THE FIRST FAILURE OCCURRED WHILE PULLING INTO THE PARKING SPACE AT MY PLACE OF EMPLOYMENT. THE POWER STEERING BRACKET, OR BRACE, GM PART # 10045287 6.006 BROKE AND THE POWER STEERING UNIT, BELT, AND OTHER ITEMS BECAME INOPERATIVE. THE VEHICLE WAS STILL UNDER FACTORY WARRANTY AND THE DEALER TOWED IT IN AND REPAIRED EVERYTHING A…
Read full complaint
THE FIRST FAILURE OCCURRED WHILE PULLING INTO THE PARKING SPACE AT MY PLACE OF EMPLOYMENT. THE POWER STEERING BRACKET, OR BRACE, GM PART # 10045287 6.006 BROKE AND THE POWER STEERING UNIT, BELT, AND OTHER ITEMS BECAME INOPERATIVE. THE VEHICLE WAS STILL UNDER FACTORY WARRANTY AND THE DEALER TOWED IT IN AND REPAIRED EVERYTHING AT NO CHARGE. SINCE THEN THE SAME BRACKET HAS CRACKED AND BROKEN FOUR OR FIVE TIMES, AND WAS REPLACED EACH TIME WITH A NEW ONE, MOST RECENTLY IN JULY OF 2004. THE PARTS DEPARTMENT ADMITS THEY SELL A LOT OF THESE. *JB
NHTSA ODI #10086889
Mileage unknown · May 7, 2002
Steering
THIS IS THE FOURTH POWER STEERING PUMP WE HAVE PUT ON THE VEHICLE IN A YEAR.*AK
POWER STEERING PUMP BROKE OFF THE BASE. ALSO, STEERING BELT BROKE. IN ADDITION, AIR CONDITIONER BELT/ ALTERNATOR AND ABS BRAKES HAD TO BE REPLACED.*AK
NHTSA ODI #864075
Mileage unknown · Dec 2, 1999
Steering
SINCE THE TIME OF PURCHASE THE STEERING COLUMN HAS BECOME VERY LOOSE AND NEEDED TO BE TIGHTENED ABOUT ONCE A YEAR. CURRENTLY IT HAS BECOME LOOSE FOR THE SECOND TIME AND WILL NEED TO HAVE THIS REPAIRED AGAIN.
NHTSA ODI #715552
Mileage unknown · May 27, 1999
Steering
DUE TO POOR ENGINEERING POWER STEERING HYDRAULIC HOSE WILL BECOME INOPERATIVE, CAUSING A LOSS OF VEHICLE CONTROL. THE PART WILL FAIL AND NEEDS TO REPLACED EVERY 12- 15 MONTHS. *AK
NHTSA ODI #838561
Mileage unknown · Aug 22, 1998
Steering
THIS VAN IN NOW CURRENTLY SITTING IN MY YARD AS I CAN NOT AFFORD TO FIX IT AT THIS TIME DUE TO THE MECHANICS AT THE LOCAL CHEVY DEALERSHIP STATED IF WOULD BE OVER $600.00 TO REPAIR. I KNOW THIS HAS TO BE A DESIGN DEFECT FOR IT TO HAVE HAPPENED TO US ON 5 OCCASIONS, NECESSITATING A WRECKER SERVICE CALL EACH TIME. I PAID $35.00…
Read full complaint
THIS VAN IN NOW CURRENTLY SITTING IN MY YARD AS I CAN NOT AFFORD TO FIX IT AT THIS TIME DUE TO THE MECHANICS AT THE LOCAL CHEVY DEALERSHIP STATED IF WOULD BE OVER $600.00 TO REPAIR. I KNOW THIS HAS TO BE A DESIGN DEFECT FOR IT TO HAVE HAPPENED TO US ON 5 OCCASIONS, NECESSITATING A WRECKER SERVICE CALL EACH TIME. I PAID $35.00 FOR THE WRECKER THIS TIME AND $48.50 TO GET IT OUT OF THE SHOP UNREPAIRED TO BRING IT HOME TO SIT IN THE YARD. WHEN THIS HAPPENS AND THE BELT SLIPS OFF OF THE SYSTEM IT IS VERY DANGEROUS TO CONTROL AND STEER OF THE HIGHWAY. FORTUNATELY IT HAPPENED EARLY IN THE MORNING AND THERE WASN'T ANY TRAFFIC ALONG THE HIGHWAY I WAS DRIVING ON.
NHTSA ODI #540229
Mileage unknown · Apr 21, 1998
Steering
THE BOLTS BY THE POWER STEERING PUMP, THAT HOLD THE ALTERNATOR AND AIR CONDITIONER COMPRESSOR BROKE, WHICH CRACKED THE BRACKET. THE BRACKET HAS BEEN REPLACED 2 TIMES(6/93 AND 6/96) AND NEEDS REPLACING AGAIN. *AK
NHTSA ODI #822134
Mileage unknown · Apr 21, 1998
Steering
TWO BOLTS BROKE BY THE POWER STEERING PUMP CAUSING THE BRACKET TO BREAK.
NHTSA ODI #534398
Mileage unknown · Feb 18, 1997
Steering
STEERING WHEEL IS LOOSE. PLEASE DESCRIBE. *AK
NHTSA ODI #809051
Mileage unknown · Jul 13, 1995
Steering
POWER STEERING; REAR POWER STEERING BRACE CONTINUOUSLY CRACKS AND HAS BEEN REPLACED (3) TIMES. FORD IS AWARE OF PROBLEM. PLEASE DESCRIBE DETAILS. *AK
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Illustration