IllustrationTHE WIRE TO THE FUEL TANK OVER HEATED AND CAUSED THE FUEL PUMP TO FAIL. *JB UPDATED 12-12-07. *KB THE FUEL PUMP HARNESS HAD MELTED. UPDATED*JB
1995 Cadillac Deville
Owner reports · Recalls · Investigations
More warning signs than most Deville years
Owner complaints for the 1995 Cadillac Deville are substantially higher than the model-year median of 44.
About this comparison →How this year compares
Owner complaints by model year
Compare all Deville years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 20 of 129 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports6 fire reports7 injury reports
Fuel System, Gasoline complaints
32 reportsCONSUMER DOES NOT FEEL SAFE WITH VEHICLE DUE TO UNEXPECTED POWER FAILURE. HAD NO OTHER CHOICE BUT TO SELL VEHICLE. VEHICLE HAS HAD REPAIRS ON THE FOLLOWING: WATER PUMP, FUEL SYSTEM, AND IGNITION MODULE. NONE OF WHICH SOLVED THE PROBLEM). DEALER WANTED TO GIVE THE CONSUMER A $1000.00 OWNER LOYALTY CERTIFICATE WHICH COULD BE …
Read full complaint
CONSUMER DOES NOT FEEL SAFE WITH VEHICLE DUE TO UNEXPECTED POWER FAILURE. HAD NO OTHER CHOICE BUT TO SELL VEHICLE. VEHICLE HAS HAD REPAIRS ON THE FOLLOWING: WATER PUMP, FUEL SYSTEM, AND IGNITION MODULE. NONE OF WHICH SOLVED THE PROBLEM). DEALER WANTED TO GIVE THE CONSUMER A $1000.00 OWNER LOYALTY CERTIFICATE WHICH COULD BE USED UPON THE TRADE OF A NEW VEHICLE. BUT THE CONSUMER FELT THAT WAS INADEQUATE AND TRADED THE VEHICLE IN ON HIS OWN TERMS AFTER HAVING NUMEROUS DIFFICULTIES W/VARIOUS DEALERSHIP REPRESENTATIVES(STATED IN LETTER). CONSUMER EXPECTS TO RECEIVE A REFUND OF THE MONIES HE HAD SPENT ON GETTING THE VEHICLE REPAIRED. *SCC...*AK
IN-TANK FUEL PUMP UNIT MOTOR FAILURE CAUSED A HIGH-CURRENT DRAW. PRIOR TO FUSE BLOWING, IN-TANK WIRING BECAME HOT ENOUGH TO MELT THE WIRE INSULATION. THIS IS A SERIOUS SAFETY CONDITION. HAD THE WIRE COME OFF THE TERMINAL AND CREATED A SPARK, THE RESULTING EXPLOSION COULD HAVE KILLED THE DRIVER AND ANY PASSENGERS.*JB
VEHICLE EXPERIENCING INTERMITTENT STALLING AT HIGHWAY SPEEDS, VEHICLE WILL RESTART AND WILL STALL AGAIN USUALLY WITHIN ONE MILE, DEALER FINALLY DETECTED THE PROBLEM AS THE FUEL PUMP. *MJ
WHILE DRIVINMG 70 MPH VEHICLE STALLED. VEHICLE TAKEN TO DEALER WHO DETERMINED THAT MOTOR OF FUEL PUMP GOT HOT AND MELTED WIRES, CAUSING VEHICLE TO STALL. DEALER REPLACED FUEL PUMP. THIS HAPPENED ONCE BEFORE IN NOVEMBER, 1999. *AK
ORIGINAL FUEL PUMP WAS REPLACED 09/99 AT APPROXIMATELY 37,000 MILES. SECOND FUEL PUMP REPLACED 11/01 AT 48,343 MILES. BOTH FAILURES OCCURRED AFTER THE HOT WIRE INSIDE THE TANK AND ATTACHED TO THE FUEL PUMP MOTOR OVER HEATED, MELTED THE WIRING INSULATION AND SCORCHED THE ASSEMBLY HOUSING AND CONNECTORS. ON THE FIRST FAILURE THE…
Read full complaint
ORIGINAL FUEL PUMP WAS REPLACED 09/99 AT APPROXIMATELY 37,000 MILES. SECOND FUEL PUMP REPLACED 11/01 AT 48,343 MILES. BOTH FAILURES OCCURRED AFTER THE HOT WIRE INSIDE THE TANK AND ATTACHED TO THE FUEL PUMP MOTOR OVER HEATED, MELTED THE WIRING INSULATION AND SCORCHED THE ASSEMBLY HOUSING AND CONNECTORS. ON THE FIRST FAILURE THE WIRE BURNED COMPLETELY IN TO AND THE PUMP STOPPED SUDDENLY. THE PRESENT FAILURE BEGAN INTERMITTENTLY AND THEN FAILED PERMANENTLY. IT INITIALLY FAILED IN HEAVY TRAFFIC ON THE FREEWAY.*AK
AMOUNT OF MILEAGE PER GALLON IS 12 GALLONS WHEN IT SHOULD BE 17 GALLONS. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
CONSUMER WAS GETTING INTO VEHICLE AND STARTED SMELLING FUEL IN PASSENGER'S COMPARTMENT. CONSUMER WENT STRAIGHT TO A MECHANIC. FUEL HAS SPILLED ONTO ENGINE, BUT NOT ENOUGH TO START SMOKING AND CATCH A FIRE. MANUFACTURE IS DOING NOTHING ABOUT SMELL OR PROBLEM. *AK
WHILE DRIVING 40-45 MPH ENGINE STALLED. VEHICLE TOWED TO DEALER, WHO FOUND A FUES HAD BLOWN, CAUSING FUEL PUMP TO QUIT, THERE WERE BURNED WIRES LEADING TO FUEL PUMP. DEALER REPLACED FUEL PUMP.*AK
VEHICLE STALLED ON THREE OCCASIONS. VEHICLE TAKEN TO THE DEALER, AND INFORMED CONSUMER THAT STALLING WAS DUE TO A SHORT IN FUEL PUMP. PUMP WOULD BE REPLACED WITH A HEAVIER WIRING HARNESS. *AK THE WIRES WERE FUSED TOGETHER IN GAS TANK AND THERE IS POSSIBLE FIRE HAZARD AS THE RESULT. *YH
Official recalls
204V110000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 4, 2004
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
98V115000 · Air Bags
May 26, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INADVERTENT DEPLOYMENT OF THE AIR BAGS CAN OCCUR DUE TO WATER INTRUSION.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL CLEAN THE EXTERIOR CASE OF THE SENSING AND DIAGNOSTIC MODULE (SDM) AND APPPLY A POTTING COMPOUND TO THE SDM CASE AND ELECTRICAL CONNECTOR BODY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE98005 · Erratic Turn Signal Operation
Opened Feb 6, 1998 · Closed Aug 27, 1998
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
SQ97017 · Inadvertent Air Bag Deployment
Opened Jul 2, 1997 · Closed Feb 24, 1998
Status: closed (inferred from source dates) · Air Bags
IF A 1995 CADILLAC INTERIOR IS EXPOSED TO SIGNIFICANT WATER INTRUSION, SUCH AS FROM WATER LEAKS, A WINDOW LEFT OPEN IN THE RAIN, OR DRIVING THROUGH HIGH WATER UP TO THE CARPET LEVEL, THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) SYSTEM SENSING AND DIAGNOSTIC MODULE (SDM) CAN BE DAMAGED.IF THIS OCCURS, BOTH THE DRIVER AND PASSENGER AIR BAGS CAN DEPLOY WHEN THE IGNITION SWITCH IS TURNED ON, EVEN IF THERE HAS BEEN NO FRONTAL IMPACT OR CRASH.AS A RESULT OF THESE DEPLOYMENTS, GM CONDUCTED AN ADVISORY LETTER CAMPAIGN, NUMBER 51-01-08 ENTITLED INADVERTENT DEPLOYMENT OF AIR BAGS WHEN INTERIOR EXPOSED TO WET CONDITIONS, IN FEBRUARY 1996.LETTERS TO OWNERS MAILED PURSUANT TO THIS COMPAIGN WARNED OWNERS TO NOT START THEIR ENGINES IF THE VEHICLE INTERIOR HAD BEEN EXPOSED TO SUBSTANTIAL AMOUNTS OF WATER.ODI HAS RECEIVED A TOTAL 8 REPORTS OF INADVERTENT AIR BAG DEPLOYMENT IN 1995 CADILLAC VEHICLES.
EA95025 · Dash Trim Separation
Opened Aug 31, 1995 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Unknown Or Other
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.