2004 Cadillac Cts

14V542000 · Fuel System, Gasoline:delivery:fuel Pump

Sep 9, 2014

General Motors LLC (GM) is recalling certain model year 2004-2007 Cadillac CTS-V vehicles manufactured October 6, 2003, to March 15, 2007, and 2006-2007 Cadillac STS-V vehicles manufactured June 23, 2005, to March 15, 2007. In the affected vehicles, the electrical terminals of the fuel pump module may overheat resulting in the melting of the flange material.

14V394000 · Electrical System:ignition

Jul 2, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 2, 2014 that they are recalling 554,328 model year 2003-2014 Cadillac CTS vehicles manufactured August 16, 2001, to April 28, 2014, and 2004-2006 Cadillac SRX vehicles manufactured March 20, 2003, to August 11, 2006. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

10V105000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Mar 17, 2010

GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2003-2007 CADILLAC CTS VEHICLES CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON D.C., WEST VIRGINIA AND WISCONSIN. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE FRONT BRAKE HOSE FITTING AT THE CALIPER MAY CORRODE DUE TO SNOW OR WATER, CONTAINING ROAD SALT OR OTHER CONTAMINANTS, ENTERING AND BEING RETAINED IN THE ROUTING SLEEVE. IF THE FITTING CORRODES SIGNIFICANTLY, THE BRAKE HOSE-TUBE INTERFACE MAY DEVELOP A LEAK.

05V024000 · Air Bags

Jan 20, 2005

ON CERTAIN PASSENGER VEHICLES, AN INTERACTION BETWEEN THE SENSING AND DIAGNOSTIC MODULE AND VEHICLE'S ELECTRICAL SYSTEM MAY CAUSE THE DRIVER'S FRONTAL AIR BAG AND/OR ROOF-MOUNTED SIDE IMPACT AIR BAG TO DEPLOY WHEN THE IGNITION KEY IS TURNED TO THE "ON" POSITION.

04V273000 · Steering:linkages

Jun 9, 2004

ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.

03V346000 · Seats

Sep 29, 2003

CERTAIN PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." ONE OR BOTH FRONT ANCHOR TABS FOR THE FRONT BUCKET SEATS ARE NOT ENGAGED IN THE FLOOR PAN REINFORCEMENT SLOTS. A SEAT WITH ONLY ONE TAB ENGAGED OR NEITHER ENGAGED WOULD NOT MEET THE STATIC REARWARD LOADING TEST REQUIREMENTS OF THE STANDARD.

EA07017 · Rear Drivetrain Component Failure

Opened Dec 7, 2007 · Closed Jul 16, 2008

Status: closed (inferred from source dates) · Power Train:driveline:differential Unit

IN JULY OF 2007 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE07-037 TO INVESTIGATE ALLEGATIONS THAT THE REAR DIFFERENTIAL MAY FAIL CAUSING A LOSS OF MOTIVE POWER, AND IN SOME INSTANCES A LOSS OF CONTROL, IN MODEL YEAR (MY) 2004 THROUGH 2006 CADILLAC CTS, CTS-V, AND STS VEHICLES.AS A RESULT OF THAT INVESTIGATION GM ISSUED RECALL 07V-589 TO CORRECT A LEAKING PINION SEAL PROBLEM.EA07-017 WAS OPENED TO INVESTIGATE COMPLAINTS OF FRACTURED REAR DIFFERENTIAL HOUSINGS OR REAR HALF SHAFTS IN HIGH PERFORMANCE CADILLAC CTS-V VEHICLES.ACCORDING TO GM, THESE FAILURES RESULTED FROM THE CUMULATIVE DAMAGE FROM MULTIPLE POWER HOP EVENTS THAT CAN OCCUR DURING VERY AGGRESSIVE DRIVING. IN FEBRUARY 2008 INVESTIGATORS FROM ODI MET WITH GM REPRESENTATIVES TO CONDUCT TESTING OF THE SUBJECT CTS-V VEHICLES.DURING THE TESTING THE SUBJECT VEHICLES WERE SUBJECTED TO CONSIDERABLE TORSIONAL FORCES FROM STANDING STARTS AND WHILE DRIVING.POWER HOP OCCURRED DURING SOME OF THE MOST AGGRESSIVE DRIVING MANEUVERS.THE TESTING DID NOT RESULT IN FAILURE OF ANY REAR DRIVETRAIN COMPONENTS.THE ENGINEERING DESIGN AND TESTING DATA SUPPLIED TO ODI BY GM AND THE RESULTS OF THE TESTING CONDUCTED BY ODI TEND TO SUPPORT GM'S POSITION THAT THE DIFFERENTIAL DESIGN IS NOT DEFECTIVE. COMPLAINTS LISTED IN THE FAILURE REPORT DO NOT INCLUDE THOSE INDICATIVE OF FAILURE OF THE REAR PINION SEAL IN CTS-V VEHICLES COVERED BY RECALL 07V-589. FURTHER INVESTIGATION IN THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

PE07037 · Failure Of The Rear Differential

Opened Jul 17, 2007 · Closed Dec 27, 2007

Status: closed (inferred from source dates) · Power Train:driveline:differential Unit

ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.