NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
218 reports250,000 miles · Dec 31, 2018
Fuel/propulsion System
ONE DAY I COULD SMELL GAS FAIRLY STRONG, AND THEN I STOPPED AT A FRIENDS SHOP, OPENED THE HOOD AND YOU COULD SEE GAS SPURTING OUT. AS I WAS LOOKING UP THIS PART AND THEN SPOKE WITH SOMEONE THAT INFORMED ME THAT YES THERE HAD BEEN A RECALL ON THE FUEL RAIL AND THAT IT WAS CLOSED. OF COURSE I HAD TO PARK IT TO KEEP IT FROM CATCH…
Read full complaint
ONE DAY I COULD SMELL GAS FAIRLY STRONG, AND THEN I STOPPED AT A FRIENDS SHOP, OPENED THE HOOD AND YOU COULD SEE GAS SPURTING OUT. AS I WAS LOOKING UP THIS PART AND THEN SPOKE WITH SOMEONE THAT INFORMED ME THAT YES THERE HAD BEEN A RECALL ON THE FUEL RAIL AND THAT IT WAS CLOSED. OF COURSE I HAD TO PARK IT TO KEEP IT FROM CATCHING ON FIRE.. IT'S A 1996 CADILLAC DEVILLE AND IT'S IN MINT CONDITION. I AM ASKING FOR SOME HELP IN GETTING THIS REPAIRED/REPLACED.
NHTSA ODI #11164233
160,000 miles · Dec 29, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE PLACING FUEL IN THE VEHICLE, THE CONTACT OBSERVED FUEL LEAKING FROM UNDERNEATH THE VEHICLE BY THE FUEL TANK. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS), BUT THE REMEDY FAILED TO REPAIR THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE PLACING FUEL IN THE VEHICLE, THE CONTACT OBSERVED FUEL LEAKING FROM UNDERNEATH THE VEHICLE BY THE FUEL TANK. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10938535
106,000 miles · Aug 5, 2015
Seat Belts
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE FRONT DRIVER AND REAR SEAT BELTS FAILED TO LOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.
NHTSA ODI #10746426
189,102 miles · Jul 4, 2015
Seat Belts
MY SEAT BELT ON THE DRIVER SIDE WILL NOT LATCH. THE TONGUE WILL NOT INSERT INTO THE BUCKLE. I REPORTED THE PROBLEM TO GM/ CADILLAC AND WAS TOLD TO VISIT THE LOCAL DEALER. THE REPRESENTATIVE OF THE DEALER IN ZANESVILLE, OHIO TOLD ME THE SEAT BELT BUCKLE WAS NO LONGER AVAILABLE. SINCE I NEVER USE THE MIDDLE BACK SEAT AND IT HA…
Read full complaint
MY SEAT BELT ON THE DRIVER SIDE WILL NOT LATCH. THE TONGUE WILL NOT INSERT INTO THE BUCKLE. I REPORTED THE PROBLEM TO GM/ CADILLAC AND WAS TOLD TO VISIT THE LOCAL DEALER. THE REPRESENTATIVE OF THE DEALER IN ZANESVILLE, OHIO TOLD ME THE SEAT BELT BUCKLE WAS NO LONGER AVAILABLE. SINCE I NEVER USE THE MIDDLE BACK SEAT AND IT HAS THE IDENTICAL BUCKLE, MY SUGGESTION WAS TO REMOVE THE SEAT BELT FOR THE MIDDLE BACK SEAT AND USE THE BUCKLE FOR MY DRIVER'S SEAT. I WAS TOLD FOR LEGAL REASON THEY COULD NOT DO THIS. SO IT IS OK FOR ME THE DRIVER NOT TO HAVE A SEAT BELT WHEN THE PART IS NOT AVAILABLE THROUGH GM BUT IS AVAILABLE IN MY MIDDLE BACK SEAT WHICH IS NEVER USED. I NOTICED THE 91 CADILLAC DEVILLE HAD A RECALL FOR A SIMILAR PROBLEM.
NHTSA ODI #10731936
74,000 miles · Oct 15, 2012
Engine
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE BEGAN TO RUN HOT AS SOON AS THE ENGINE WAS STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE HE WAS INFORMED THAT THE ENGINE BLOCK WAS CRACKED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD REPAIR THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE BEGAN TO RUN HOT AS SOON AS THE ENGINE WAS STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE HE WAS INFORMED THAT THE ENGINE BLOCK WAS CRACKED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD REPAIR THE VEHICLE AT THEIR COST AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A LOCAL DEALER. THE DEALER STATED TO THE CONTACT THAT THE MANUFACTURER ADVISED THEM NOT TO MAKE ANY REPAIRS TO THE VEHICLE. A LETTER WAS WRITTEN TO THE CHIEF EXECUTIVE OFFICER WHO RESPONDED THAT THEY WOULD NOT ASSIST IN THE REPAIR OF THE VEHICLE. THE FAILURE AND CURRENT MILEAGE WAS 74,000.
