2011 BMW Z4

ON 3 APRIL 2026 I WAS DRIVING MY 2011 BMW Z4 SDRIVE 30I E89 N52K (MANUAL TRANSMISSION) THAT HAS 31,000 MILES ON IT, SUDDENLY A STEERING ASSISTANCE MALFUNCTION TROUBLE LIGHT APPEARED AND I LOST ALL ELECTRONIC POWER STEERING. THIS SUDDEN LOSS OF STEERING CONTROL ALMOST CAUSED AN ACCIDENT!! THEN SHORTLY THEREAFTER THE ELECTRONIC POWER STEERING CONTROL RETURNED. ON APRIL 4 I LOST THE STEERING CONTROL AGAIN AND TOOK IT TO A BMW REPAIR SHOP. THEY CONFIRMED THAT THE PROBLEM WAS WITH THE EPS (ELECTRIC POWER STEERING CONTROL). UPON INVESTIGATION, A SPECIFIC RECALL EXISTS FOR 2012 BMW Z4 REGARDING THE ELECTRIC POWER STEERING (EPS) SYSTEM. (NHTSA RECALL CAMPAIGN #12V302000: ELECTRIC POWER STEERING CONTROL MODULE.) THE RECALL CAMPAIGN NOTES THAT, AFTER THE ENGINE IS SHUT OFF AND THEN RESTARTED, THE EPS MODULE MAY FUNCTION PROPERLY. IN THAT CASE, THE WARNING SYMBOL IN THE INSTRUMENT CLUSTER WILL NO LONGER APPEAR, AND THE AUDIBLE WARNING WILL NOT ACTIVATE. HOWEVER THE CONDITION MAY OCCUR AGAIN. THIS IS EXACTLY WHAT IS OCCURRING WITH MY CAR AND YOU NEVER KNOW WHEN IT WILL OCCUR. THE CAMPAIGN COVERS 2012 Z4'S AND COVERED SOME CARS MANUFACTURED IN LATE 2011. HOWEVER, THE VIN FOR MY 2011 BMW Z4 SDRIVE 30I E89 N52K (MANUAL TRANSMISSION) IS WBALM5C58BE162421 AND IT WAS MANUFACTURED IN 04/2010. THE EPS IN MY 2011 BMW Z4 IS EXACTLY THE SAME AS THE EPS THAT IS COVERED IN THE NHTSA RECALL CAMPAIGN #12V302000: ELECTRIC POWER STEERING CONTROL MODULE.) CLEARLY MY 2011 BMW Z4 SHOULD BE INCLUDED IN THIS CAMPAIGN WHICH REQUIRES A 4 HR REPAIR BY A CERTIFIED BMW DEALER AND REPLACEMENT OF THE EPS UNIT. FOR Z4 MODELS THE TECHNICIANS ARE TO REFER TO REPAIR INSTRUCTION 32 13 370, "REMOVING AND INSTALLING (REPLACING) ELECTRIC STEERING BOX (EPS)." E89 STEERING GEAR PART # 32 10 6 855 888. PLUS FOLLOWING PARTS: ASA BOLT (#32 10 6 773 068); HEX NUT (#33 32 6 768 884); TORX BOLT (#32 30 6 778 609); COMBINATION NUT (#33 30 6 787 062). ALL ABOVE REFERENCED PARTS WERE LISTED IN THE RECALL CAMPAIGN. !

Electrical power steering system failed, warning light came on. Vehicle suddenly became very difficult to impossible to steer. Failed to negotiate a turn and nearly hit a tree. I have an appointment set with an independent service dealer near me, but I’m afraid to drive it there, so I may have it towed. The warning light came on just moments before the initial failure.

October, 9, 2024 BMW USA Customer Relations, Recall Services Ms. Ikevia, Thank you following up. My 2021 claim regarding the 2011 BMW Z4 Vanos Bolts recall has been pending since April, 2021. My Z4 almost destroyed itself, after having been left off your recall list. December, 2023 BMW USA provided me written notice my VIN had been added to the recall list so I will be reimbursed for the costly repair. I hope you will help your colleagues who are stonewalling to appreciate my patience as well as my willingness to fight for reimbursement for as long as it takes You do have all my information in your Vanos Bolts Recall file, including detailed photos from my Syncro Car Care professionals who did the repair when you declined to help me. My VIN which is: [XXX] - 2011 Z4 3.0 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have written to you previously to advise of repeated engine issues with my vehicle, a 2011 BMW Z4. I also included invoices of work that was done over time to correct a likely Engineering flaw that caused excessive fuel injector failure. In 2021, there was a 10 year extended warranty to replace them. Prior and after the warranty work, there was almost constant engine misfires and engine warning lights resulting in decreased engine performance, and low oil lights that came on every 300+ miles driven. My recent issue with the car involves a starter quitting while driving at 70mph on [XXX]. It was terrifying. It's impossible to put into words that death was imminent. On [XXX], we were traveling to Orangeburg, SC when the car suddenly "died" on the highway. Once we recovered from our shock, we had the vehicle towed to a local shop. The owner advised us that it needed a new starter. Once that was replaced, the car started with a severe screeching noise. After further assessment, it was determined that there was a bent piston rod and that the engine would have rebuilt or replaced. I, a former automotive Engineer, believe that there was an inherent design flaw that caused the car to excessively use oil. Interestingly, I purchased a new BMW and as a condition of sale, was required to sign a document that I would not sue BMW or participate in a class action lawsuit. I was not provided with a copy of the form that was signed, but doubt that it would be upheld in court. BMW needs to be held accountable for their products and their performance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2011 BMW Z4. The contact stated while driving at 55 MPH, the vehicle stalled. The vehicle was difficult to restart. The check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 30,000. VIN tool confirms parts not available.

The contact owns a 2011 BMW Z4. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while driving at undisclosed speeds, the vehicle was shaking abnormally with an unknown warning light illuminated. The vehicle was taken to the dealer. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 68,000. VIN tool confirms parts not available.

Hello, I am writing to you about repeated repairs that I have incurred for my 2011 BMW Z4, VIN [XXX] . On [XXX] 2017, I had a BMW initiated, no cost recall/extended warranty replacement of 6 fuel injectors performed at Hilton Head BMW in Hilton Head, SC. Due to the nature of the work, it was recommended that the 6 spark plugs be replaced, which were not covered under the recall/extended warranty, and which I paid $187.71 in parts and labor for. Mileage at this time was 45,795. On [XXX], 2019, I once again had the spark plugs and ignition coils replaced at Hilton Head BMW at a cost of $1208.25 for parts and labor. Mileage at this time was 58,815. On [XXX], 2024, I had the ignition coil and spark plugs replaced again by Import Service of the Lowcountry at a cost of $840 for parts and labor. Mileage at this time was 95,977. Relative to this, I also had fuel injector replacement performed on [XXX], 2024, at a cost of $724.29 for parts and labor. Lastly, the valve cover and #2 fuel injector failed and were replaced on [XXX], 2024 at a cost of $1843.14. Mileage at this time was 97,125. I am seeking $4803.59 in reimbursement costs for a repeated field defect that is known to BMW, and for which they have failed to correct through recall/extended warranty mitigation. All of these instances caused me to lose power while driving in traffic, putting me at serious risk for injury. Please find attached copies of the receipts for the above work. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)