Illustration1997 CHEVROLET ASTRO. CONSUMER STATES SEVERAL ISSUES WITH VEHICLE *TGW THE CONSUMER STATED THE ODOMETER LIGHT WENT OUT WHILE DRIVING AND THE AIR CONDTIONER COMPRESSOR FAILED. THE VEHICLE WOULD CUT OFF IN THE MIDST OF DRIVING, WHICH MADE CONTROLLING THE VEHICLE DIFFICULT. *JB
1997 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1997 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 46 of 360 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports7 fire reports16 injury reports
Equipment complaints
16 reportsBRAKE PROBLEMS ON 1997 CHEVROLET ASTRO VAN. *MR THE CONSUMER STATED THAT MORE BRAKE WORK WAS NEEDED. THE BRAKES HAD RUSTED AND NEEDED TO BE TURNED, THE A/C WAS NOT BLOWING COLD AND THERE WAS A HEATING CONCERN. *SC THE REAR AXLE SEALS AND DIFFERENTIAL GASKETS WERE LEAKING.. *JB
TENSIONER BELT ON MY 1997 CHEVROLET ASTRO VAN CONTINUES TO MAKE CHIRPING SOUNDS ESPECIALLY AFTER IT RAINS. TENSIONER BELT HAS BEEN CHANGED 4 TIMES AND ALLEVIATES THE PROBLEM TEMPORARILY.*AK
CONSUMER STATES WHEN AIR CONDITONER IS SET ON MAXIMUM AIR COMES OUT OF DEFROSTER INSTEAD OF ALL THE OTHER AIR DUCKS. IT'S INTERMITTENT.*AK
MY WIPERS ON MY 1997 ASTRO VAN STOP WORKING DURING USE WHICH IS OF COURSE IS VERY DANGEROUS. AFTER READING SOME OF THE OTHER PEOPLES PROBLEMS IT IS APPARENT THAT THIS IS A KNOWN PROBLEM WITH THIS VEHICLE.. WHY WONT GM DO ANYTHING ABOUT IT? DOES SOMEONE NEED TO DIE? *NLM
CHEVROLET DOESN'T CARE ABOUT USING CHEAP PARTS- AFTER WARRANTY THEY SAY TRADE IT IN .NUMEROUS THINGS WRONG WITH VAN AND HAVE TALKED TO CHEVROLET MANY TIMES. CAN'T USE BACK DOOR OF VAN, RUN OUT OF GAS, KNOBS FALL OF INTERIOR DEVICES, ASKED CHEVY TO HELP SINCE 37,000 AND PROBLEMS STILL HAPPENING AS I GO, CAN'T AFFORD TO FIX AND CA…
Read full complaint
CHEVROLET DOESN'T CARE ABOUT USING CHEAP PARTS- AFTER WARRANTY THEY SAY TRADE IT IN .NUMEROUS THINGS WRONG WITH VAN AND HAVE TALKED TO CHEVROLET MANY TIMES. CAN'T USE BACK DOOR OF VAN, RUN OUT OF GAS, KNOBS FALL OF INTERIOR DEVICES, ASKED CHEVY TO HELP SINCE 37,000 AND PROBLEMS STILL HAPPENING AS I GO, CAN'T AFFORD TO FIX AND CAN'T AFFORD TO TRADE. ANOTHER NICE SHOVE IT JOB BY CHEVROLET THEY DON'T STAND BY THEIR PRDUCT AND THEIR PRODUCT IS NOT SAFE PLEASE RESPOND. *AK
RADIO BROKE DOWN. YH
DESIGN DEFECT CORRECTED IN NEW INSTALLATION. HOWEVER, OUT $432 TO COVER FIX FOR KNOWN PROBLEM. GM REFUSED TO COVER LOSS EVEN THOUGH A DESIGN CHANGE HAD BEEN MADE. NO SAFETY DEFECT MENTIONED IN THE SUMMARY. *AK
WHILE PARKED AIR CONDITIONER EXPLODED. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER DETAILS. *AK
NUMEROUS PROBLEMS WITH ALL OF THIS VAN. PLEASE CONTACT TO EXPLAIN IN FULL.
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.