NHTSA ODI #10480161
17,000 miles · Apr 15, 2011
Engine And Engine Cooling
MY FATHER PURCHASED A 1996 SEDAN DEVILLE BRAND NEW. HE PASSED AWAY IN APRIL 1998. MY MOTHER DROVE THE CAR UNTIL THIS YEAR. SHE GAVE ME THE CAR. THE CAR HAS APPROX 17,000 MILES. I JUST FOUND OUT THE CAR HAS A BLOWN REAR HEAD GASKET. I REALIZE THE CAR IS 15 YRS OLD BUT I FEEL THIS SHOULD NOT HAVE HAPPENED WITH SUCH LOW MILEAGE. TH…
Read full complaint
MY FATHER PURCHASED A 1996 SEDAN DEVILLE BRAND NEW. HE PASSED AWAY IN APRIL 1998. MY MOTHER DROVE THE CAR UNTIL THIS YEAR. SHE GAVE ME THE CAR. THE CAR HAS APPROX 17,000 MILES. I JUST FOUND OUT THE CAR HAS A BLOWN REAR HEAD GASKET. I REALIZE THE CAR IS 15 YRS OLD BUT I FEEL THIS SHOULD NOT HAVE HAPPENED WITH SUCH LOW MILEAGE. THE CAR WAS NEVER ABUSED AND STILL SMELLS NEW INSIDE. DO I HAVE ANY RECOURSE WITH GM? *TR
NHTSA ODI #10396042
154,000 miles · Nov 8, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS) YET THE CONTACT CONTINUED TO EXPERIENCE FAILURES WITH THE VEHICLE AFTER REPAIRS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FAC…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS) YET THE CONTACT CONTINUED TO EXPERIENCE FAILURES WITH THE VEHICLE AFTER REPAIRS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE A DIAGNOSTIC WAS PERFORMED AND THE MECHANIC ADVISED THE CONTACT THAT THE PLASTIC TUBING CONNECTED TO THE STAINLESS STEEL FUEL RAIL FAILED, CAUSING FUEL TO SPRAY INTO THE ENGINE. THE MANUFACTURER ADVISED THE CONTACT THAT THE TUBING WAS NO LONGER MANUFACTURED THEREFORE THEY COULD NOT AUTHORIZE THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 154,000.
NHTSA ODI #10364962
160,000 miles · Sep 10, 2010
VisibilityInjury
TL*THE CONTACT OWNS 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE ANTI FREEZE CAME OVER THE FIREWALL AND CAUSED SECOND DEGREE BURNS TO HIS FEET. THE CONTACT WAS TRAVELING 55 MPH WHEN THIS OCCURRED. THE MECHANIC STATED THAT THE HEATER CORE FAILED ON THE VEHICLE AND ALLOWED THE ANTI FREEZE TO LEAK INTO THE VEHICLE. THE VIN WA…
Read full complaint
TL*THE CONTACT OWNS 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE ANTI FREEZE CAME OVER THE FIREWALL AND CAUSED SECOND DEGREE BURNS TO HIS FEET. THE CONTACT WAS TRAVELING 55 MPH WHEN THIS OCCURRED. THE MECHANIC STATED THAT THE HEATER CORE FAILED ON THE VEHICLE AND ALLOWED THE ANTI FREEZE TO LEAK INTO THE VEHICLE. THE VIN WAS NOT AVAILABLE AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 160000 AND THE CURRENT MILEAGE WAS 167000.
NHTSA ODI #10354918
90,201 miles · Aug 19, 2010
Vehicle Speed Control
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE ABNORMALLY ACCELERATED UNTIL HEAVY PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE FAILURE WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER YET THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPA…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE ABNORMALLY ACCELERATED UNTIL HEAVY PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE FAILURE WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER YET THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 90,201.
NHTSA ODI #10350630
Mileage unknown · Apr 8, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. ON A SEPARATE OCCASION, THE ODOR WAS PRESENT WHEN THE ENGINE WAS STARTED AFTER SEVERAL ATTEMPTS. THERE WERE NO WARNINGS PRIOR TO THE FAILURES. TH…
Read full complaint
TL*THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. ON A SEPARATE OCCASION, THE ODOR WAS PRESENT WHEN THE ENGINE WAS STARTED AFTER SEVERAL ATTEMPTS. THERE WERE NO WARNINGS PRIOR TO THE FAILURES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE NYLON TUBING USED IN THE FUEL RAIL CONTRIBUTED TO FUEL LEAKAGE IN THE ENGINE. THE ORIGINAL PART WAS DISCONTINUED AND THE REPLACEMENT COMPONENT WOULD COST $400. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY;HOSES, LINES/PIPING, AND FITTINGS), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN AND MILEAGES WERE UNKNOWN.
NHTSA ODI #10264496
NHTSA investigations
5EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE98005 · Erratic Turn Signal Operation
Opened Feb 6, 1998 · Closed Aug 27, 1998
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration