IllustrationWINDSHIELD WIPERS WILL NOT COME ON UNLESS CONSUMER JIGGLES THE WIRING UNDER HOOD. THE DEALER IS AWARE OF THE PROBLEM. THE PROBLEM WILL BE CORRECTED. *AK
1994 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1994 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 33 of 328 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports3 fire reports27 injury reports
Visibility complaints
88 reportsWINDSHIELD WIPERS WORK INTERMITTENTLY IN RAINY WEATHER. PLEASE PROVIDE FURTHER INFORMATION. *AK
WINDSHIELD WIPERS MALFUNCTIONED WHILE IN USE, OBSTRUCTING VISIBILITY AND MAY RESULT IN A CRASH. THERE IS A RECALL ON THIS PROBLEM, BUT DOES NOT INCLUDE THIS VEHICLE. *AK
INTERMITTENTLY WINDSHIELD WIPERS WOULD STOP, OBSTRUCTING VIEW OF THE DRIVER. THE DEALER HAS REPLACED THE WIPERS. A RECALL HAS BEEN ISSUED ON OTHER GM TRUCKS HOWEVER, THIS MODEL WAS NOT INCLUDED UNDER THE RECALL. *AK
ON TWO OCCASIONS THE WINDSHIELD WIPER MOTOR CIRCUIT BOARD FAILED DURING RAINY CONDITIONS, CAUSING POOR VISIBILITY, RECALL COMPONENT HOWEVER VEHICLE NOT INCLUDED. *YC
INTERMITTENTLY, WHILE IN USE, THE WINDSHIELD WIPERS MALFUNCTIONED, AFFECTING VISIBILITY WHICH RESULTED IN A CRASH. ALSO WHEN TURNING ON THE WIPERS, THEY WON'T WORK. CURRENTLY WILL BE TAKING TO DEALRES. THERE IS A RECALL FOR THIS PROBLEM BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL ALTHOUGH IT HAS THE SAME PROBLEM. PLE…
Read full complaint
INTERMITTENTLY, WHILE IN USE, THE WINDSHIELD WIPERS MALFUNCTIONED, AFFECTING VISIBILITY WHICH RESULTED IN A CRASH. ALSO WHEN TURNING ON THE WIPERS, THEY WON'T WORK. CURRENTLY WILL BE TAKING TO DEALRES. THERE IS A RECALL FOR THIS PROBLEM BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL ALTHOUGH IT HAS THE SAME PROBLEM. PLEASE PROVIDE FURTHER INFORMATION AND VIN#. *AK
WINSHIEL WIPERS WILL NOT COME ON. WHEN THEY DO COME ON THEY STOP IN THE MIDDLE OF THE WINDSHIELD, THEN DRIVER HAS TO WORK TO GET THEM STARTED AGAIN. *AK
CONSUMER WAS DRIVING DOWN THE ROAD AND IT BEGAN TO RAIN AND WINDSHIELD WIPERS DID NOT WORK. *AK
THE LEGR FIRST WENT OUT 11/27/93 TAKEN TO THE NEAREST DEALER NO PROPLEM WAS FOUND, FINALLY LEGR VALVE WENT OUT COMPLETLY 9/04/98 TAKEN TO THE NEAREST DEALER LEGR VALVE WAS REPLACED...WINDSHIELD WIPER SWITCH FIRST WENT OUT ESTIMATE 10/98 AFTER SEVERAL ATTEMPTS TO GET FIXED AT DEALER FINALLY REPAIRED 11/19/98, WINDSHIELD WIPER SWI…
Read full complaint
THE LEGR FIRST WENT OUT 11/27/93 TAKEN TO THE NEAREST DEALER NO PROPLEM WAS FOUND, FINALLY LEGR VALVE WENT OUT COMPLETLY 9/04/98 TAKEN TO THE NEAREST DEALER LEGR VALVE WAS REPLACED...WINDSHIELD WIPER SWITCH FIRST WENT OUT ESTIMATE 10/98 AFTER SEVERAL ATTEMPTS TO GET FIXED AT DEALER FINALLY REPAIRED 11/19/98, WINDSHIELD WIPER SWITCH OUT AGAIN NOT REPLACED YET OUT OF WARRENTY AND DEALER AND CHEVERLOT DOES NOT WANT TO REPLACE AT NO CHARGE
WINDSHIELD WIPERS HAD TO BE REPLACED. THE WIPERS FAIL TO WORK WHEN NEEDED. THE MOTOR OR WIRES HAVE TO BE SHAKEN TO GET WIPERS TO START TO WORK AGAIN. THE BATTERY WENT. HAD A 6 YEAR WARRANTY, BUT MANUFACTURER IS COVERING ONLY 3 YEARS & IT DOES NOT WORK. *AK
Official recalls
294V177000 · Seats:front Assembly:head Restraint
Sep 14, 1994
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Remedy: SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
94V087000 · Equipment:other:labels
May 9, 1994
THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OWNERS OF VEHICLE WOULD BE UNAWARE OF THE LOAD CAPACITY OF THE VANS, THE VAN BUILD DATE, AND WOULD NOT HAVE ANY ASSURANCE THAT THE VANS MEET THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS.
Remedy: THE LABELS WILL BE FURNISHED TO OWNER'S FOR INSTALLATION ON THE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ99003 · Windshield Wiper
Opened Mar 8, 1999 · Closed May 31, 2002
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer
No summary supplied.