WHILE DRIVING AT 68 MPH ON ROUTE 35E 40 MILES SOUTH OF DALLAS, TEXAS, THE RIGHT FRONT WHEEL CAME OFF THE CAR. ALL FIVE OF THE LUG STUDS SHEARED OF AT THE FACE OF THE ROTOR ASSEMBLY. THE TIRE WEDGED AGAINST THE LOWEST REAR PART OF THE FENDER WELL WHICH RESULTED IN A CLEAN CUT THROUGH THE TIRE SIDEWALL. I WAS TRAVELLING IN THE …
Read full complaint
WHILE DRIVING AT 68 MPH ON ROUTE 35E 40 MILES SOUTH OF DALLAS, TEXAS, THE RIGHT FRONT WHEEL CAME OFF THE CAR. ALL FIVE OF THE LUG STUDS SHEARED OF AT THE FACE OF THE ROTOR ASSEMBLY. THE TIRE WEDGED AGAINST THE LOWEST REAR PART OF THE FENDER WELL WHICH RESULTED IN A CLEAN CUT THROUGH THE TIRE SIDEWALL. I WAS TRAVELLING IN THE RIGHT HAND LANE AND WAS ABLE TO BRING THE CAR TO A SAFE STOP ON THE RIGHT SHOULDER OF THE ROAD. THE TIRE TRAVELED ABOUT 350 YARDS ACROSS THE RIGHT HAND DRAINAGE AREA AND STOPPED IN A CULTIVATED FIELD ABOUT 100 YARDS FROM WHERE I STOPPED THE CAR. THE TIRE HAD BEEN PUT ON THE CAR ABOUT THREE WEEKS PRIOR TO THIS INCIDENT AND HAD BEEN TORQUED TO THE MANUFACTURERS SPECIFICATIONS OF 100 FT/LBS. THE ROTOR REQUIRED REPLACEMENT ALONG WITH THE SHIELD THAT IS INSTALLED BEHIND THE ROTOR. THE RIGHT FRONT QUARTER PANEL (FENDER) WILL REQUIRE EXTENSIVE WORK OR REPLACEMENT. CADILLAC HAS SAID THAT THE LUG NUTS WERE OVERTORQUED AT SOME POINT. IT IS MY OPINION THAT THE STUDS FAILED BECAUSE OF THE MATERIAL THAT WAS USED IN MANUFACTURE. I FEEL THAT FAILURES OF THIS TYPE ARE SERIOUS BECAUSE OF POTENTIAL TURNOVERS AND DAMAGE THAT MAY RESULT TO OTHER VEHICLES BY THE LOOSE WHEEL.*AK
NHTSA ODI #750277
Mileage unknown · Jun 21, 2001
SuspensionWheels
WHILE DRIVING 15 MONTHS AGO LEFT FRONT WHEEL FELL OFF. ALSO, WHILE DRIVING ON JUNE 18,2001, FRONT LEFT WHEEL FEEL OFF VEHICLE WITH NO PRIOR WARNING. WHEN STOPPING VEHICLE IT FELL ON THE GROUND. CONTACT DEALER. DEALER STATED IT JUST HAPPENED. *AK CONSUMER ALSO MENTIONS RECALLS 96V019 AND 96V018, POSSIBLY RELATING TO PROBLEM A…
Read full complaint
WHILE DRIVING 15 MONTHS AGO LEFT FRONT WHEEL FELL OFF. ALSO, WHILE DRIVING ON JUNE 18,2001, FRONT LEFT WHEEL FEEL OFF VEHICLE WITH NO PRIOR WARNING. WHEN STOPPING VEHICLE IT FELL ON THE GROUND. CONTACT DEALER. DEALER STATED IT JUST HAPPENED. *AK CONSUMER ALSO MENTIONS RECALLS 96V019 AND 96V018, POSSIBLY RELATING TO PROBLEM ALONG WITH THE RECALL 96V245 REGARDING LUGS, NUTS, AND BOLTS. *SLC
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: THE LOWER CONTROL ARM BALL JOINT CAN LOOSEN, FATIGUE, AND SEPARATE FROM THE FRONT SUSPENSION KNUCKLE RESULTING IN A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
THESE VEHICLES WERE PRODUCED WITH AN IMPROPERLY ADJUSTED TRANSMISSION SHIFT CONTROL LINKAGE. THIS DOES NOT MEET WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IT MAY BE POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED INCREASING THE RISK OF A VEHICLE ACCIDENT RESULTING FROM THE UNINTENDED MOVEMENT OF A PARKED VEHICLE.
Remedy: DEALERS WILL ADJUST THE SHIFT CONTROL LINKAGE SYSTEM.
THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA96007 · Rear Wheel Separation
Opened May 31, 1996 · Closed Dec 24, 1996
Status: closed (inferred from source dates) · Suspension
GM NOTIFIED ODI THAT THEY ARE CONDUCTING A RECALL TO RETORQUE THE WHEEL LUG NUTS ON VEHICLES BUILT BETWEEN AUGUST AND SEPTEMBER OF 1995.IT IS ANTICIPATED THAT MOST VEHICLES WILL REQUIRE THE WHEEL LUG NUTS TO BE RETORQUED TO 135 N.M(100 LB. FT.).CUSTOMERS WHO HAVE HAD ALL FOUR OF THEIR TIRES AND WHEELS ROTATED SHOULD HAVE PROPERLY TORQUED LUG NUTS.HOWEVER, GM IS OFFERING CUSTOMERS WHO HAVE HAD THEIR TIRES AND WHEELS ROTATED THE OPTION OF RETURNING TO THEIR DEALER FOR THIS REPAIR OR COMPLETING AND RETURNING AN OWNER REPLY CARD INCLUDED WITH THEIR RECALL NOTICE.THIS ENGINEERING ANALYSIS IS CLOSED.
1995 Cadillac Fleetwood Problems, Complaints & Recalls | Skip That Year
Illustration