IllustrationTHE HORN REQUIRED EXCESSIVE PRESSURE TO ACTIVATE. THE DEALER STATED THE PROBLEM WAS DUE TO THE AIR BAG PLACEMENT. MR SCC *JB
2002 Buick Lesabre
Owner reports · Recalls · Investigations
More warning signs than most Lesabre years
Owner complaints for the 2002 Buick Lesabre are substantially higher than the model-year median of 24.
About this comparison →How this year compares
Owner complaints by model year
Compare all Lesabre years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
410–25K
4825–50K
4650–75K
3675–100K
31100–150K
18150K+
220 reports with mileage · 90 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports12 fire reports15 injury reports
What owners actually said
310 reportsTHE ANTI LOCK BRAKE LIGHT ILLUMINATED, AND THE BRAKES FAILED, WHICH CAUSED THE CONSUMER TO DRIVE INTO A DITCH. THE DEALER STATED THE BRAKES HAD FROZE, DUE TO ICE BUILD UP. *TS *JB
AIR BAG LIGHT ILLUMINATED WHEN HORN WAS USED. DEALER REPAIRED THE VEHICLE FOUR TIMES, A FUSE WAS REPLACED AND THE WIRING OF THE POWER SEAT WAS WRAPPED AROUND THE HORN. *JB...*AK
FAX FROM JAMES L. BURNS (MI) REGARDING DEFECTIVE ANTI-LOCK BRAKES ON HIS 2002, BUICK, LESABRE, REPLY DIRECLY TO CONSTITUENT & FWD COPY TO TOM BALDINI OF CONG. STUPAK'S OFC. MR BALDINI IS WRITER OF CONG LETTER. *JB *NLM....*AK
A THIN COAT OF ICE COVERED THE BRAKE PADS AND ROTORS WHICH CAUSED THE ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT TO ILLUMINATE AND THE BRAKES TO FAIL. *TT *JB
THE SUNVISORS DID NOT FOLD FAR ENOUGH TO SEE STOP LIGHTS.*AK *JB
CONSUMER WAS UNABLE TO SEE OUT OF THE FRONT WINDSHIELD, A REFLECTION FROM THE WINDSHIELD CAUSED A GLOW. *JB
THE HEAD LIGHTS FAILED.*JB
VEHICLE STALLED WHILE DRIVING THROUGH THE "HILLS" RESULTING IN CONSUMER BEING STRANDED. THE VEHICLE HAS BEEN STALLING INTERMITTENTLY FOR OVER A YEAR DUE TO BATTERY GROUND CABLE BEING LOOSELY ATTACHED TO VEHICLE'S FRAME. AS A RESULT, CABLE WOULD COME UNATTACHED, CAUSING CAR TO STALL. BATTERY WAS INSTALLED UNDER VEHICLE'S REAR …
Read full complaint
VEHICLE STALLED WHILE DRIVING THROUGH THE "HILLS" RESULTING IN CONSUMER BEING STRANDED. THE VEHICLE HAS BEEN STALLING INTERMITTENTLY FOR OVER A YEAR DUE TO BATTERY GROUND CABLE BEING LOOSELY ATTACHED TO VEHICLE'S FRAME. AS A RESULT, CABLE WOULD COME UNATTACHED, CAUSING CAR TO STALL. BATTERY WAS INSTALLED UNDER VEHICLE'S REAR SEAT. TS.....*AK THE CONSUMER REQUESTED REIMBURSEMENT. *SCC
THE TRUNK LID COLLAPSED ON TWO OCCASIONS WHILE ON AN INCLINE, AND CAUSED INJURY TO THE CONSUMER AND HIS WIFE. *SCC *JB
Official recalls
202V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
02V067000 · Steering:gear Box (other Than Rack And Pinion)
Mar 6, 2002
CERTAIN PASSENGER VEHICLES WERE BUILT WITH MISSING OR UNDER-TORQUED STEERING GEAR ATTACHMENT BOLTS. IF A BOLT IS MISSING, THE DRIVER MAY NOTICE UNEVEN STEERING RESPONSE OR UNUSUAL NOISES DURING TURNS.
Consequence & remedy
Consequence: IF THE LEFT BOLT IS MISSING AND THE RIGHT MOUNTING STRAP FAILS, STEERING CONTROL IS LOST AND A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR PRESENCE AND PROPER TORQUE OF BOTH STEERING GEAR BOLTS. OWNER NOTIFICATION BEGAN APRIL 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300 OR CADILLAC AT 1-800-458-8006.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.