA. CAN NHTSA PROVIDE ADDITIONAL INFORMATION OR HELP IN THIS MATTER. HOW CAN THIS GO ON KNOWING WHAT IT CAN DO, BUT YET NO CORRECTION TO THE PROLEM CAN BE FOUND UNTIL THEY CAN THE GRADE OF FUEL. *AK
PROBLEM HAS ACCURRED FOUR TIMES IN THE ONE YEAR I'VE OWNED IT. *AK
FUEL FILTER FAILED. YH
FUEL INJECTOR SYSTEM FAILED. *YC
FRONT BRAKE PADS FAILED ON THREE OCCASIONS. MJS
Official recalls
303V093000 · Visibility:rearview Mirrors/devices:exterior
Mar 7, 2003
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence & remedy
Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.