IllustrationAIR CONDITIONER CONTROLS OVERHEATED. *AK
1998 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1998 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 55 of 241 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports7 fire reports14 injury reports
Equipment complaints
7 reportsWHILE HAVING HEADLIGHTS ON, RADIO KNOBS GOT HOT TO THE POINT WHERE CONSUMER BURNED HIS FINGER. BUT, THIS ONLY HAPPENED WHEN HEADLIGHTS WERE ON. HAS NOT CONTACTED DEALER.*AK
WE NOTICED A SMELL OF BURNING WIRES. WE WERE PARKED, SO I PULLED THE REAR A/C SWITCH OUT OF THE DASH. I FOUND THAT THIS SWITCH, WHICH IS ALL PLASTIC, HAD BEEN SHORTED AND PARTIALLY MELTED. I DISCONNECTED THE SWITCH. THE SCARY PART FOR ME IS THAT THE FUSE NEVER BLEW. I AM AN AIRCRAFT MECHANIC AND FEEL THAT I WAS ABLE TO AVOI…
Read full complaint
WE NOTICED A SMELL OF BURNING WIRES. WE WERE PARKED, SO I PULLED THE REAR A/C SWITCH OUT OF THE DASH. I FOUND THAT THIS SWITCH, WHICH IS ALL PLASTIC, HAD BEEN SHORTED AND PARTIALLY MELTED. I DISCONNECTED THE SWITCH. THE SCARY PART FOR ME IS THAT THE FUSE NEVER BLEW. I AM AN AIRCRAFT MECHANIC AND FEEL THAT I WAS ABLE TO AVOID AN ELECTRICAL FIRE BY HAVING SOME MECHANICAL ABILITY. IF MY WIFE HAD BEEN IN THE VAN ALONE WITH OUR CHILDREN THIS WOULD HAVE BEEN A VERY SERIOUS AND POSSIBLY DEVASTATING PROBLEM. I CONTACTED THE MANUFACTURER AND LODGED A COMPLAINT WITH CHEVROLET CUSTOMER ASSISTANCE ( FILE # C01463026 ). CHEVROLET TOLD ME THAT NO RECALL HAD BEEN ISSUED ON THIS SWITCH AND THAT ALL I COULD DO IS TAKE IT TO THE DEALER. THE DEALER WANTS TO PUT IN A REPLACEMENT SWITCH, SAME TYPE. THIS TYPE OF SWITCH, IN MY OPINION, IS UNSAFE AND A HAZARD, AND I REFUSE TO PUT THIS TYPE OF SWITCH BACK INTO MY VEHICLE.
THE VEHICLE'S CONTROL ARMS FAILED. YH
ROBLEMS THAT I HAVE LISTED ARE ONLY THE ICING ON THE CAKE. I HAVE SEVERAL OTHER PROBLEMS AND SUCH AS : OIL COLLER INLET, REAR MAIN SEAL, EXTENTION HOUSING LEAKING.MY FRONT END ALIGNMENT WANDERS, PROBLEMS WITH KEYLESS REMOTE AND FACTORY ALARM.ROOF RACK WAS IMPROPERLY INSTALLED, CIGARETTTE LIGHTER FALLS OUT, GLOVE BOX LIGHT SWITC…
Read full complaint
ROBLEMS THAT I HAVE LISTED ARE ONLY THE ICING ON THE CAKE. I HAVE SEVERAL OTHER PROBLEMS AND SUCH AS : OIL COLLER INLET, REAR MAIN SEAL, EXTENTION HOUSING LEAKING.MY FRONT END ALIGNMENT WANDERS, PROBLEMS WITH KEYLESS REMOTE AND FACTORY ALARM.ROOF RACK WAS IMPROPERLY INSTALLED, CIGARETTTE LIGHTER FALLS OUT, GLOVE BOX LIGHT SWITCH DEFECTIVE,RAIDO SPEAKERS NOT PROPERTLY INSTALLLED. WHEN TENSIONER FAILED, THERE WAS A LOUD NOISE FROM THE FRONT END,SO I DECIDED TO GET OFF THE BUSY ROAD TO FIND OUT WHERE THE NOISE CAME FROM. MY STEERING ALSO WENT OUT;I HAD MY CHILDREN WITH ME ON A BUSY ROAD SPEED LIMIT 45.I WENT TO MAKE A LEFT HAD TURN AND HAD EXTREME DIFFICULTY IN TURNING MY WHEEL. I HAD TO UNBUCKLE MY SEATBELT; TO PULL ON THE STEERING WHEEL WITH ALL MY BODY WEIGHT, AND STILL COULDN'T MAKE THE TURN, I HAD TO BACK UP AND TRY TO TURN AGAIN.I CONTINUE TO HAVE FRONTEND,WINDOW,FUEL INJECTION, DOORS NOT WANTING TO LOCK AND UNLOCK PROPERLY AND I STILL CONTINUE TO HAVE THESE PROBLEMS. I FEEL THAT THIS CHEVROLET, ASTRO IS A VERY UNSAFE VEHICLE TO BE DRIVING. ANY INFO YOU CAN GIVE ME ON THIS VEHICLE WOULD BE GREATLY APPERICATED. THANK YOU LAURIE HOEKZEMA. *AK
CD PLAYER INOPERABLE. YH
STEREO FAILED. YH
Official recalls
303V093000 · Visibility:rearview Mirrors/devices:exterior
Mar 7, 2003
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence & remedy
Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.