Illustration2004 CADILLAC SRX. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE FAILURE. *SMD THE CONSUMER STATED HIS WIFE WAS DRIVING, WHEN THE BRAKES FAILED. THE DEALER WAS UNABLE TO FIND A PROBLEM. THE CONSUMER BELIEVED THE VEHICLE STALLED AND LOST POWER STEERING AND BRAKES. *JB
2004 Cadillac Srx
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Cadillac Srx do not stand out strongly from the model-year median of 192.
About this comparison →How this year compares
Owner complaints by model year
Compare all Srx years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
330–25K
2925–50K
3650–75K
2975–100K
32100–150K
17150K+
176 reports with mileage · 40 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electronic Stability Control (esc). Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports2 fire reports14 injury reports
What owners actually said
216 reportsTL* THE CONTACT OWNS A 2004 CADILLAC SRX. THE CONTACT STATED THAT THE AIR BAG SERVICE LIGHT ILLUMINATED SPORADICALLY. THE CONTACT MENTIONED THAT THE FAILURE STARTED TO OCCUR AFTER THE VEHICLE WAS REPAIRED UNDER AN UNKNOWN MANUFACTURER RECALL RELATED TO THE AIR BAGS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE …
Read full complaint
TL* THE CONTACT OWNS A 2004 CADILLAC SRX. THE CONTACT STATED THAT THE AIR BAG SERVICE LIGHT ILLUMINATED SPORADICALLY. THE CONTACT MENTIONED THAT THE FAILURE STARTED TO OCCUR AFTER THE VEHICLE WAS REPAIRED UNDER AN UNKNOWN MANUFACTURER RECALL RELATED TO THE AIR BAGS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 46,000.
DRIVING ON HIGHWAY DOING ABOUT 70 CAR WOULD NOT ACCELERATE AND MADE LOUD GRINDING NOISE. CAR WAS STUCK IN NEUTRAL WOULD NOT CHANGE GEARS. *TR
RE: RECALL NUMBER 14V394. THE FIX GM IS DOING IS A SMALL PLASTIC PIECE BEING GLUED INTO THE KEY END. I'VE HAD MY KEY STICK IN THE IGNITION MORE THAN ONCE AND I WASN'T EVEN MOVING. I FOUND A PAGE IN MY MANUAL (SECTION 2 PAGE 21) THAT EXPLAINS WHAT TO DO WHEN YOUR KEY GETS STUCK IN THE IGNITION. THIS TELLS ME THAT THE PROBLEM CA…
Read full complaint
RE: RECALL NUMBER 14V394. THE FIX GM IS DOING IS A SMALL PLASTIC PIECE BEING GLUED INTO THE KEY END. I'VE HAD MY KEY STICK IN THE IGNITION MORE THAN ONCE AND I WASN'T EVEN MOVING. I FOUND A PAGE IN MY MANUAL (SECTION 2 PAGE 21) THAT EXPLAINS WHAT TO DO WHEN YOUR KEY GETS STUCK IN THE IGNITION. THIS TELLS ME THAT THE PROBLEM CAUSING CRASHES IS MUCH MORE THAN A SMALL KEY FIX. THE IGNITION NEEDS TO BE REPLACED. I REPORTED THIS TO THE GM HOTLINE. THEY MADE A NOT OF THE FACT THAT IF ANYBODY GETS HURT IN MY CAR BECAUSE OF IGNITION ISSUES, THEY WILL HEAR FROM MY LAWYER. THEY JUST SAID "OK, WE'LL MAKE A NOTE OF IT". *TR
WHEN THE LIGHT TURN GREEN I PUT MY FOOT ON THE ACCELERATOR AND MY TRUCK START MAKING A LOUD RATTLING / THUMPING NOISE. ONCE THE 2004 SRX CHANGE GEARS THEN THE VEHICLE IS ROLLING WITH NO PROBLEM. I TOOK MY TRUCK TO CADILLAC AND I HAVE PAPERWORK THAT SAY I NEED A BEARING HUB ON THE LEFT TIRE THINKING THAT'S WHAT THE PROBLEM WAS BU…
