NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
33 reportsClear category filter154,000 miles · Nov 8, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS) YET THE CONTACT CONTINUED TO EXPERIENCE FAILURES WITH THE VEHICLE AFTER REPAIRS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FAC…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS) YET THE CONTACT CONTINUED TO EXPERIENCE FAILURES WITH THE VEHICLE AFTER REPAIRS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE A DIAGNOSTIC WAS PERFORMED AND THE MECHANIC ADVISED THE CONTACT THAT THE PLASTIC TUBING CONNECTED TO THE STAINLESS STEEL FUEL RAIL FAILED, CAUSING FUEL TO SPRAY INTO THE ENGINE. THE MANUFACTURER ADVISED THE CONTACT THAT THE TUBING WAS NO LONGER MANUFACTURED THEREFORE THEY COULD NOT AUTHORIZE THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 154,000.
NHTSA ODI #10364962
Mileage unknown · Apr 8, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. ON A SEPARATE OCCASION, THE ODOR WAS PRESENT WHEN THE ENGINE WAS STARTED AFTER SEVERAL ATTEMPTS. THERE WERE NO WARNINGS PRIOR TO THE FAILURES. TH…
Read full complaint
TL*THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. ON A SEPARATE OCCASION, THE ODOR WAS PRESENT WHEN THE ENGINE WAS STARTED AFTER SEVERAL ATTEMPTS. THERE WERE NO WARNINGS PRIOR TO THE FAILURES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE NYLON TUBING USED IN THE FUEL RAIL CONTRIBUTED TO FUEL LEAKAGE IN THE ENGINE. THE ORIGINAL PART WAS DISCONTINUED AND THE REPLACEMENT COMPONENT WOULD COST $400. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY;HOSES, LINES/PIPING, AND FITTINGS), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN AND MILEAGES WERE UNKNOWN.
NHTSA ODI #10264496
114,000 miles · Jul 16, 2008
Fuel System, Gasoline
UPON APPROACHING THE 1996 CADILLAC DEVILLE IT WAS NOTED THAT A FLUID WAS DRIPPING FROM BEHIND THE LEFT FRONT WHEEL. INSPECTION REVEALED THAT THE LEAK WAS GASOLINE - OPENING THE HOOD FOUND NO LEAKS. CAR WAS STARTED IN ORDER TO RELOCATE IT IN THE DRIVE WAY, WITHIN A MINUTE OF STARTING THERE WAS A STRONG BLAST OF VAPORIZED GASOLINE…
Read full complaint
UPON APPROACHING THE 1996 CADILLAC DEVILLE IT WAS NOTED THAT A FLUID WAS DRIPPING FROM BEHIND THE LEFT FRONT WHEEL. INSPECTION REVEALED THAT THE LEAK WAS GASOLINE - OPENING THE HOOD FOUND NO LEAKS. CAR WAS STARTED IN ORDER TO RELOCATE IT IN THE DRIVE WAY, WITHIN A MINUTE OF STARTING THERE WAS A STRONG BLAST OF VAPORIZED GASOLINE SPRAYING ON THE DRIVEWAY. CAR WAS IMMEDIATELY SHUTOFF. FURTHER INSPECTION SHOWED THERE WAS A LEAK FROM THE PLASTIC FUEL LINE UNDER THE FLOOR AT A LOCATION UNDER THE DRIVER'S SEAT. THE PLASTIC FUEL LINE IS MOUNTED PARALLEL THE BODY AND IT IS ABOUT 9 INCHES OUTBOARD OF THE CATALYTIC CONVERTER. THIS WAS THE FIRST TIME THAT DAY THAT THE CAR WAS STARTED. THE CAR WAS TOWED TO THE CADILLAC DEALER WHERE IT WAS REPAIRED BY INSTALLING A NEW FUEL HARNESS - PART NUMBER 25644121 AT A COST OF $608 TO ME. ANY DESIGN THAT USES PLASTIC (NYLON) FUEL LINES PLACED SO CLOSE TO THE HOTTEST PART OF THE CAR IS JUST PLAIN IRRESPONSIBLE ! *TR
NHTSA ODI #10234486
90,000 miles · Dec 19, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT SMELLED FUEL UPON STARTING THE VEHICLE. HE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASIONS AND EACH TIME THE DEALER STATED THEY RAN…
Read full complaint
TL*THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT SMELLED FUEL UPON STARTING THE VEHICLE. HE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASIONS AND EACH TIME THE DEALER STATED THEY RAN OUT OF PARTS. THE CONTACT HAD SCHEDULED REPAIR APPOINTMENTS. THE FAILURE MILEAGE WAS 90,000 AND CURRENT MILEAGE WAS 101,000.
NHTSA ODI #10212316
115,000 miles · Mar 13, 2007
Fuel System, GasolineFire
TL*- THE CONTACT HEARD A LOUD POP COME FROM UNDER THE HOOD OF THE 1996 CADILLAC DEVILLE AND ALSO NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT TURNED THE VEHICLE OFF, AND THEN NOTICED THERE FLAMES WERE COMING FROM UNDER THE HOOD . THE FIRE DEPARTMENT ADVISED THE CONTACT THAT CAUSE OF THE FIRE WAS A PROBLEM WITH THE F…
Read full complaint
TL*- THE CONTACT HEARD A LOUD POP COME FROM UNDER THE HOOD OF THE 1996 CADILLAC DEVILLE AND ALSO NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT TURNED THE VEHICLE OFF, AND THEN NOTICED THERE FLAMES WERE COMING FROM UNDER THE HOOD . THE FIRE DEPARTMENT ADVISED THE CONTACT THAT CAUSE OF THE FIRE WAS A PROBLEM WITH THE FUEL. THE VEHICLE CURRENTLY HAD 115000 MILES. THE CONTACT STATED THERE WAS A RECALL 04014 FOR THE FUEL SYSTEM .
NHTSA ODI #10184953
111,000 miles · Jun 16, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY, THE ENGINE STALLED WITHOUT WARNING. THE ENGINE DID NOT RESTART AND WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE FUEL PUMP ASSEMBLY WAS INOPERATIVE AND REVEALED FRAYED, MELTED WIRES. THE FUEL PUMP ASSEMBLY WAS REPLACED.…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY, THE ENGINE STALLED WITHOUT WARNING. THE ENGINE DID NOT RESTART AND WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE FUEL PUMP ASSEMBLY WAS INOPERATIVE AND REVEALED FRAYED, MELTED WIRES. THE FUEL PUMP ASSEMBLY WAS REPLACED.
NHTSA ODI #10159988
46,000 miles · Jan 7, 2005
Fuel System, Gasoline
AFTER BRINGING THE VEHICLE TO DEALER FOR FUEL RAIL RECALL REPAIRS VEHICLE STARTED UP SLOWLY. THEN, CONSUMER TOOK THE VEHICLE TO DEALER FOR AN OIL CHANGE, AND MECHANIC DISCOVERED RANCHED, PLIERS, AND A SOCKET EXTENSION. DEALER WAS CONTACTED, AND THEY STATED THEY WANTED THEM BACK. VEHICLE WAS STILL RUNNING VERY ROUGHLY…
Read full complaint
AFTER BRINGING THE VEHICLE TO DEALER FOR FUEL RAIL RECALL REPAIRS VEHICLE STARTED UP SLOWLY. THEN, CONSUMER TOOK THE VEHICLE TO DEALER FOR AN OIL CHANGE, AND MECHANIC DISCOVERED RANCHED, PLIERS, AND A SOCKET EXTENSION. DEALER WAS CONTACTED, AND THEY STATED THEY WANTED THEM BACK. VEHICLE WAS STILL RUNNING VERY ROUGHLY, AND THE DEALER WANTED TO REPLACE THE FUEL PUMP. THE CONSUMER WAS CHARGED $50.00 TO ANALYZE THE DEFECT.*AK
NHTSA ODI #10107000
58,605 miles · Dec 30, 2004
Fuel System, Gasoline
LTR REQUEST REIMBURSEMENT OF REPAIR FOR RECALLED FUEL PUMP ON THEIR 1996 CADILLAC DEVILLE. *BF NHTSA CAMPAIGN ID NUMBER : 04V110000. THE VEHICLE STALLED DUE TO A LOSS OF FUEL PRESSURE TO THE ENGINE. THE SERVICE DEPT FOUND THE FUEL PUMP FUSE BLOWN. *TC *JB
NHTSA ODI #10105569
Mileage unknown · Dec 1, 2004
Fuel System, Gasoline
REIMBURSEMENT REQUEST WAS NOT HONEST IN ANY WAY. *BF THE CONSUMERS VEHICLE STALLS AT 75 MPH. THE DEALER STATED THAT A REIMBURSMENT IS NOT POSSIBLE BECAUSE THE REPLACEMENT OF THE FUEL RAIL WAS NOT IN THE RECALL. NHTSA CAMPAIGN ID NUMBER : 04V110000. *TC *JB
NHTSA ODI #10105414
Mileage unknown · Nov 8, 2004
Fuel System, Gasoline
CADILLAC DEVILLE 1996, FILLER AND VAPOR RETURN FUEL LINES RUSTED THROUGH. *BF THE CONSUMER WAS INFORMED OF A RECALL, HOWEVER THE PROBLEM WITH THE FUEL SYSTEM WAS NOT RELATED TO THE RECALL, WHICH DEALT WITH CRACKS IN THE INJECTION FUEL LINES. *JB
NHTSA ODI #10117146
NHTSA investigations
5EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE98005 · Erratic Turn Signal Operation
Opened Feb 6, 1998 · Closed Aug 27, 1998
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration