NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
24 reportsClear category filter183,000 miles · Jan 6, 2017
Air BagsElectrical System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. WHILE DRIVING 30 MPH, THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS SUDDENLY DEPLOYED WITHOUT IMPACT OR WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN NOTICED WATER LEAKING FROM THE AIR CONDITIONING UNIT INTO THE AIR BAG COMPUTER SYSTEM, WHIC…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. WHILE DRIVING 30 MPH, THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS SUDDENLY DEPLOYED WITHOUT IMPACT OR WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN NOTICED WATER LEAKING FROM THE AIR CONDITIONING UNIT INTO THE AIR BAG COMPUTER SYSTEM, WHICH CAUSED THE AIR BAGS TO FAIL. AS A RESULT, THE CONTACT WAS INFORMED THAT THE AIR BAGS AND OTHER UNKNOWN PARTS RELATED TO THE COMPUTER SYSTEM AND AIR CONDITIONING UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 183,000.
NHTSA ODI #10940061
117,000 miles · Oct 31, 2016
Electrical SystemFuel/propulsion System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK. ALSO, WHEN THE VEHICLE WAS STARTED, THE PASS KEY LOCK WARNING INDICATOR FLASHED. THE KEY WOULD NOT TURN OVER TO START THE VEHICLE ON SEVERAL OCCASIONS. THE VEHICLE WAS UNABLE TO BE DRIVEN EACH TIME THE FAILURE OCCURRED. THE VIN WAS NOT I…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK. ALSO, WHEN THE VEHICLE WAS STARTED, THE PASS KEY LOCK WARNING INDICATOR FLASHED. THE KEY WOULD NOT TURN OVER TO START THE VEHICLE ON SEVERAL OCCASIONS. THE VEHICLE WAS UNABLE TO BE DRIVEN EACH TIME THE FAILURE OCCURRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 95V224000 (EQUIPMENT) AND 04V110000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND RECOMMENDED THAT THE VEHICLE BE TAKEN TO A DEALER FOR FURTHER DIAGNOSTIC TESTING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 117,000.
NHTSA ODI #10920198
80,000 miles · Mar 21, 2014
Air BagsElectrical SystemEngine
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THE CRANK SHAFT SENSORS, SPARKS PLUGS AND IDLE AIR CONTROL VALVE NEEDED TO BE REPLACED THE VEHICLE WAS NOT REPAIRED. . THE CONTACT TOOK THE VEHICLE TO AN I…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THE CRANK SHAFT SENSORS, SPARKS PLUGS AND IDLE AIR CONTROL VALVE NEEDED TO BE REPLACED THE VEHICLE WAS NOT REPAIRED. . THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC. THE MECHANIC REPLACED THE CRANK SHAFT POSITION SENSORS,WIRING, SPARKS PLUGS AND IDLE AIR CONTROL VALVE. HOWEVER THE FAILURE PERSISTED. THE CONTACT STATED NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) IS THE SAME FAILURE HE EXPERIENCED. HOWEVER, THE RECALL DID NOT INCLUDE THE CONTACT'S YEAR MAKE OR MODEL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 80,000. UPDATED 07-23-14 *BF UPDATED 7/31/14*CN
NHTSA ODI #10573986
Mileage unknown · Dec 3, 2012
Electrical System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENTIRE INSTRUMENT PANEL WENT BLACK WITH THE EXCEPTION OF THE RADIO COMPONENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT TH…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENTIRE INSTRUMENT PANEL WENT BLACK WITH THE EXCEPTION OF THE RADIO COMPONENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 95V224000 (EQUIPMENT:ELECTRICAL). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10487207
Mileage unknown · Jul 19, 2012
Electrical System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE SLS. THE CONTACT WAS TRAVELING 30 MPH WHEN AN ERROR MESSAGE APPEARED INDICATING THAT THE VEHICLE WOULD NOT START. THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT A GROUNDED FUSE CAUSED A FAILURE TO THE WIRING HARNESS IN THE INSTRUMENT PA…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE SLS. THE CONTACT WAS TRAVELING 30 MPH WHEN AN ERROR MESSAGE APPEARED INDICATING THAT THE VEHICLE WOULD NOT START. THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT A GROUNDED FUSE CAUSED A FAILURE TO THE WIRING HARNESS IN THE INSTRUMENT PANEL. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.
NHTSA ODI #10466621
56,000 miles · Aug 15, 2005
Electrical System
DT: 1996 CADILLAC SEVILLE. THE CONSUMER STATED THE IGNITION CUT OUT WHILE DRIVING. THIS CAUSED THE VEHICLE TO LOSE POWER STEERING. THE VEHICLE THEN SLOWED DOWN, AND HE TURNED OFF THE IGNITION, AND THEN TURNED IT ON AGAIN. THIS HAPPENED APPROXIMATELY ONCE EVERY COUPLE OF MONTHS. THE VEHICLE WAS NOT TAKEN TO THE DEALERSHIP, …
Read full complaint
DT: 1996 CADILLAC SEVILLE. THE CONSUMER STATED THE IGNITION CUT OUT WHILE DRIVING. THIS CAUSED THE VEHICLE TO LOSE POWER STEERING. THE VEHICLE THEN SLOWED DOWN, AND HE TURNED OFF THE IGNITION, AND THEN TURNED IT ON AGAIN. THIS HAPPENED APPROXIMATELY ONCE EVERY COUPLE OF MONTHS. THE VEHICLE WAS NOT TAKEN TO THE DEALERSHIP, NOR HAD ANY OTHER MECHANIC INSPECTED THE VEHICLE. . THE CONSUMER STATED THIS HAPPENED SINCE PURCHASING THE VEHICLE. *AK
NHTSA ODI #10132845
80,000 miles · Jun 10, 2005
Electrical System
DT: THE CONSUMER'S VEHICLE HAD PROBLEMS WITH IT'S INSTRUMENT CLUSTER. THE CONSUMER SEARCHED THE INTERNET FOR A INSTRUMENT CLUSTER RECALL. HE FOUND A RECALL BUT WAS TOLD BY THE DEALER AND MANUFACTURE THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE SPEEDOMETER WOULD WILL GO FROM 10MPH TO 140 MPH AND THE TACHOMETER WOULD GO…
Read full complaint
DT: THE CONSUMER'S VEHICLE HAD PROBLEMS WITH IT'S INSTRUMENT CLUSTER. THE CONSUMER SEARCHED THE INTERNET FOR A INSTRUMENT CLUSTER RECALL. HE FOUND A RECALL BUT WAS TOLD BY THE DEALER AND MANUFACTURE THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE SPEEDOMETER WOULD WILL GO FROM 10MPH TO 140 MPH AND THE TACHOMETER WOULD GO FROM NORMAL TO 0. SOMETIMES THE VEHICLE WOULD NOT START. REFR# CADILLAC 1-333-062133, CAMPAIGN # FROM RECALL 95V224000. *NM OCCASIONALLY ALL ENGINE POWER IS ABRUPTLY LOST WITHOUT WARNING AT LOW SPEEDS OF 10-30 MPH RESULTING IN LOSS OF CONTROL WITH POWER STEERING FUNCTION LOST. ON 2 OCCASIONS THE CAR STEERED ITSELF INTO AN OPPOSING TRAFFIC LANE. NO COLLISION OCCURRED BECAUSE THE OPPOSING TRAFFIC LANE WAS FREE OF TRAFFIC. STEERING CONTROL WITHOUT POWER STEERING WAS IMPOSSIBLE AFTER ENGINE FAILURE. *TT
NHTSA ODI #10119909
91,000 miles · Dec 2, 2004
Electrical System
CONSUMER'S VEHICLE EXPERIENCED THE SAME PROBLEMS AS MENTIONED IN RECALL 95V224000 CONCERNING INSTRUMENT PANEL. DEALERSHIP WILL NOT REPAIR FREE OF CHARGE BECAUSE THE VIN WAS NOT INCLUDED. *AK
NHTSA ODI #10102023
96,000 miles · Nov 1, 2004
Electrical SystemFire
WHILE BACKING OUT OF THE DRIVEWAY, SMOKE CAME FROM THE DASHBOARD. THE CONSUMER EXITED THE VEHICLE, AND IT STARTED TO BURN. PRIOR TO THE FIRE, THERE WAS A SMELL OF GAS. *AK *SC
NHTSA ODI #10094580
30,000 miles · Oct 6, 2004
Electrical System
ON SEVERAL OCCASIONS CONSUMER SMELLED SMOKE AND A BURNING ODOR COMING FROM THE STEERING COLUMN WHILE DRIVING 50 MPH. VEHICLE WAS TAKEN TO TWO SEPARATE DEALERS. BOTH DEALERS INFORMED CONSUMER THAT THE PROBLEM WAS NOT COVERED UNDER A RECALL.*AK
NHTSA ODI #10095180
Official recalls
2Mar 4, 2004
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
Nov 30, 1995
THE ANALOG INSTRUMENT PANEL CLUSTER ON THESE VEHICLES COULD HAVE AN INTERNAL SHORT CIRCUIT DISRUPTING THE PASS KEY SYSTEM, CAUSING FAILURE OF THE INSTRUMENT PANEL GAUGES AND TELL-TALES, AND A POSSIBLE NO-START CONDITION. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS;" NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT;" AND NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SHORT CIRCUIT OCCURS WHILE DRIVING, THE INSTRUMENT PANEL CLUSTER WILL GO BLANK, CAUSING LOSS OF GAUGE FUNCTION AND ALL TEEL-TALE INDICATORS EXCEPT FOR ABS, SIR, PARK BRAKE AND SERVICE ENGINE SOON. THE LOSS OF ALL TELL-TALES FOR SEAT BELTS, TURN SIGNALS, HIGH BEAM, HAZARD, OIL PRESSURE, COOLANT TEMPERATURE, AND OTHERS RESULT IN NONCOMPLIANCE WITH THESE SAFETY STANDARDS.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE INSTRUMENT PANEL CLUSTER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
Illustration