Engine And Engine CoolingFuel System, GasolineSeats
FUEL TANK AND SENDING LINES NEED TO BE REPLACED DUE TO O-RINGS IMPROPERLY FITTED ON FUEL PUMP. IN JULY 2000, VEHICLE WAS MAKING A KNOCKING NOISE WHEN TURNING OR GOING OVER A BUMP. FRONT/REAR TRANSMISSION MOUNTS WERE DEFECTIVE COMPONENTS. DEALERSHIP PUT A SEALER ON THIS, BUT IT FAILED TO CORRECT DEFECT. *AK THE DEALER …
Read full complaint
FUEL TANK AND SENDING LINES NEED TO BE REPLACED DUE TO O-RINGS IMPROPERLY FITTED ON FUEL PUMP. IN JULY 2000, VEHICLE WAS MAKING A KNOCKING NOISE WHEN TURNING OR GOING OVER A BUMP. FRONT/REAR TRANSMISSION MOUNTS WERE DEFECTIVE COMPONENTS. DEALERSHIP PUT A SEALER ON THIS, BUT IT FAILED TO CORRECT DEFECT. *AK THE DEALER HAD REPLACED MOTOR, TRANSMISSION MOUNTS, POWER STEERING LINES, GASKET TO CATALYTIC CONVERTOR AND SWITCH FOR HEATED SEAT. *YH
NHTSA ODI #885524
Mileage unknown · Jun 29, 2000
Structure
THERE WAS A LEAK COMING FROM THE DASHBOARD. AS A RESULT OF HEAVY RAIN DASHBOARD WIRES/FLOORBOARD WERE WET. *AK
NHTSA ODI #864521
Mileage unknown · Feb 16, 2000
Structure
THE CUP HOLDERS ARE TOO SMALL TO HOLD A CUP OR SODA CAN. THEY ARE OF TWO DIFFERENT SIZES. WHEN A STOP IS MADE THEY HAVE A TENDENCY TO SPILL AND WHEN A PERSON REACHES TO GRAB THEM AN ACCIDENT CAN OCCUR.THE FACTORY SAYS THAT IS DESIGN, AND NOTHING CAN BE DONE ABOUT IT.I ASKED FOR A RECALL OR A REPLACEMENT AND WAS TURNED DOWN. MINE…
Read full complaint
THE CUP HOLDERS ARE TOO SMALL TO HOLD A CUP OR SODA CAN. THEY ARE OF TWO DIFFERENT SIZES. WHEN A STOP IS MADE THEY HAVE A TENDENCY TO SPILL AND WHEN A PERSON REACHES TO GRAB THEM AN ACCIDENT CAN OCCUR.THE FACTORY SAYS THAT IS DESIGN, AND NOTHING CAN BE DONE ABOUT IT.I ASKED FOR A RECALL OR A REPLACEMENT AND WAS TURNED DOWN. MINE SPILLED AND POURED HOT COFFEE ALL OVER THE FLOOR. I WOULD APPRECIATE A REPLY AS TO WHAT CAN BE DONE ABOUT THIS SITUATION. *AK
NHTSA ODI #718826
Mileage unknown · Jan 20, 2000
Structure
IF A PERSON WERE STANDED IN THE CAR DURING A WYO BLIZZARD THE HEATER WOULD NOT BE ABLE TO KEEP YOU FROM FREEZING. THE CAR HAS BEEN RETURNED TO THE DEALERS SIX OR MORE TIMES AND THE PROBLEM CAN'T BE REMEDIED.
NHTSA ODI #717599
Mileage unknown · Dec 4, 1999
Structure
TRUNK LID FLEW UP UPON OPENING AND CAME BACK DOWN ON MY HEAD AND MY WIFE'S ON TWO DIFFERENT OCCASIONS.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES HAVE INTERNAL FLUID LEAKS IN THE BRAKE HYDRAULIC CONTROL UNIT.
Consequence & remedy
Consequence: WHEN THE REAR BRAKE PROPORTIONING, ANTILOCK BRAKE, TRACTION CONTROL, OR STABILITY CONTROL FEATURE IS ACTIVATED IN SOME DRIVING SITUATIONS, THE FEATURE MAY NOT PERFORM AS DESIGNED.
Remedy: DEALERS WILL INSPECT THE ABS HYDRAULIC MODULATOR UNIT AND IF NECESSARY, REPLACE THE HYDRAULIC MODULATOR.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE HEAD LAMP ADJUSTMENT DEVICE HORIZONTAL ADJUSTER MAY NOT MOVE THE HEAD LAMP REFLECTOR WHEN THE SHAFT IS ROTATED IN A NORMAL MANNER DURING AIMING.
Consequence & remedy
Consequence: DRIVER VISIBILITY MAY BE IMPAIRED INCREASING THE RISK OF A CRASH.
Remedy: AN INSERT CONTAINING INSTRUCTIONS FOR OPTICALLY AIMING THE HEADLAMPS WILL BE PROVIDED TO OWNERS FOR THE OWNER'S MANUAL. OWNERS SHOULD FOLLOW THE PROCEDURE IN THE INSERT FOR HEADLAMP AIM ADJUSTMENT, RATHER THAN USING THE HORIZONTAL VHAD INDICATOR.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE BOOSTER TO PEDAL ASSEMBLY ATTACHMENT NUTS MAY BE LOOSE.
Consequence & remedy
Consequence: IF THESE NUTS ARE LOOSE, THE BRAKE PEDAL MAY BE LOW, THE ASSEMBLY MAY BE LOOSE, THE BRAKES MAY NOT RELEASE, AND IF THE NUTS BACK COMPLETELY OFF, BRAKING MAY BE LOST. ALSO FUME AND WATER INTRUSION TO THE PASSENGER COMPARTMENT CAN OCCUR.
Remedy: DEALERS WILL REPLACE ANY MISSING BRAKE BOOSTER TO BRAKE PEDAL ASSEMBLY NUTS AND TIGHTEN ALL FOUR (4) NUTS TO SPECIFIED TORQUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
2000 Buick Lesabre Problems, Complaints & Recalls | Skip That Year
Illustration