NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
17 reportsClear category filterMileage unknown · Aug 15, 2026
Power Train
The transmission has experienced ongoing shifting problems, including extremely hard shifts at low speeds and difficulty shifting properly at higher/highway speeds. The hard shifting could cause the vehicle to jerk unexpectedly, and the difficulty shifting at higher speeds caused concern about the vehicle’s ability to accelerate…
Read full complaint
The transmission has experienced ongoing shifting problems, including extremely hard shifts at low speeds and difficulty shifting properly at higher/highway speeds. The hard shifting could cause the vehicle to jerk unexpectedly, and the difficulty shifting at higher speeds caused concern about the vehicle’s ability to accelerate and maintain predictable power while driving. Because of the ongoing shifting problems, we paid to have the vehicle tuned in an attempt to improve the shifting, but the transmission problems continued. More recently, after routine transmission fluid service, the transmission became significantly worse and the vehicle would not properly move in either Drive or Reverse. The vehicle has not been diagnosed or repaired by a dealership. The transmission is currently being inspected and repaired privately, and components can be retained if needed. The shifting problems were present before the recent transmission fluid service.
NHTSA ODI #11757087
Mileage unknown · Jul 7, 2023
EnginePower Train
The engine seized while driving in the middle of the road. I was very fortunate that there was no incident. For others that drove at highway speed, accidents or fatalities may occur. GM is aware of this problem and elect not to do anything. Because of the high amount of engines faulty, the engines are 8-10 months back-order.
NHTSA ODI #11530828
Mileage unknown · Feb 3, 2023
Power Train
It has a pulsing action and massive vibration when under normal acceleration. It makes it so you have to give it more throttle or stop completely. It's a known transmission problem that GM knows about but will do nothing to fix. They even have a TSB out about it. It makes the vehicle very unsafe and hard to drive.
NHTSA ODI #11505326
54,000 miles · May 7, 2021
Power TrainSuspension
SOMETIMES BANGS INTO GEAR SO HARD IT FEELS LIKE YOU?VE BEEN IN AN ACCIDENT. IT'S BEEN IN THE SHOP 4 TIMES FOR THE SAME PROBLEM.
NHTSA ODI #11415585
50,000 miles · Mar 14, 2021
Power Train
THIS VEHICLE HAS HAD ONGOING TRANSMISSION ISSUES SINCE IT WAS PURCHASED. IT HAS BEEN TO THE DEALER 9 TIMES AND THEY CLAIM EVERYTHING IS OK BUT IT IS NOT. IT IS SLUGGISH SHIFTING, HUNTS FOR GEARS, SOMETIMES BANGS INTO GEAR SO HARD IT FEELS LIKE YOU'VE BEEN IN AN ACCIDENT, SHUTTERS AND SHAKES, AND THIS HAPPENS REGULARLY REGARDLESS…
Read full complaint
THIS VEHICLE HAS HAD ONGOING TRANSMISSION ISSUES SINCE IT WAS PURCHASED. IT HAS BEEN TO THE DEALER 9 TIMES AND THEY CLAIM EVERYTHING IS OK BUT IT IS NOT. IT IS SLUGGISH SHIFTING, HUNTS FOR GEARS, SOMETIMES BANGS INTO GEAR SO HARD IT FEELS LIKE YOU'VE BEEN IN AN ACCIDENT, SHUTTERS AND SHAKES, AND THIS HAPPENS REGULARLY REGARDLESS OF HOW FAST YOU'RE DRIVING OR WHAT TYPE OF ROAD.
NHTSA ODI #11402889
12,000 miles · Oct 5, 2020
Power Train
TL* THE CONTACT OWNS A 2016 CADILLAC ESCALADE. THE CONTACT STATED THAT WHILE DRIVING AT HIGHWAY SPEEDS, THE VEHICLE VIOLENTLY SHOOK AND SHUDDERED WITHOUT WARNING. ADDITIONALLY, WHILE DRIVING AT VERY SLOW SPEEDS, THE VEHICLE INADVERTENTLY LUNGED FORWARD. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER INGERSOLL OF DANBURY LOCATED AT 84…
Read full complaint
TL* THE CONTACT OWNS A 2016 CADILLAC ESCALADE. THE CONTACT STATED THAT WHILE DRIVING AT HIGHWAY SPEEDS, THE VEHICLE VIOLENTLY SHOOK AND SHUDDERED WITHOUT WARNING. ADDITIONALLY, WHILE DRIVING AT VERY SLOW SPEEDS, THE VEHICLE INADVERTENTLY LUNGED FORWARD. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER INGERSOLL OF DANBURY LOCATED AT 84 FEDERAL RD, DANBURY, CT 06810, WHO WAS UNABLE TO DUPLICATE THE FAILURE OR DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 12,000.
NHTSA ODI #11362745
52,000 miles · Jul 15, 2020
Power Train
VEHICLE HAS BEEN TO THE DEALER 5 TIMES FOR TRANSMISSION AND TORQUE CONVERTER ISSUES RELATED TO HARSH SHIFTING, STUTTERING, SLAMMING INTO GEAR AND OTHERWISE TERRIBLE SHIFTING. THE FLUID HAS BEEN FLUSHED 4 TIMES AND NOTHING HAS SOLVED THE PROBLEMS AND THEY CLAIM THERE IS NOTHING WRONG AND CHARGED ME A DIAGNOSTIC FEE THE LAST TIME …
Read full complaint
VEHICLE HAS BEEN TO THE DEALER 5 TIMES FOR TRANSMISSION AND TORQUE CONVERTER ISSUES RELATED TO HARSH SHIFTING, STUTTERING, SLAMMING INTO GEAR AND OTHERWISE TERRIBLE SHIFTING. THE FLUID HAS BEEN FLUSHED 4 TIMES AND NOTHING HAS SOLVED THE PROBLEMS AND THEY CLAIM THERE IS NOTHING WRONG AND CHARGED ME A DIAGNOSTIC FEE THE LAST TIME TO PERFORM NO ACTUAL WORK.
NHTSA ODI #11339586
25,000 miles · Jun 11, 2020
Power Train
WHEN FIRST STARTING IN THE MORNING, MY ESCALADE ESV MAKES HORRIBLE CLUNKING SOUNDS FROM THE TRANSMISSION. WHEN I PUT IT INTO GEAR, IT JUMPS FORWARD. WHILE DRIVING, THE TRUCK IS VERY JUMPY AND SHIFTS HARD. I DON'T DRIVE THE TRUCK HARD AS ITS MEANT FOR CRUISING AND NOT RACING. THE TRUCK HAS 31000 MILES ON IT CURRENTLY. I SEE THERE…
Read full complaint
WHEN FIRST STARTING IN THE MORNING, MY ESCALADE ESV MAKES HORRIBLE CLUNKING SOUNDS FROM THE TRANSMISSION. WHEN I PUT IT INTO GEAR, IT JUMPS FORWARD. WHILE DRIVING, THE TRUCK IS VERY JUMPY AND SHIFTS HARD. I DON'T DRIVE THE TRUCK HARD AS ITS MEANT FOR CRUISING AND NOT RACING. THE TRUCK HAS 31000 MILES ON IT CURRENTLY. I SEE THERE ARE OTHER COMPLAINTS WITH THE SAME ISSUE. GM NEEDS TO FIX THIS! *TR
NHTSA ODI #11328295
35,000 miles · Oct 10, 2019
Electrical SystemPower Train
AROUND 20,000 MILES WE STARTED DOCUMENTING ISSUES WITH THE DRIVE TRAIN BY TAKING IT INTO THE DEALERSHIP BUT WE HAD HAD THESE ISSUES PRIOR TO THE 20,000 MILE MARK. WHEN YOU WOULD BE TRAVELING AROUND 20 MPH AND TRAFFIC WOULD SLOW DOWN NEARLY COMING TO A STOP AND THEN SPEEDS WOULD PICK UP BACK AND YOU BEGAN TO ACCELERATE IT WOULD …
Read full complaint
AROUND 20,000 MILES WE STARTED DOCUMENTING ISSUES WITH THE DRIVE TRAIN BY TAKING IT INTO THE DEALERSHIP BUT WE HAD HAD THESE ISSUES PRIOR TO THE 20,000 MILE MARK. WHEN YOU WOULD BE TRAVELING AROUND 20 MPH AND TRAFFIC WOULD SLOW DOWN NEARLY COMING TO A STOP AND THEN SPEEDS WOULD PICK UP BACK AND YOU BEGAN TO ACCELERATE IT WOULD SHIFT WITH HARD THUD INTO GEAR. ALSO WHEN PLACING THE CAR IN REVERSE FROM PARK OR FROM REVERSE INTO DRIVE IT WOULD LUNGE FORWARD. WHEN AT A COMPLETE STOP AND SLOWLY REMOVING YOUR FOOT FROM THE BRAKE IT WOULD LUNGE FORWARD AS WELL. WE HAVE TAKEN IT INTO THE DEALERSHIP FOR THESE ISSUES A MINIMUM OF SIX TIMES WITH THE FOLLOWING OUTCOMES: 1) CANNOT DUPLICATE ISSUE 2) THEN DUPLICATED IT WAS A SOFTWARE ISSUE AND THEY UPDATED THE SOFTWARE 3) THIS IS JUST HOW THE TRANSMISSION SHIFTS - THIS IS NORMAL. THE SAME ISSUES ARE STILL OCCURRING AND MORE CONSISTENTLY WITH NO RESOLUTION FROM TWO DIFFERENT CADILLAC SERVICE DEPARTMENTS. THEN TWO WEEKS AGO THE MAIN SCREEN FOR AUDIO/THERMOSTAT/ NAVIGATION WENT COMPLETELY BLACK WHILE THE CAR WAS ON. COULD NOT CONTROL ANY OF THE AUDIO, THERMOSTAT, NAVIGATION - TRIED PRESSING THE HOME BUTTON, CONTROLS ON THE STEERING WHEEL. I TOOK A VIDEO OF THIS FOR PROOF IT HAPPENED BECAUSE I KNEW THEY WERE GOING TO TELL ME THEY COULDN'T DUPLICATE THIS. IN ADDITION, THE BLUETOOTH WOULD DISCONNECT MY PHONE INTERMITTENTLY THEN RECONNECT A FEW MINUTES LATER ALL ON ITS OWN. THE THERMOSTAT DISPLAY WILL SAY ITS 76 DEGREES BUT WILL BLOW COLD AIR ON MY MORNING 20 MINUTE DRIVE TO WORK. THIS IS OUR SECOND CADILLAC ESCALADE ESV. OUR FIRST 2004 IS STILL ON THE ROAD WITH MY DAUGHTER NOW DRIVING IT, I WISH I WOULD HAVE KEPT IT INSTEAD OF BUYING THIS ONE AS WE HAVE HAD NOTHING BUT PROBLEMS WITH IT. MY HUSBAND AND I HAVE PURCHASED 5 GM VEHICLES SINCE 1995 AND ARE SO DISAPPOINTED THAT OUR MOST EXPENSIVE PURCHASE TO DATE IS RIDDLED WITH ISSUES
NHTSA ODI #11267573
49,000 miles · Jun 21, 2019
Power Train
THE 8 SPEED TRANSMISSION HAS BEEN JERKY AT SLOW SPEEDS FROM ALMOST DAY ONE. BUT AFTER 30,000 MILES IT HAS BECOME WORSE. AT TIME AFTER STARTING THE VEHICLE AND PLACING INTO GEAR IT WILL SUDDENLY AND VIOLENTLY LUNG FORWARD OR REVERSE, WHEN ACCELERATING FROM A SLOW SPEED IT WILL STALL ABRUPTLY, TWICE CAUSING AN ENGINE CODE. TWO …
Read full complaint
THE 8 SPEED TRANSMISSION HAS BEEN JERKY AT SLOW SPEEDS FROM ALMOST DAY ONE. BUT AFTER 30,000 MILES IT HAS BECOME WORSE. AT TIME AFTER STARTING THE VEHICLE AND PLACING INTO GEAR IT WILL SUDDENLY AND VIOLENTLY LUNG FORWARD OR REVERSE, WHEN ACCELERATING FROM A SLOW SPEED IT WILL STALL ABRUPTLY, TWICE CAUSING AN ENGINE CODE. TWO DEALERS HAVE TRIED TO FIX IT, BUT HAVEN' BEEN ABLE TO. THIS SEEMS TO BE A MUCH BIGGER PROBLEM RELATED TO THE 8 SPEED TRANSMISSION IN GENERAL.
NHTSA ODI #11221758
Official recalls
4Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Apr 28, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control arm bushing.
Consequence & remedy
Consequence: Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, or GMC customer service at 1-800-462-8782. GM's number for this recall is 42190.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration