1997 CHEVROLET ASTROVAN WITH ELECTRICAL DOOR LOCKS. PULLED INTO SHEETZ GAS AND GO AND WENT TO OPEN THE DRIVERS DOOR AND IT DID NOT OPEN. TRIED TO PUSH THE MANUAL INSIDE DOOR LOCK BUT IT WAS TOTALLY FROZEN AND WOULD NOT ACTUATE. NEXT TRIED ELECTRICAL DOOR LOCK SWITCH. NO RESPONSE ON DRIVERS DOOR BUT THERE WAS WEAK SOUND FROM PA…
Read full complaint
1997 CHEVROLET ASTROVAN WITH ELECTRICAL DOOR LOCKS. PULLED INTO SHEETZ GAS AND GO AND WENT TO OPEN THE DRIVERS DOOR AND IT DID NOT OPEN. TRIED TO PUSH THE MANUAL INSIDE DOOR LOCK BUT IT WAS TOTALLY FROZEN AND WOULD NOT ACTUATE. NEXT TRIED ELECTRICAL DOOR LOCK SWITCH. NO RESPONSE ON DRIVERS DOOR BUT THERE WAS WEAK SOUND FROM PASSENGER DOOR LOCK SOLENOID. IT WAS AS IF ON THE PASSENGER SIDE IT WAS SUFFERING FROM INSUFFICIENT VOLTAGE. CRAWLED OUT OF PASSENGER SEAT AND GOT OUT OF CAR. ' TOOK IGNITION KEY AND INSERTED IT INTO DRIVERS DOOR LOCK. KEY WOULD TURN TO LOCK (FELT THE DETENT OF THE ) AND BACK TO NEUTRAL... KEY WOULD NOT TURN TO UNLOCK POSITION ...WOULD MOVE A LITTLE AND THEN FREEZE. I DID NOT TRY HARDER TO TURN AS I FELT THERE WAS A VERY GOOD CHANCE THE KEY WOULD BREAK AND LEAVE ME STRANDED 40 MILES FROM HOME... NO BACKUP IGNITION KEY. IGNITION KEY WORKS THE DOOR LOCKS IN THIS MODEL. WENT TO NTSTB WEB SITE AND SEARCHED FOR OTHER PEOPLE WITH SAME TYPE PROBLEM. NO LUCK. WENT TO GOOGLE AND DID SAME SEARCH CHEVROLET ASTROVAN DOOR WON'T OPEN AND GOT A NUMBER OF COMPLAINTS THAT HAD NOT REACHED NTSTB.. CHEVROLET HAS TO KNOW ABOUT THIS PROBLEM. IF THIS MODEL HAS FLIP UP STEERING WHEEL, THIS WOULD NOT BE THE PROBLEM IT IS. IT IS VERY DIFFICULT FOR OLDER AND LARGER PROBLEM TO CLIMB OUT OF THE BUCKET SEAT AS THE STEERING WHEEL TRAPS YOUR LEGS WHEREAS A BENCH SEAT YOU SIMPLY SLIDE SIDEWAYS. THIS IS AN ENTRAPMENT ISSUE!!!!!! WILL SEE DEALER IN HOUR. *TR
NHTSA ODI #10549828
Mileage unknown · Jan 24, 2003
Latches/locks/linkages
UNABLE TO OPEN THE HATCHBACK FROM INSIDE OF VEHICLE DUE TO HATCHBACK NOT HAVING A RELEASE BUTTON. DEALER NOTIFIED. *TS..*AK
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
1997 Chevrolet Astro Problems, Complaints & Recalls | Skip That Year
Illustration