Read full complaint
WHEN THE LIGHT TURN GREEN I PUT MY FOOT ON THE ACCELERATOR AND MY TRUCK START MAKING A LOUD RATTLING / THUMPING NOISE. ONCE THE 2004 SRX CHANGE GEARS THEN THE VEHICLE IS ROLLING WITH NO PROBLEM. I TOOK MY TRUCK TO CADILLAC AND I HAVE PAPERWORK THAT SAY I NEED A BEARING HUB ON THE LEFT TIRE THINKING THAT'S WHAT THE PROBLEM WAS BUT THAT WAS NOT THE PROBLEM. I HAD THE REPAIRS DONE ON BOTH PASSENGER HUBS AND STILL THE NOISE IS THERE. I WENT TO SEVERAL REPAIR SHOPS AND SOME SAY THE TRANSFER CASE OR THE CHAIN IS SLIPPING. I BOUGHT THE VEHICLE AT THE END OF FEBRUARY FROM A USED CAR LOT NOT KNOWING WHAT I WAS GETTING MYSELF INTO. I'M AFRAID TO HAVE MY KIDS IN THE TRUCK WITH ME BECAUSE WHEN I TAKE OFF FAST THE KNOCKING WILL START. I HAVE TO TAKE MY FOOT OFF THE ACCELERATOR AND GO SLOW UNTIL THE TRUCK PICK UP THE RIGHT AMOUNT OF SPEED TO STOP FROM HEARING THE KNOCKING NOISE. IF I'M AT A STOP SIGN OR A LIGHT I HAVE TO TAKE OFF REAL, REAL SLOW SO I WANT HEAR THE NOISE. I HATE STOPPING BECAUSE I FEAR THAT SOMEONE WILL HIT ME FROM BEHIND FOR GOING SO SLOW. IT'S VERY ANNOYING WHEN YOUR SPENDING YOUR HARD EARNED MONEY ON A VEHICLE AND PAYING A NOTE AND THIS PROBLEM IS NOT SOLVE YET. *TR
I PURCHASED A 2004 SRX FROM COLEMAN CADILLAC IN EWING, NJ ON 11/05/03. MY SRX WAS PARKED AT COLUMBIA UNIVERSITY WHEN THE IGNITION KEY GOT LOCKED IN THE IGNITION CYLINDER. THE REPAIR COST AT POTAMKIN CADILLAC CAME TO A TOTAL OF $2217.86. I ALSO HAD TO GET MY KEYS REPROGRAMMED WHICH TOTALED $181.35 BACK AT COLEMAN CADILLAC IN NJ.…
Read full complaint
I PURCHASED A 2004 SRX FROM COLEMAN CADILLAC IN EWING, NJ ON 11/05/03. MY SRX WAS PARKED AT COLUMBIA UNIVERSITY WHEN THE IGNITION KEY GOT LOCKED IN THE IGNITION CYLINDER. THE REPAIR COST AT POTAMKIN CADILLAC CAME TO A TOTAL OF $2217.86. I ALSO HAD TO GET MY KEYS REPROGRAMMED WHICH TOTALED $181.35 BACK AT COLEMAN CADILLAC IN NJ. I RECENTLY READ THAT THE 2004 SRX IGNITION WAS IDENTIFIED AS A PROBLEM: THE DELPHI (DLPH.N) DOCUMENTS, RELEASED ON WEDNESDAY BY THE U.S. NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, ALSO MAY INDICATE THAT EARLIER VERSIONS OF THE CADILLAC SRX, FROM MODEL YEARS 2004-2006, USED A SWITCH PART FROM THE 2003 ION. ONE DOCUMENT SAYS THE SRX "IN THE BEGINNING OF THE PROGRAM" USED SWITCH PARTS FROM "DELTA" VEHICLES, THE CODE NAME FOR THE GM SMALL-CAR FAMILY THAT INCLUDES THE ION AND COBALT. I'M SURE YOU ARE AWARE OF THIS ISSUE AND AM ASKING THAT I RECEIVE A CREDIT FOR THE EXPENSE I INCURRED FOR THE REPAIR OF THE IGNITION CYLINDER AND ATTENDANT COST'ECM, REPROGRAMMING, ETC. THE TOTAL AMOUNT OF THE CREDIT I AM ASKING IS $2399.21. I HAVE WRITTEN TO GM AND HAD NUMEROUS DISCUSSIONS WITH THEIR EXECUTIVE RESOURCE CENTER (REFERENCE NO. 71-1336933693402). AN INITIAL OFFER OF $200 WAS WITHDRAWN AFTER CALLING TO TELL ME THAT I WOULD RECEIVE A RECALL NOTICE IN THE MAIL. THE ONLY RECALL NOTICE I HAVE RECEIVED WAS TELLING ME TO HAVE A PLUG PUT IN MY IGNITION KEY.
TL* THE CONTACT OWNS A 2004 CADILLAC SRX. THE CONTACT STATED THAT A TIRE BLEW OUT CAUSING THE VEHICLE TO SPIN OUT OF CONTROL AND CRASH. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND ONE INJURY WAS REPORTED THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE…
Read full complaint
TL* THE CONTACT OWNS A 2004 CADILLAC SRX. THE CONTACT STATED THAT A TIRE BLEW OUT CAUSING THE VEHICLE TO SPIN OUT OF CONTROL AND CRASH. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND ONE INJURY WAS REPORTED THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
TL* THE CONTACT OWNS A 2004 CADILLAC SRX. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V394000 (ELECTRICAL SYSTEM), BUT THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
RANDOM ENGINE STALL, AFTER ENGINE IS FULLY WARMED UP AND HIGH HUMIDITY (ESPECIALLY DURING RAINING). OBD II CODE INDICATING P2135, P2119, P2176, P0638, P1101. (EACH TIME THE OBD II CODE MIGHT BE SLIGHTLY DIFFERENT) THE ENGINE COULD STALL DURING IDLE (STOPPING IN FRONT OF RED LIGHT), SLOW MOVING, OR HIGHWAY SPEED. PERSISTED S…
Read full complaint
RANDOM ENGINE STALL, AFTER ENGINE IS FULLY WARMED UP AND HIGH HUMIDITY (ESPECIALLY DURING RAINING). OBD II CODE INDICATING P2135, P2119, P2176, P0638, P1101. (EACH TIME THE OBD II CODE MIGHT BE SLIGHTLY DIFFERENT) THE ENGINE COULD STALL DURING IDLE (STOPPING IN FRONT OF RED LIGHT), SLOW MOVING, OR HIGHWAY SPEED. PERSISTED SINCE SUMMER OF 2012. DEALER ALREADY REPLACED THROTTLE BODY, COIL PACK, SPARK PLUGS AND ECM. DEALER COULD NOT REPRODUCE THE PROBLEM, AND COULD NOT FIGURE OUT A FIX. *TR
TL* THE CONTACT OWNS A 2004 CADILLAC SRX. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE ABS WARNING LIGHT ILLUMINATED SPORADICALLY. THE CONTACT ALSO STATED THAT WHEN APPLYING THE BRAKES, THE BRAKES WOULD SEIZE AND EXHIBIT A SCREECHING SOUND. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE CONTACT REFER…
Read full complaint
TL* THE CONTACT OWNS A 2004 CADILLAC SRX. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE ABS WARNING LIGHT ILLUMINATED SPORADICALLY. THE CONTACT ALSO STATED THAT WHEN APPLYING THE BRAKES, THE BRAKES WOULD SEIZE AND EXHIBIT A SCREECHING SOUND. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 04V151000 (SERVICE BRAKES, HYDRAULIC) BUT DID NOT CONFIRM IF THE VEHICLE WAS INCLUDED IN THE RECALL CAMPAIGN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 126,000 AND THE CURRENT 126,250.
Official recalls
714V394000 · Electrical System:ignition
Jul 2, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 2, 2014 that they are recalling 554,328 model year 2003-2014 Cadillac CTS vehicles manufactured August 16, 2001, to April 28, 2014, and 2004-2006 Cadillac SRX vehicles manufactured March 20, 2003, to August 11, 2006. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 15, 2014. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14172.
08V527000 · Power Train:automatic Transmission
Oct 9, 2008
GM IS RECALLING 17,301 MY 2004 CADILLAC SRX VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE TRANSMISSION SHIFT LEVER CAN BE MOVED FROM THE "PARK" POSITION WITH THE IGNITION "ON" AND WITHOUT THE OPERATOR DEPRESSING THE BRAKE PEDAL OR, IN SOME CASES, THE SHIFTER CAN BE MOVED FROM THE "PARK" POSITION WITH THE IGNITION TURNED OFF.
Consequence & remedy
Consequence: IF THE VEHICLE IS PARKED OR PARKED ON A SLOPE, THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PAWL STOPPER AND A BUSHING WITHIN THE SHIFTER ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 3, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-982-2339 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
05V046000 · Vehicle Speed Control:accelerator Pedal
Feb 9, 2005
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, GREATER BRAKE PEDAL FORCE AND A LONGER DISTANCE MAY BE REQUIRED TO STOP THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY. THIS RECALL BEGAN ON MARCH 8, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR PONTIAC AT 1-800-620-7668.
05V024000 · Air Bags
Jan 20, 2005
ON CERTAIN PASSENGER VEHICLES, AN INTERACTION BETWEEN THE SENSING AND DIAGNOSTIC MODULE AND VEHICLE'S ELECTRICAL SYSTEM MAY CAUSE THE DRIVER'S FRONTAL AIR BAG AND/OR ROOF-MOUNTED SIDE IMPACT AIR BAG TO DEPLOY WHEN THE IGNITION KEY IS TURNED TO THE "ON" POSITION.
Consequence & remedy
Consequence: A PERSON POSITIONED FOR DRIVING MAY RECEIVE MINOR INJURIES, SUCH AS ABRASIONS, FROM CONTACT WITH A DEPLOYING AIR BAG.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 20, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
04V273000 · Steering:linkages
Jun 9, 2004
ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Consequence & remedy
Consequence: IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHICLE TO TURN IN THE DIRECTION OF THE AFFECTED WHEEL. IN EXTREME SITUATIONS, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL;S HYDRAULIC BRAKE HOSE AND RESULT IN DIMINISHED BRAKING PERFORMANCE OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.
04V151000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Mar 29, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ALL WHEEL DRIVE, THE ANTILOCK BRAKE SYSTEM (ABS) MAY IMPROPERLY TEMPORARILY ISOLATE THE DRIVER FROM THE FOUNDATION BRAKE SYSTEM FOR A MAXIMUM OF 1.25 SECONDS.
Consequence & remedy
Consequence: THIS CAN CAUSE IN AN INCREASE IN BRAKING DISTANCE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS TRACTION CONTROL SYSTEM CONTROLLER. OWNER NOTIFICATION BEGAN ON MAY 10, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339.
03V346000 · Seats
Sep 29, 2003
CERTAIN PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." ONE OR BOTH FRONT ANCHOR TABS FOR THE FRONT BUCKET SEATS ARE NOT ENGAGED IN THE FLOOR PAN REINFORCEMENT SLOTS. A SEAT WITH ONLY ONE TAB ENGAGED OR NEITHER ENGAGED WOULD NOT MEET THE STATIC REARWARD LOADING TEST REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IN SOME CRASH CONDITIONS, THE SEAT COULD PIVOT REARWARD AND ITS OCCUPANT OR A REAR SEAT OCCUPANT COULD BE INJURED MORE SEVERELY.
Remedy: DEALERS WILL ENSURE THAT BOTH FRONT ANCHOR TABS ARE FULLY SEATED IN THE FLOOR PAN REINFORCEMENT SLOTS. OWNER NOTIFICATION BEGAN SEPTEMBER 19, 2003. OWNERS SHOULD CONTACT GM AT 1-800-458-8006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA06001 · Sunroof Glass Failure
Opened Jan 20, 2006 · Closed Dec 1, 2006
Status: closed (inferred from source dates) · Visibility:sun/moon Roof Assembly
ODI'S INVESTIGATION OF THE CADILLAC SRX GLASS ROOF DID NOT IDENTIFY ANY DEFECTIVE MANUFACTURING PROCESS, DESIGN, OR QUALITY CONTROL ISSUE WITH THE SRX GLASS ROOF SYSTEM.GM BELIEVES THAT THE MOST LIKELY CAUSE OF BREAKAGE IS STONE OR SHARP OBJECT IMPACT AGAINST THE GLASS.THE INVESTIGATION INCLUDED A PEER MULTI-VEHICLE ANALYSIS.THAT ANALYSIS FOUND THAT OTHER VEHICLES WITH LARGE GLASS ROOF SYSTEMS EXPERIENCE RANDOM STONE/OBJECT IMPACTS AND BROKEN GLASS PANELS.THE INCIDENT RATE FOR THE SUBJECT VEHICLES DID NOT STAND OUT IN THIS ANALYSIS.THE SRX ULTRAVIEW POWER GLASS ROOF CONSISTS OF UP TO THREE TEMPERED GLASS PANELS SURROUNDED BY METAL TRIM AROUND THE PERIMETER OF THE ROOF STRUCTURE.THE MAIN FRONT PANEL IS A LARGE MOVABLE GLASS PANEL RESIDING OVER THE FIRST AND SECOND ROW OCCUPANTS.THE MIDDLE NON-MOVABLE PANEL IS NOT ACCESSIBLE FROM THE INSIDE.THE REAR NON-MOVABLE PANEL IS AN OPTIONAL PANEL (ULTRAVIEW PLUS OPTION) AND IS VIEWABLE FROM THE INSIDE.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05052 · Sun Roof Glass Failure
Opened Sep 22, 2005 · Closed Jan 20, 2006
Status: closed (inferred from source dates) · Visibility:sun/moon Roof Assembly
OF THE 17 COMPLAINTS, THERE WERE 9 INJURY INCIDENTS RESULTING IN 19 INDIVIDUALS BEING INJURED.THE INJURIES CONSIST OF CUTS AND SCRAPES TO OCCUPANT'S FACE, ARM, HAND OR LEG.SOME INJURIES WERE THE DIRECT RESULT OF THE FALLING GLASS FRAGMENTS WHILE OTHER INJURIES OCCURRED WHEN OCCUPANTS WERE EXITING THE VEHICLE OR WHILE HANDLING THE GLASS FRAGMENTS.IN ADDITION, THERE WERE FIVE WARRANTY CLAIMS RELATED TO THE ISSUE FOR A TOTAL OF 22 REPORTS.GM HAS NOT IDENTIFIED ANY MANUFACTURING PROCESS OR QUALITY CONTROL ISSUE WITH THE MOVABLE SUN ROOF/MOON ROOF GLASS PANEL.THEY BELIEVE THE MOST LIKELY CAUSE OF THE BREAKAGE IS RANDOM STONE OR SHARP DEBRIS IMPACT TO THE GLASS ROOF STRUCTURE.ODI'S ANALYSIS INDICATES THAT THE NUMBER OF INCIDENTS WILL CONTINUE TO INCREASE AS MY 2006 VEHICLES ARE SOLD AND PUT INTO SERVICE.THE EVIDENCE INDICATES THAT THE BROKEN GLASS FRAGMENTS WILL FALL DIRECTLY ONTO BOTH THE FRONT AND MIDDLE ROW SEAT OCCUPANTS OF THESE VEHICLES.THESE OCCURRENCES MAY POSE A RISK OF DRIVER DISTRACTION AND/OR OCCUPANT INJURY.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-001) TO FURTHER ASSESS THIS MATTER AND WILL INCLUDE MY 2006 SRX VEHICLES.