Visibility. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

20 crash reports7 fire reports14 injury reports

Engine And Engine Cooling complaints

27 reports

Clear category filter

Mileage unknown · Nov 28, 2002

Engine And Engine CoolingService Brakes, HydraulicVehicle Speed Control

BELT TENSIONER CASING CRACKED/BROKEN AROUND MOUNT BOLT, CAUSING LOSS OF BELT TENSION, POWER ASSISTED STEERING, AND POWER ASSISTED BRAKING. THROTTLE CONTROL PEDAL "STICKS" AND EXCESSIVE PRESSURE MUST BE APPLIED TO OVERCOME RESISTANCE. BRAKE PEDAL COULD NOT BE DEPRESSED UNTIL EXCESSIVE FORCE WAS APPLIED WITH BOTH FEET, OCCURRED TW…

Read full complaint

NHTSA ODI #770222

Mileage unknown · Apr 15, 2002

Electrical SystemEngine And Engine CoolingFuel System, Gasoline

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ODI #760718

Mileage unknown · Apr 1, 2002

Engine And Engine CoolingPower TrainStructure

CONSUMER STATES TRANSMISSION IS SLIPPING AND THERE IS HARSH SHIFTING FROM 1ST TO 2ND GEAR. DEALER FOUND TORQUE CONVERTER AND VALVE BODY NEED TO BE REPLACED. *TT

NHTSA ODI #564840

Mileage unknown · May 23, 2001

Engine And Engine CoolingPower Train

TRANSMISSION HAS TO BE REBUILT DUE TO BAD SHIFTING. ALSO, ENGINE ROD BEARING WAS MAKING A KOCKING SOUND THAT FORCED REPLACEMENT. *AK CRACK IN COOLING SYSTEM HAD TO REPLACE SEAL.*JB

NHTSA ODI #889009

Mileage unknown · Mar 14, 2001

Electrical SystemEngine And Engine CoolingPower Train

BATTERY FAILED. NLM

NHTSA ODI #560311

Mileage unknown · Aug 30, 2000

Engine And Engine CoolingService Brakes, Hydraulic

COOLANT LEAKING FROM RADIATOR AND VEHICLE OVERHEATS. ALSO, WHEN APPLYING BRAKES PEDAL GETS HARD, AND GOES ALL THE WAY TO THE FLOOR. DEALERSHIP IS AWARE OF PROBLEM. *AK THE HOLD DOWN SPRING FOR REAR BRAKE RUSTED DUE TO WET WEATHER. *YH

NHTSA ODI #869167

Mileage unknown · Jul 10, 2000

Electrical SystemEngine And Engine CoolingEquipment

THE VEHICLE'S CONTROL ARMS FAILED. YH

NHTSA ODI #552960

Mileage unknown · Mar 30, 2000

Engine And Engine CoolingPower Train

TENSIONER ARM HOUSING BROKE OFF OF ENGINE BLOCK RENDERING VEHICLE UNDRIVEABLE. TRANSMISSION SLIPPED BETWEEN 2 & 3 & 4 GEARS. REPLACED TRANSMISSION WITH NEW GM TRANS. NO MONETARY RELIEF FROM GM WAS RECEIVED.

NHTSA ODI #720797

Mileage unknown · Jan 10, 2000

Electrical SystemEngine And Engine CoolingFuel System, Gasoline

SECURITY LIGHT KEPT COMING ON. THEN CAR WOULD NOT START, THEN TOOK TO DEALER ,AND THE FUEL PUMP HAD TO BE CHANGED. ONE WEEK LATER, VEHICLE WOULD NOT START AGAIN , CHANGED THE SENSOR . TWO WEEKS LATER, VEHICLE WOULD NOT START ONCE AGAIN. TOWED TRUCK TO DEALER, AND THEY TOOK OUT THE DASH AND REPLACED A SWITCH. *AK

NHTSA ODI #854822

Mileage unknown · Dec 10, 1999

Engine And Engine CoolingEquipmentFuel System, Gasoline

Read full complaint

ROBLEMS THAT I HAVE LISTED ARE ONLY THE ICING ON THE CAKE. I HAVE SEVERAL OTHER PROBLEMS AND SUCH AS : OIL COLLER INLET, REAR MAIN SEAL, EXTENTION HOUSING LEAKING.MY FRONT END ALIGNMENT WANDERS, PROBLEMS WITH KEYLESS REMOTE AND FACTORY ALARM.ROOF RACK WAS IMPROPERLY INSTALLED, CIGARETTTE LIGHTER FALLS OUT, GLOVE BOX LIGHT SWITCH DEFECTIVE,RAIDO SPEAKERS NOT PROPERTLY INSTALLLED. WHEN TENSIONER FAILED, THERE WAS A LOUD NOISE FROM THE FRONT END,SO I DECIDED TO GET OFF THE BUSY ROAD TO FIND OUT WHERE THE NOISE CAME FROM. MY STEERING ALSO WENT OUT;I HAD MY CHILDREN WITH ME ON A BUSY ROAD SPEED LIMIT 45.I WENT TO MAKE A LEFT HAD TURN AND HAD EXTREME DIFFICULTY IN TURNING MY WHEEL. I HAD TO UNBUCKLE MY SEATBELT; TO PULL ON THE STEERING WHEEL WITH ALL MY BODY WEIGHT, AND STILL COULDN'T MAKE THE TURN, I HAD TO BACK UP AND TRY TO TURN AGAIN.I CONTINUE TO HAVE FRONTEND,WINDOW,FUEL INJECTION, DOORS NOT WANTING TO LOCK AND UNLOCK PROPERLY AND I STILL CONTINUE TO HAVE THESE PROBLEMS. I FEEL THAT THIS CHEVROLET, ASTRO IS A VERY UNSAFE VEHICLE TO BE DRIVING. ANY INFO YOU CAN GIVE ME ON THIS VEHICLE WOULD BE GREATLY APPERICATED. THANK YOU LAURIE HOEKZEMA. *AK

NHTSA ODI #715876

Official recalls

03V093000 · Visibility:rearview Mirrors/devices:exterior

Mar 7, 2003

CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.

Consequence & remedy

Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

01V123000 · Seat Belts:front:warning Light/devices

Apr 10, 2001

VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

99V009000 · Child Seat

Jan 20, 1999

VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.

Consequence & remedy

Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.