2020 Buick Enclave

My car starting making a loud noise upon start up and continued while driving, sounded like a GoCart exhaust system and was not normal. It just sounded loud and would get louder when accelerated until the car ran for awhile. I first noticed it at about 83,500 miles. I took to the dealer for checkup at 83,950 miles when I could get an appointment. The dealer (Elco Chevrolet) confirmed the problem upon hearing and looking under the car, there is a bracket broken on the exhaust system and the catalytic converter has a hole/crack in the molding. Our safety is at risk if the exhaust with the crack would create fumes harmful when driving the car and risk of injury if the exhaust would fall off upon driving due to bracket broke. There were no warning lamps or messages from the car. I am submitting this problem as upon discussion with the dealer and investigation online about this, appears that this is a problem with GM vehicles with this make and model, Enclave and Travers, however, my year was not flagged for a recall already established. When I tried to investigate with GM they stated it was because my car was not identified likely due to parts or timing. I am asking to further investigate as there may be a problem with the design of this exhaust system that caused this issue early in the mileage of this car. Asking for further investigation into the make and model of this year for the year 2020.

Front exhaust pipe separated from its mounting bracket causing a consistent rattle. This condition is exactly as described in "N222385510 - Special Coverage Front Exhaust Pipe", released in May 2023. Exhaust components in this vehicle are materially the same as the covered 2021 vehicles and thus this vehicle should be similarly covered. Issue has been confirmed by a dealer and is available for further inspection.

I am submitting this complaint regarding a paint defect on my 2020 Buick Enclave. The passenger-side rear door has significant top-coat peeling and flaking, exposing the primer and metal underneath. This deterioration is not normal wear for a six-year-old vehicle that has been properly maintained and protected from environmental conditions. The pattern of peeling indicates a failure of the top coat or clear coat applied during manufacturing. The paint layers are separating prematurely, reducing corrosion protection and long-term durability. Exposed metal increases the risk of rust, structural weakening, and potential failure of the door panel, which may affect occupant safety in the event of a collision. I am aware that similar paint adhesion failures have been reported across multiple General Motors vehicles, and class-action lawsuits are currently pending alleging defective basecoat and clearcoat systems that cause premature peeling, bubbling, and flaking. The number of complaints suggests a broader manufacturing issue rather than isolated consumer misuse. Although my vehicle’s limited warranty has expired, the defect is clearly premature and manufacturing-related. A properly applied top coat should not fail this early, especially on a vehicle that has been routinely washed, waxed, and stored in normal conditions. I respectfully request that NHTSA review this issue and consider opening an investigation into paint top-coat failures on Buick and other GM vehicles. Premature paint failure affects corrosion resistance, vehicle longevity, and consumer value, and may compromise the safety of occupants and other drivers if corrosion spreads or structural integrity is reduced. I am willing to provide photographs, documentation, and maintenance records to support this complaint. Thank you for your attention to this matter and for your commitment to consumer safety and manufacturing accountability.

The contact owns a 2020 Buick Enclave. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle lost motive power and was coasted to the shoulder of the roadway. No warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was in the process of being repaired. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 45,684.

I am submitting a complaint regarding premature exhaust system failure on my 2020 Buick Enclave involving the front exhaust pipe/exhaust manifold/catalytic converter assembly. The issue appears very similar to the conditions described in GM Special Coverage programs N212356540 and N242445280 involving exhaust pipe and bracket failures on related GM crossover platforms. The mounting brackets/support brackets on the front exhaust pipe appear to fail or separate, which places excessive stress on the flex section of the exhaust system. This movement and stress can cause the flex pipe/manifold area to crack and may ultimately damage the catalytic converter assembly itself. My vehicle developed: Exhaust leak Loud ticking/exhaust noise Rich/lean oxygen sensor fault conditions Exhaust fumes entering or potentially entering the cabin Passenger dizziness while riding in the vehicle Concern for carbon monoxide exposure The repair facility documented that the exhaust leak should be repaired as soon as possible because exhaust fumes may enter the vehicle cabin. The estimated repair cost is approximately $1,700 for replacement of the integrated catalytic converter/exhaust manifold assembly. This appears to be more than ordinary wear and tear. The failure pattern is consistent with bracket/support failure causing abnormal stress and cracking in the exhaust system upstream near emissions components. Because these failures can allow exhaust gases and possible carbon monoxide exposure into the passenger compartment, I believe this issue represents a significant safety concern and warrants investigation for 2020 Buick Enclave vehicles and related GM crossover platforms.

Why enclave Burns about 1 to 2 quarts of oil in between oil changes so I'm constantly having to check the oil level and put more oil in it which come really close to being out of oil and causing the engine to seize Buick says this is normal and I don't think it is I have never had a car that uses oil like this new or used in addition to that the transmission is locked up twice since we have owned it and can't get it out of park can't drive it can't use it. Had to have it towed . The first time that the transmission gave issues it didn't lock up in park it locked up in drive and we couldn't put it in park I was able to get it to the dealer to get worked on it was still under warranty at that time the second time it wouldn't go out of park and could not move it it was stuck wherever we happen to be at and it would not move when they loaded it on the tow truck to tow it down to the dealer the wheels were locked up cuz it was in park and we couldn't it had to just be drug onto the truck.