The contact owns a 2010 BMW Z4. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recal…
Read full complaint
The contact owns a 2010 BMW Z4. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms tools are not available
NHTSA ODI #11470484
7,000 miles · Jul 7, 2011
Engine And Engine Cooling
2011 BMW Z4, PURCHASED NEW WITH APPROXIMATELY 7K MILES. STARTED TO FEEL VIBRATION WHEN I PUT ON BRAKES AROUND 5K MILE MARK. VIBRATION LASTS 1-2 SECONDS. HAPPENED 20 TIMES SO FAR. I WAS DRIVING TODAY, 7000K MILE MARK, AND THE ENGINE FAILED AND DIED. LIKE SOMEBODY JUST TURNED IT OFF. LUCKILY I WAS ON LOCAL STREET SO I JUST CAME TO…
Read full complaint
2011 BMW Z4, PURCHASED NEW WITH APPROXIMATELY 7K MILES. STARTED TO FEEL VIBRATION WHEN I PUT ON BRAKES AROUND 5K MILE MARK. VIBRATION LASTS 1-2 SECONDS. HAPPENED 20 TIMES SO FAR. I WAS DRIVING TODAY, 7000K MILE MARK, AND THE ENGINE FAILED AND DIED. LIKE SOMEBODY JUST TURNED IT OFF. LUCKILY I WAS ON LOCAL STREET SO I JUST CAME TO A COMPLETE STOP. THIS IS VERY DANGEROUS! THEN I RESTARTED THE CAR AND IT CAME BACK TO LIFE AND RAN LIKE NORMAL. TOOK IT TO DEALER AND DEALER SAID NOTHING WAS WRONG. SOMETHING IS WRONG IF YOUR CAR DIES WHILE YOU'RE DRIVING!! *TR
NHTSA ODI #10410874
9,000 miles · Jun 18, 2010
Engine And Engine Cooling
WHENEVER SLOWING DOWN TO A NEAR STOP, THE ENGINE WILL RANDOMLY STALL. THIS CAN OCCUR AT ANYTIME, BUT IS MORE LIKELY TO OCCUR WHEN THE OUTSIDE AIR TEMPERATURE IS IN THE 90'S OR ABOVE (IT WILL STALL IN COLD TEMPERATURE AS WELL, BUT NOT AS OFTEN). THE ENGINE TEMPERATURE AT THE TIME OF THE STALL IS ALWAYS COMPLETELY NORMAL, THE CA…
Read full complaint
WHENEVER SLOWING DOWN TO A NEAR STOP, THE ENGINE WILL RANDOMLY STALL. THIS CAN OCCUR AT ANYTIME, BUT IS MORE LIKELY TO OCCUR WHEN THE OUTSIDE AIR TEMPERATURE IS IN THE 90'S OR ABOVE (IT WILL STALL IN COLD TEMPERATURE AS WELL, BUT NOT AS OFTEN). THE ENGINE TEMPERATURE AT THE TIME OF THE STALL IS ALWAYS COMPLETELY NORMAL, THE CAR IS NOT OVERHEATING IN ANYWAY. IT IS ALSO MORE LIKELY TO OCCUR IN "SPORT MODE". THIS ISSUE ONLY EFFECTS BMW E89 3.0 AUTOMATICS. AN AUTOMATIC SHOULD NEVER STALL. ONCE THE ENGINE STALLS YOU ARE FORCED TO STOP THE CAR IN ORDER TO RESTART TO MOVE. THIS ISSUE IS OCCURRING WORLD-WIDE. I HAVE TAKEN THE CAR TO THE BMW DEALER IN AUSTIN, TX TO LOOK INTO THIS ISSUE. THEY STATED THAT THERE WERE NO ERROR CODES PRESENT IN THE COMPUTER. THE CHECK ENGINE LIGHT IS NOT ON. I HAD A BMW SHOP FOREMAN DRIVE WITH ME AND WE REPRODUCED THE ENGINE STALL AS WE APPROACHED A STOPLIGHT. HE STATED THERE WERE NO BMW SERVICE BULLETINS ABOUT THIS ISSUE. OTHER E89 Z4 OWNERS HAVE TAKEN THEIR CAR IN FOR SERVICE AT BMW DEALERS IN CALIFORNIA, FLORIDA AND TEXAS AND IN ALL CASES THE BMW MECHANICS FOUND NO REASON FOR THE ENGINE STALL AND DO NOT HAVE A FIX. RANDOM ENGINE STALL WHEN SLOWING IS AN EXTREMELY DANGEROUS ISSUE. I CONSIDER THIS VEHICLE (E89 3.0 AUTOMATIC) TO BE UNSAFE AND UNRELIABLE IN HOT WEATHER. SERIOUS INJURY CAN OCCUR IF A CAR RANDOMLY SHUTS ITSELF OFF AS IT IS BEING SLOWED. OVER THE PAST 6 MONTHS, THIS HAS HAPPENED TO ME AT LEAST 15-20 TIMES. *TR
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
Consequence & remedy
Consequence: If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2010 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration