NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
218 reports115,000 miles · Mar 13, 2007
Fuel System, GasolineFire
TL*- THE CONTACT HEARD A LOUD POP COME FROM UNDER THE HOOD OF THE 1996 CADILLAC DEVILLE AND ALSO NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT TURNED THE VEHICLE OFF, AND THEN NOTICED THERE FLAMES WERE COMING FROM UNDER THE HOOD . THE FIRE DEPARTMENT ADVISED THE CONTACT THAT CAUSE OF THE FIRE WAS A PROBLEM WITH THE F…
Read full complaint
TL*- THE CONTACT HEARD A LOUD POP COME FROM UNDER THE HOOD OF THE 1996 CADILLAC DEVILLE AND ALSO NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT TURNED THE VEHICLE OFF, AND THEN NOTICED THERE FLAMES WERE COMING FROM UNDER THE HOOD . THE FIRE DEPARTMENT ADVISED THE CONTACT THAT CAUSE OF THE FIRE WAS A PROBLEM WITH THE FUEL. THE VEHICLE CURRENTLY HAD 115000 MILES. THE CONTACT STATED THERE WAS A RECALL 04014 FOR THE FUEL SYSTEM .
NHTSA ODI #10184953
100,165 miles · Jan 24, 2007
Engine And Engine CoolingVehicle Speed Control
VERY DANGEROUS SITUATION OCCURRED WHILE DRIVING ON CITY ROADS WHERE POSTED SPEEDS ARE 35-45 MPH. THE CAR JUST STARTED TO SPEED UP ON ITS OWN AND I COULD NOT GET THE ENGINE TO SLOW DOWN. THE ONLY WAY I COULD AVOID A TRAFFIC ACCIDENT WAS TO RIDE THE BRAKES CONTINUOUSLY. BY THE TIME I GOT HOME THE BRAKES WERE SMOKING AND EXTREMELY…
Read full complaint
VERY DANGEROUS SITUATION OCCURRED WHILE DRIVING ON CITY ROADS WHERE POSTED SPEEDS ARE 35-45 MPH. THE CAR JUST STARTED TO SPEED UP ON ITS OWN AND I COULD NOT GET THE ENGINE TO SLOW DOWN. THE ONLY WAY I COULD AVOID A TRAFFIC ACCIDENT WAS TO RIDE THE BRAKES CONTINUOUSLY. BY THE TIME I GOT HOME THE BRAKES WERE SMOKING AND EXTREMELY OVERHEATED. I ALMOST COULD NOT STOP WITH THE ENGINE RACING AND THE BRAKES WORN OUT. I HAD TO SHUT THE ENGINE DOWN WHILE STILL IN DRIVE, ALMOST RUNNING INTO THE WALL OF MY HOUSE. I AM 70 YEARS OLD AND WAS VERY SCARED. ON EDMUNDS .COM THERE ARE THREE OTHER REPORTED INSTANCES OF THE SAME THING HAPPENING WITH THE SAME MAKE AND MODEL. MY CAR IS UNDRIVEABLE AND I WILL HAVE TO GET IT TOWED FROM MY HOUSE TO THE DEALER FOR IT TO BE CHECKED OUT, PLEASE FOLLOW UP ON THIS AS IT IS A VERY DANGEROUS CONDITION. I WAS VERY CLOSE TO HAVING AN ACCIDENT. *JB
NHTSA ODI #10179535
Mileage unknown · Jan 15, 2007
Engine And Engine Cooling
BOUGHT VEHICLE USED FROM AUTO DEALERSHIP. FROM DAY ONE SMELLED OIL FROM UNDER HOOD, SMELLED ENGINE COOLANT LEAK. HAVING TO CONSTANTLY REFILL COOLANT LEVEL. AND COOLANT MIXED ON WITH ENGINE OIL. DEALER "COULD NOT FIND PROBLEM AFTER THREE ATTEMPTS. LATER, 3 OTHER REPAIR SHOPS ALL DIAGNOSED BLOWN HEAD GASKET. ESTIMATED COST OF REP…
Read full complaint
BOUGHT VEHICLE USED FROM AUTO DEALERSHIP. FROM DAY ONE SMELLED OIL FROM UNDER HOOD, SMELLED ENGINE COOLANT LEAK. HAVING TO CONSTANTLY REFILL COOLANT LEVEL. AND COOLANT MIXED ON WITH ENGINE OIL. DEALER "COULD NOT FIND PROBLEM AFTER THREE ATTEMPTS. LATER, 3 OTHER REPAIR SHOPS ALL DIAGNOSED BLOWN HEAD GASKET. ESTIMATED COST OF REPAIRS RANGED FROM $2800.00 TO $5200.00. *JB
NHTSA ODI #10178754
111,000 miles · Jun 16, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY, THE ENGINE STALLED WITHOUT WARNING. THE ENGINE DID NOT RESTART AND WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE FUEL PUMP ASSEMBLY WAS INOPERATIVE AND REVEALED FRAYED, MELTED WIRES. THE FUEL PUMP ASSEMBLY WAS REPLACED.…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY, THE ENGINE STALLED WITHOUT WARNING. THE ENGINE DID NOT RESTART AND WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE FUEL PUMP ASSEMBLY WAS INOPERATIVE AND REVEALED FRAYED, MELTED WIRES. THE FUEL PUMP ASSEMBLY WAS REPLACED.
NHTSA ODI #10159988
Mileage unknown · Apr 3, 2006
Vehicle Speed Control
DT*: THE CONTACT STATED ON APRIL 1ST, 2006 AFTER STOPPING FOR GASOLINE, THE ODOMETER WAS RESET FOR TRIP MILEAGE. AFTERWARDS THE VEHICLE BEGAN TO ACCELERATE CAUSING THE RPM TO INCREASE EVEN WHILE APPLYING BRAKE PRESSURE. THE VEHICLE WAS TURNED OFF. AFTER RESTARTING THE VEHICLE IT CONTINUED TO BE IN THE HIGH ACCELERATION MODE. …
Read full complaint
DT*: THE CONTACT STATED ON APRIL 1ST, 2006 AFTER STOPPING FOR GASOLINE, THE ODOMETER WAS RESET FOR TRIP MILEAGE. AFTERWARDS THE VEHICLE BEGAN TO ACCELERATE CAUSING THE RPM TO INCREASE EVEN WHILE APPLYING BRAKE PRESSURE. THE VEHICLE WAS TURNED OFF. AFTER RESTARTING THE VEHICLE IT CONTINUED TO BE IN THE HIGH ACCELERATION MODE. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP AND IS AWAITING INSPECTION. ADDITIONALLY THE CRUISE CONTROL WAS INOPERABLE ON THE VEHICLE SINCE PURCHASE. *NM
NHTSA ODI #10154383
Mileage unknown · Oct 28, 2005
Suspension
DT: THE CONTACT STATED THE TIRES DID NOT HOLD AIR PROPERLY, AND THERE WERE SMALL CRACKS AROUND THE OUTER SIDEWALLS OF THE TIRES. ALSO, THERE HAS BEEN UNEVEN WEAR PATTERN ON ALL FOUR TIRES. THIS WAS A PROBLEM SINCE PURCHASE OF VEHICLE. THE LOSS OF AIR PRESSURE MADE IT IMPOSSIBLE TO MAINTAIN THE TIRES PROPERLY. THE TIRES W…
Read full complaint
DT: THE CONTACT STATED THE TIRES DID NOT HOLD AIR PROPERLY, AND THERE WERE SMALL CRACKS AROUND THE OUTER SIDEWALLS OF THE TIRES. ALSO, THERE HAS BEEN UNEVEN WEAR PATTERN ON ALL FOUR TIRES. THIS WAS A PROBLEM SINCE PURCHASE OF VEHICLE. THE LOSS OF AIR PRESSURE MADE IT IMPOSSIBLE TO MAINTAIN THE TIRES PROPERLY. THE TIRES WERE TAKEN TO A DEALERSHIP, AND THEY STATED THE UNEVEN WEAR WAS DUE TO THE FRONT END OF THE VEHICLE. ANOTHER MECHANIC STATED THERE WAS NOTHING WRONG WITH THE FRONT END. AT THIS TIME, NO CORRECTIONS WERE MADE TO THE VEHICLE. *AK
NHTSA ODI #10141116
38,826 miles · Aug 29, 2005
Vehicle Speed Control
DRIVING OUR CAR, '96 CADILLAC DEVILLE, WITH APPROXIMATELY 38,000 MI, TRAVELING NORTH ON THE 15 FWY., APPROACHING VICTORVILLE, CA, OUR SPEED WENT OUT OF CONTROL REPEATEDLY HITTING 90+ MPH. THIS HAPPENED, EVEN THOUGH I SHIFTED THE GEARS DOWN 3,2, THEN 1, AND FLOORED THE BRAKE, THEN THE EMERGENCY BRAKE. ON CUTTING FRONT OF AN…
Read full complaint
DRIVING OUR CAR, '96 CADILLAC DEVILLE, WITH APPROXIMATELY 38,000 MI, TRAVELING NORTH ON THE 15 FWY., APPROACHING VICTORVILLE, CA, OUR SPEED WENT OUT OF CONTROL REPEATEDLY HITTING 90+ MPH. THIS HAPPENED, EVEN THOUGH I SHIFTED THE GEARS DOWN 3,2, THEN 1, AND FLOORED THE BRAKE, THEN THE EMERGENCY BRAKE. ON CUTTING FRONT OF ANOTHER, EXITING THE FREEWAY, UPHILL, COMING TO THE SIGNAL, ON BEAR VALLEY ROAD, WAS ABLE TO TURN LEFT ON A GREEN, THEN THE NEXT SIGNAL GREEN, BUT THEN A RED LIGHT, IT WAS IMPOSSIBLE TO BRING THE CAR TO A STOP. SUDDENLY A GREEN ARROW LET US TURN RIGHT, AND RIGHT IN FRONT OF A TRUCK. CONTINUING NORTH ON A FRONTAGE ROAD, SEEING A PRACTICALLY EMPTY PARKING LOT, ENTERED IT AND THEN SHUT THE ENGINE OFF, FINALLY COMING TO A STOP. CALLING AAA, WE WERE TOLD THERE WERE NO CADILLAC AGENCIES NEAR & WOULD HAVE TO TOW ALL THE WAY TO KENNEDY CADILLAC I N SAN BERNARDINO. HOWEVER, WALKED ACROSS THE PARKING LOT, INTO PENNY'S HAIR SALON, GRACIOUSLY, THE LET US LOOK IN THEIR YELLOW PAGES TO FIND RANCHO MOTOR COMPANY, CHEVROLET, CADILLAC & PONTIAC DEALERSHIP, JUST A FEW MILES AWAY. THE CAR WAS TOWED, AND WE RODE ALONG. WE WARNED EDUARDO, OUR TOWING DRIVER, ABOUT THE RISK IN STARTING THE CAR? AGAIN, ON ARRIVAL AT RANCHO AGENCY, WE WARNED OUR REPRESENTATIVE DEBBIE DEMERS OF THE RISK! THE CAUSE OF THE MOTOR RACING OR "HIGH IDLE" WAS A LOOSE CABLE CAUSING THE THROTTLE TO STAY OPEN RACING THE ENGINE TO UNCONTROLLABLE SPEEDS. IF IT WERE NOT FOR MY BEING A VERY EXPERIENCED DRIVER, WE AND OTHERS AROUND US ON THE 15 FWY. AND/OR BEAR VALLEY RD. WOULD HAVE BEEN GONNERS! HOW CAN IT BE THAT A CABLE CAN SIMPLY COME LOOSE AND CAUSE OUR CAR TO GO FORWARD AT RAMPANT SPEED? HOW IS THAT SUCH A CABLE IS NOT WELDED SECURELY SO THERE IS NO RISK? OUR CAR WAS SERVICED AT JESSOP CADILLAC, IN CATHEDRAL CITY, CA ON JULY 19, 2005 AND AUGUST 9TH HAD A BATTERY REPLACEMENT, AGAIN AT JESSOP? *JB
NHTSA ODI #10134658
62,545 miles · Jul 27, 2005
Engine And Engine Cooling
1996 CADILLAC DEVILLE HAD A CRACKED HEAD GASKET.***NO ANSWER REQUIRED***. *MR THE CRACKED GASKET CAUSED COOLANT TO LEAK FROM THE VEHICLE. *NM
NHTSA ODI #10131295
97,000 miles · Jul 8, 2005
Seats
DT: CADILLAC DEVILLE 1996. THE CONTACT STATED THAT THE ELECTRONIC BUTTONS THAT CONTROLLED THE DRIVER'S SEAT, STARTED TO MOVE IN ALL DIFFERENT WAYS, UPWARD, DOWNWARD, AND PUSHED THE CONTACT UP AGAINST THE STEERING WHEEL. WHEN SHE TRIED TO MOVE THE SEAT BACKWARD IT WOULD NOT MOVE. *AK *SC *JB
NHTSA ODI #10125881
89,000 miles · Jun 9, 2005
Electrical SystemService Brakes, Hydraulic
DT: WHILE DRIVING CALLER TRIES TO SLOW DOWN AND WITHOUT WARNING THE BRAKES LOSE POWER. WHILE AT THE STOP LIGHT IT ACCELERATES, AND SHE HAS TO FIGHT THE CAR TO KEEP IT STOPPED. WHILE IN PARK IT RACES AT 2125 RPMS. HAD CAR TO DEALER 4 TIMES FOR SAME PROBLEM. DEALER SAID IT WAS A CHIP IN COMPUTER. CAR WILL BE TOWED AGAIN TONIGHT.…
Read full complaint
DT: WHILE DRIVING CALLER TRIES TO SLOW DOWN AND WITHOUT WARNING THE BRAKES LOSE POWER. WHILE AT THE STOP LIGHT IT ACCELERATES, AND SHE HAS TO FIGHT THE CAR TO KEEP IT STOPPED. WHILE IN PARK IT RACES AT 2125 RPMS. HAD CAR TO DEALER 4 TIMES FOR SAME PROBLEM. DEALER SAID IT WAS A CHIP IN COMPUTER. CAR WILL BE TOWED AGAIN TONIGHT. MANUFACTURER HAS NOT BEEN CONTACTED YET. MANUFACTURER WAS CALLED THE LAST TIME THIS HAPPENED. *AK
NHTSA ODI #10124654
NHTSA investigations
5EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE98005 · Erratic Turn Signal Operation
Opened Feb 6, 1998 · Closed Aug 27, 1998
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration