Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
48 miles · Jun 8, 2009
Engine And Engine Cooling
PURCHASE BIKE WOULD NOT STAY RUNNING NEEDED A TUNE UP GOING UP A HILL AFTER GETTING GAS IN 1ST GEAR BIKE STALLS AND WOULD NOT START DRIVING DOWN 695 WENT TO SHIFT DOWN-SHIFTER WAS GONE ...WAS REPLACE NOT LONG AFTER THAT SHIFTER BECAME LOOSE AGAIN..CAUGHT AND FIXED PRIOR TO LOSING HAVE BEEN COMPLAINING SHOP ABOUT PINGI…
Read full complaint
PURCHASE BIKE WOULD NOT STAY RUNNING NEEDED A TUNE UP GOING UP A HILL AFTER GETTING GAS IN 1ST GEAR BIKE STALLS AND WOULD NOT START DRIVING DOWN 695 WENT TO SHIFT DOWN-SHIFTER WAS GONE ...WAS REPLACE NOT LONG AFTER THAT SHIFTER BECAME LOOSE AGAIN..CAUGHT AND FIXED PRIOR TO LOSING HAVE BEEN COMPLAINING SHOP ABOUT PINGING NOISE IN ENGINE AND NOTHING HAS BEEN DONE ABOUT IT. THE BIKE CONTINUES TO GET LOUDER . MOTOR MOUNTS HAVE BEEN REPLACED TWICE SO FAR PER PAPERWORK BOLT WAS WELDED OIL LINKAGE/USAGE MORE THAN NORMAL..NOTHING DONE MANIFOLD COUPLER HAS ALREADY BEEN REPLACED DUE TO BIKE NOT STARTING. *TR
NHTSA ODI #10273093
170 miles · Nov 3, 2008
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2008 BUELL BLAST. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V439000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) AND SCHEDULED AN APPOINTMENT WITH THE DEALER TO HAVE THE VEHICLE REPAIRED. THE CONTACT WAS INFORMED THAT THE PARTS FOR THE REPAIR WOULD BE UNAVAILABLE UNTIL OCTOBER. …
Read full complaint
TL*THE CONTACT OWNS A 2008 BUELL BLAST. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V439000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) AND SCHEDULED AN APPOINTMENT WITH THE DEALER TO HAVE THE VEHICLE REPAIRED. THE CONTACT WAS INFORMED THAT THE PARTS FOR THE REPAIR WOULD BE UNAVAILABLE UNTIL OCTOBER. WHEN OCTOBER ARRIVED, HE CALLED THE DEALER AGAIN FOR AN APPOINTMENT, BUT THE PARTS WERE STILL UNAVAILABLE. HE CALLED THE DEALER BACK IN NOVEMBER AND WAS INFORMED THAT THE PARTS HAD TO BE RE-ORDERED. AS OF NOVEMBER 3, 2008, THE VEHICLE HAS NOT BEEN PROPERLY REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 170. REMAILED 12/08/08. *LJ UPDATED 02/05/09 *BF THE CONSUMER STATED THE VEHICLE HAS BEEN REPAIRED. UPDATED 02/06/09.*JB
BUELL IS RECALLING 1,307 MY 2007-2008 BLAST MOTORCYCLES. THE FUEL TANK MAY EXPERIENCE SOME LOCAL DEFORMATION UNDER HIGH-HEAT CONDITIONS THAT CREATES CONTACT OF THE TANK WITH THE CYLINDER HEAD. IN SOME OF THESE CASES, THE CYLINDER HEAD RUBBING ON THE FUEL TANK HAS CREATED A FUEL LEAK.
Consequence & remedy
Consequence: THIS COULD RESULT IN A CRASH OR FIRE, WHICH COULD CAUSE INJURY OR DEATH TO THE RIDER.
Remedy: DEALERS WILL INSTALL A BRACKET WHICH WILL PREVENT THE FUEL TANK FROM CONTACTING THE CYLINDER HEAD. THE RECALL BEGAN ON SEPTEMBER 11, 2008. OWNERS MAY CONTACT BUELL AT 1-414-343-8400.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 Buell Blast Problems, Complaints & Recalls | Skip That Year
Illustration