IllustrationREQUEST FOR REIMBURSEMENT FOR REPAIRS MADE TO WINDSHIELD WIPER MOTOR CIRCUIT BOARD. *MR FAULTY WINDSHIELD WIPER MOTOR CIRCUIT BOARD CRACKED AND CAUSED THEM TO FAIL. RECALL#03V159000 *SCC *JB
1996 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1996 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 22 of 263 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports1 fire reports7 injury reports
Visibility complaints
60 reportsI HAVE A 1996 CHEVROLET ASTRO VAN. I'VE REPLACED THE DRIVER AND PASSENGER SIDE POWER WINDOW MOTOR'S FOUR TIMES, EACH. OUR COMPANY HAS 26 VEHICLES, ALL ASTRO VAN'S AND ALL HAVE THE SAME PROBLEM. I JUST RECEIVED A RECALL NOTICE ABOUT THE WIPER MOTOR ON THIS VEHICLE. THE POWER WINDOW MOTOR DEFINITELY IS MORE OF A PROBLEM. I CA…
Read full complaint
I HAVE A 1996 CHEVROLET ASTRO VAN. I'VE REPLACED THE DRIVER AND PASSENGER SIDE POWER WINDOW MOTOR'S FOUR TIMES, EACH. OUR COMPANY HAS 26 VEHICLES, ALL ASTRO VAN'S AND ALL HAVE THE SAME PROBLEM. I JUST RECEIVED A RECALL NOTICE ABOUT THE WIPER MOTOR ON THIS VEHICLE. THE POWER WINDOW MOTOR DEFINITELY IS MORE OF A PROBLEM. I CAN'T BELIEVE THAT THERE HASN'T BEEN A RECALL. IN THE WINTER, YOU'LL BEING DRIVING, LOWER THE WINDOW AND ALL OF A SUDDEN CAN'T GET IT UP. IT'S EVEN MORE OF A PROBLEM WHEN IT RAINS. PLEASE CHECK INTO THIS. I FIRST REPLACED THE MOTOR ON BOTH SIDES @ 19,000 MILE, THAN 39,000 MILES AND SO ON. WHEN I CALLED GM TO COMPLAIN THE CUSTOMER SERVICE REP WAS STONE COLD; COULDN'T CARE LESS! IF YOU CHECK INTO THIS YOU'LL SEE IT'S A MAJPOR PROBLEM.*AK
CHEVROLET ASTRO VAN 1996. THE DRIVERS WINDOW MOTOR STOPPED WORKING ABOUT 6 MONTHS AFTER PURCHASE, WAS REPAIRED, THEN IT STOPPED WORKING AGAIN ABOUT A 6 MONTHS LATER. THE CHEVROLET DEALER WILL NOT FIX IT BECAUSE THEY SAY IT IS OUT OF WARRANTY. STILL UNUSABLE. *JB
THE WINDSHIELD WIPERS WORKED INTERMITTENTLY. SCC *JB
THE WIPERS WILL WORK INTERMITTENTLY TO NON OPERATIONAL WHEN NEEDED. THE MOTOR HAS BEEN REPLACED. *JG
WIPER WORK INTERMITTENLY TO NON-OPERATIONAL WHEN NEEDED. DEALER AND MFR WAS NOTIFIED PROVIDE ANY FURTHER INFORMATION. TS
ONGOING PROBLEM WITH WINDSHIELD WIPERS WORKING INTERMITTENTLY SINCE 85,000 MILES, UNTIL NOT OPERATING AT THIS PRESENT TIME. DEALER AND MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
WIPERS QUIT WORKING DURING HEAVY RAIN STORM, SWITCH POSITION MADE NO DIFFERENCE. AFTER SEVERAL MINUTES THEY STARTED WORKING AGAIN, ONLY TO FAIL WORKING AFTER A SHORT PERIOD OF TIME. THIS HAPPENED (4) MORE TIMES DURING OUR DRIVING TIME OF 6 HOURS RETURNING HOME FROM VACATION. *AK
WINDSHIELD WIPERS WORK INTERMITTENTLY DURING OPERATION. DEALER AND MANUFACTURER WERE NOTIFIED. *AK. CONSUMER STATES THE MANUFACTURER SHOULD EXTEND THE RECALL 98043 ON ALL CHEVROLET VEHICLES.*JB
WINDSHIELD WIPERS WORK INTERMITTENTLY WITH PROBLEM BECOMING INCREASINGLY WORSE. AT TIMES, WILL WORK ON HIGHEST SPEED, THEN AT OTHER TIMES, WILL FAIL COMPLETELY.*AK
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.