NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
64 reportsClear category filter85,000 miles · Aug 10, 2015
Air Bags
IN DECEMBER OF 2010 THERE WAS A RECALL FOR THE PASSENGER SIDE AIR BAG SENSOR. THAT RECALL WAS COMPLETED ON JULY 7, 2011. I BOUGHT THIS USED CAR WITH VERY LOW MILEAGE ON JUNE 15, 2013. ON AUGUST 7, 2015 THE AIR BAG SENSOR WENT OUT. THE DEALERSHIP SAID THAT SINCE THE RECALL HAD ALREADY BEEN DONE THEY WOULD NOT DO IT FOR FREE A…
Read full complaint
IN DECEMBER OF 2010 THERE WAS A RECALL FOR THE PASSENGER SIDE AIR BAG SENSOR. THAT RECALL WAS COMPLETED ON JULY 7, 2011. I BOUGHT THIS USED CAR WITH VERY LOW MILEAGE ON JUNE 15, 2013. ON AUGUST 7, 2015 THE AIR BAG SENSOR WENT OUT. THE DEALERSHIP SAID THAT SINCE THE RECALL HAD ALREADY BEEN DONE THEY WOULD NOT DO IT FOR FREE A SECOND TIME. IT SOUNDS TO ME LIKE THE RECALL WAS REPLACED WITH A FAULTY PART AS WELL. I AM VERY DISAPPOINTED WITH THIS CADILLAC AND WILL NEVER BUY ANOTHER ONE. I HAVE HAD NOTHING BUT PROBLEMS SINCE I DROVE IT OFF THE LOT.
NHTSA ODI #10747538
82,300 miles · Aug 7, 2015
Air Bags
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE SERVICE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE AIR BAG SENSOR FAILED AND N…
Read full complaint
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED THAT WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE SERVICE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE AIR BAG SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V644000 (AIR BAGS). THE FAILURE MILEAGE WAS APPROXIMATELY 82,300. MA 10/19/15 THE CONSUMER STATED THE VEHICLE WAS REPAIRED AT THE NEAREST CADILLAC DEALER. THE REPAIR WAS PAID FOR IN FULL BY THE OWNER. THE MANUFACTURER DID NOT OFFER ANY ASSISTANCE. THE CONSUMER WAS ADVISED THAT IT WAS A POSSIBILITY FOR THE PROBLEM TO RECUR. THE CONSUMER STATED THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIR COST. UPDATED 3/21/16*JS *CN
NHTSA ODI #10746907
99,000 miles · Jul 24, 2015
Air BagsElectrical SystemEngine
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. WHILE DRIVING AT 60 MPH, THE KEY CAME OUT THE IGNITION. THE DEALER PERFORMED A REPAIR, BUT IT DID NOT RESOLVE THE ISSUE WITH THE IGNITION AND THE AIR BAG WARNING LIGHT BEGAN ILLUMINATING SINCE THE REPAIR. THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT M…
Read full complaint
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. WHILE DRIVING AT 60 MPH, THE KEY CAME OUT THE IGNITION. THE DEALER PERFORMED A REPAIR, BUT IT DID NOT RESOLVE THE ISSUE WITH THE IGNITION AND THE AIR BAG WARNING LIGHT BEGAN ILLUMINATING SINCE THE REPAIR. THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,000.
NHTSA ODI #10743400
38,000 miles · Jul 9, 2015
Air Bags
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. WHILE STARTING THE VEHICLE, THE FRONT PASSENGER SIDE AIR BAG OFF INDICATOR ILLUMINATED CONTINUOUSLY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V644000 (AIR BAGS). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.
NHTSA ODI #10732853
42,000 miles · Dec 19, 2014
Air BagsService BrakesSteeringCrashInjury
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED THAT WHILE MAKING A RIGHT TURN AT APPROXIMATELY 25 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. AS A RESULT, THE CONTACT CRASHED THE VEHICLE INTO A LIGHT …
Read full complaint
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED THAT WHILE MAKING A RIGHT TURN AT APPROXIMATELY 25 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. AS A RESULT, THE CONTACT CRASHED THE VEHICLE INTO A LIGHT POLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A SHOULDER AND NECK INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V394000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 42,000.
NHTSA ODI #10667223
86,000 miles · Oct 7, 2014
Air Bags
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED WHEN TURNING THE IGNITION SWITCH TO THE ON POSITION, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE PROBLEM HAS OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN DIAGNOSED THAT THE SRI PPS MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED WHEN TURNING THE IGNITION SWITCH TO THE ON POSITION, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE PROBLEM HAS OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN DIAGNOSED THAT THE SRI PPS MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE WAS 86,000.
NHTSA ODI #10641936
132,000 miles · Sep 18, 2014
Air BagsElectrical SystemService BrakesCrash
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. WHILE DRIVING 30 MPH, THE VEHICLE DECELERATED AND STALLED. THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO TURN. THE BRAKES ALSO BECAME DIFFICULT TO ENGAGE. DUE TO THE FAILURES, THE CONTACT CRASHED THE VEHICLE INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO…
Read full complaint
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. WHILE DRIVING 30 MPH, THE VEHICLE DECELERATED AND STALLED. THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO TURN. THE BRAKES ALSO BECAME DIFFICULT TO ENGAGE. DUE TO THE FAILURES, THE CONTACT CRASHED THE VEHICLE INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. AFTER THE CRASH, THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V394000 (IGNITION SWITCH). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000.
NHTSA ODI #10637290
136,000 miles · Sep 5, 2014
Air BagsCrash
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED THAT WHILE DRIVING T APPROXIMATELY 30 MPH, THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY.IN ADDITION, THE CONTACT MENTIONED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. …
Read full complaint
TL* THE CONTACT OWNS A 2007 CADILLAC CTS. THE CONTACT STATED THAT WHILE DRIVING T APPROXIMATELY 30 MPH, THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY.IN ADDITION, THE CONTACT MENTIONED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE AIR BAG SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V644000 (AIR BAGS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.
NHTSA ODI #10631144
80,000 miles · Jun 5, 2014
Air BagsEngine
OUR CAR IS EXPERIENCING AN ISSUE WITH THE PASSENGER SIDE AIRBAG, WHICH MATCHES EXACTLY THE DESCRIPTION AND SYMPTOMS IN NHTSA CAMPAIGN ID 10V644000 AND GM SAFETY RECALL 100355. THE GM DEALERS KEEP SAYING OUR VIN DOESN'T MATCH THE PLANT WHERE THE CARS WITH THE PROBLEM AIRBAGS WERE MANUFACTURED AND WILL NOT REPLACE AS STATED IN TH…
Read full complaint
OUR CAR IS EXPERIENCING AN ISSUE WITH THE PASSENGER SIDE AIRBAG, WHICH MATCHES EXACTLY THE DESCRIPTION AND SYMPTOMS IN NHTSA CAMPAIGN ID 10V644000 AND GM SAFETY RECALL 100355. THE GM DEALERS KEEP SAYING OUR VIN DOESN'T MATCH THE PLANT WHERE THE CARS WITH THE PROBLEM AIRBAGS WERE MANUFACTURED AND WILL NOT REPLACE AS STATED IN THE RECALL, BUT OUR CAR HAS THE EXACT ISSUE AS SHOWN IN THE RECALL.------------------------------------------------------------------------------------------------------------------------------------ GM SUBJECT 10287 CONCERNING TIMING CHAIN ISSUE. GM PUT A BAND AID FIX ON THIS AND GAVE A SPECIAL WARRANTY TO 120,000 TO REPAIR ANY ISSUES WITH TIMING CHAIN UNTIL 120,000 MILES. OUR TIMING CHAIN WENT OUT AT 121,000 AND I FEEL GM SHOULD HONOR THE SPECIAL WARRANTY. TIMING CHAIN ISSUE WAS NOT EXPLAINED TO US WHEN THE BAND AID FIX WAS APPLIED AND TIMING CHAIN ISSUE STARTED BEFORE 120,000 MILES. *TR
NHTSA ODI #10596326
64,150 miles · May 29, 2014
Air Bags
SERVICE AIR BAG LIGHT COMES ON. *TR
NHTSA ODI #10594923
Official recalls
6Sep 9, 2014
General Motors LLC (GM) is recalling certain model year 2004-2007 Cadillac CTS-V vehicles manufactured October 6, 2003, to March 15, 2007, and 2006-2007 Cadillac STS-V vehicles manufactured June 23, 2005, to March 15, 2007. In the affected vehicles, the electrical terminals of the fuel pump module may overheat resulting in the melting of the flange material.
Consequence & remedy
Consequence: If the flange melts, a hole may be created allowing the fuel pump to leak fuel, causing the vehicle to stall, increasing the risk of a vehicle crash. Additionally, leaking fuel in the presence of an ignition source increases the risk of a fire.
Remedy: GM will notify owners, and dealers will replace the fuel module and fuel tank jumper harness, free of charge. GM sent out interim notices in late October. The recall began on March 12, 2015. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14405.
Jul 2, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 2, 2014 that they are recalling 554,328 model year 2003-2014 Cadillac CTS vehicles manufactured August 16, 2001, to April 28, 2014, and 2004-2006 Cadillac SRX vehicles manufactured March 20, 2003, to August 11, 2006. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 15, 2014. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14172.
Dec 17, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2007 CADILLAC CTS VEHICLES. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH REPEATED FLEXING OF THE PASSENGER SENSING SYSTEM MAT IN THE FRONT PASSENGER SEAT MAY CAUSE THE MAT TO KINK, BEND, OR FOLD. THIS FLEXING CAN BREAK THE CONNECTIONS IN THE MAT. IF THIS OCCURS, THE SENSOR MAY NOT DETECT THE PRESENCE OF A FRONT SEAT PASSENGER AND WILL DISABLE THE AIR BAG.
Consequence & remedy
Consequence: NON-DEPLOYMENT OF THE FRONT PASSENGER AIR BAG IN THE EVENT OF A CRASH NECESSITATING THAT AIR BAG'S DEPLOYMENT MAY REDUCE PROTECTION OF THE PASSENGER AND INCREASE THE RISK OR SEVERITY OF INJURY TO THEM.
Remedy: DEALERS WILL REPLACE THE PASSENGER SENSING SYSTEM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 15, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Mar 17, 2010
GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2003-2007 CADILLAC CTS VEHICLES CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON D.C., WEST VIRGINIA AND WISCONSIN. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE FRONT BRAKE HOSE FITTING AT THE CALIPER MAY CORRODE DUE TO SNOW OR WATER, CONTAINING ROAD SALT OR OTHER CONTAMINANTS, ENTERING AND BEING RETAINED IN THE ROUTING SLEEVE. IF THE FITTING CORRODES SIGNIFICANTLY, THE BRAKE HOSE-TUBE INTERFACE MAY DEVELOP A LEAK.
Consequence & remedy
Consequence: THE BRAKE HOSE-TUBE INTERFACE MAY RUPTURE SUDDENLY WITHOUT PRIOR WARNING AND INCREASE VEHICLE STOPPING DISTANCE MAY OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS ARE TO REPLACE BOTH FRONT BRAKE HOSE ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Dec 20, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
Oct 4, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, 'POWER OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS.' UNDER THE STANDARD, THE SUNROOF MAY ONLY BE CLOSED WHEN THE IGNITION IS ON, OR AFTER THE IGNITION IS TURNED OFF, BUT BEFORE EITHER OF THE FRONT DOORS ARE OPENED. THE AFFECTED VEHICLES MAY EXHIBIT A CONDITION WHERE THE SUNROOF CAN BE CLOSED AFTER THE IGNITION IS TURNED OFF AND THE DOORS ARE OPENED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES REQUIREMENTS FOR POWER OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS TO MINIMIZE THE LIKELIHOOD OF DEATH OR INJURY FROM THEIR ACCIDENTAL OPERATION.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS. THE RECALL BEGAN ON MAY 29, 2008. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EQ11001 · Iee Passenger Sensing System Mats
Opened Feb 7, 2011 · Closed Jul 19, 2011
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
On December 17, 2010, General Motors (GM) notified the NHTSA that it had decided certain 2005 - 2007 model year Cadillac CTS vehicles contain a safety related defect.GM stated that certain CTS vehicles contain a passenger sensing system mat, manufactured by IEE, in the front passenger seat that may flex causing the mat to kink, bend or fold.If this flexing causes the connections in the mat to break, the passenger airbag could become disabled.Non-deployment of the front passenger air bag in the event of a crash necessitating that air bag's deployment may reduce protection of the passenger and increase the risk or severity of injury to them.This issue was assigned recall number 10V-644.On February 8, 2011, RMD mailed an information request (IR) letter to IEE requesting a list of purchasers for any company that was sold the same or similar defective mats.RMD also requested IEE supply the year, make and models of compatible vehicles for each of the mats it listed in its response.IEE responded on February 15, 2011, reporting that the mats recalled in GM recall 10V-644 were developed specifically for the 2005-2007 Cadillac CTS.IEE noted that, ...the CTS Sensor Mat is not the same or similar to any other sensor mat manufactured by IEE.IEE further explained that the sensor mats were sold to Lear Corp. (Lear), for incorporation into seat assemblies, with the seat assemblies finally being sold to GM.Also, some sensor mats were sold to Integrated Manufacturing and Assembly, LLC (IMA) who would then re-sell the mats to GM to use as service parts.Ultimately, these parts were all sold to GM for use in the 2005-2007 Cadillac CTS vehicles.According to its 10V-644 Defect Report, GM reported that some vehicles outside the recall population have ...significantly lower incident rates and will be provided a special coverage.This special coverage includes a free repair should the same issue occur to non-recalled 2005-2007 Cadillac CTS vehicles up to 10 years or 120,000 miles.On April 7, 2011, RMD mailed an IR letter to GM to gather more information on GM's decision to only recall a portion of the vehicles that contained the subject IEE mats.RMD also requested that GM provide updated to current warranty claims, field reports, and other field information for CTS vehicles both recalled and those under the special coverage.On May 19, 2011, GM responded with a letter and several CD attachments that were submitted to NHTSA's Office of the Chief Counsel along with a request for confidentiality.GM confirmed that the IEE mats recalled in 10V-644 were only used in the 2005-2007 Cadillac CTS.GM also explained its reasoning in only recalling a portion of the CTS vehicles containing IEE mats.Due to various production phases, error detections, and false corrections, certain vehicles were more prone to mat failures than other vehicles.GM identified 4 distinct seat assembly production periods and chose to recall CTS vehicles depending on which seat assembly each vehicle received.Examining the data submitted in regards to warranty claims, field reports, and incidents, the CTS vehicles that were included in the safety recall were responsible for about 80% of the overall claims.CTS vehicles included in the special coverage (essentially an extended warranty), those with seat assemblies from other identified production phases, were responsible for about 20% of the overall claims.As GM has provided clear data to support its recall decision and since no other manufacturer has installed these same or similar passenger sensing system mats / seat assemblies in their vehicles, this Equipment Query is satisfied.This EQ is cl
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
Illustration