NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
263 reports36,350 miles · Apr 17, 2014
Engine
VEHICLE LOST ALL POWER (MECHANICAL AND ELECTRICAL) WITHOUT WARNING. THIS OCCURRED WHILE CRUISING AT HIGHWAY SPEED, UNDER NORMAL CONDITIONS. THE VEHICLE LOST POWER STEERING AND BRAKING BECAME SIGNIFICANTLY MORE DIFFICULT. AFTER DRIFTING SAFELY TO THE HIGHWAY SHOULDER THE VEHICLE REMAINED DISABLED AND COULD NOT STARTED. THE CA…
Read full complaint
VEHICLE LOST ALL POWER (MECHANICAL AND ELECTRICAL) WITHOUT WARNING. THIS OCCURRED WHILE CRUISING AT HIGHWAY SPEED, UNDER NORMAL CONDITIONS. THE VEHICLE LOST POWER STEERING AND BRAKING BECAME SIGNIFICANTLY MORE DIFFICULT. AFTER DRIFTING SAFELY TO THE HIGHWAY SHOULDER THE VEHICLE REMAINED DISABLED AND COULD NOT STARTED. THE CAR EXHIBITED NO SIGNS THAT IT WOULD START AGAIN. INSTRUMENTATION DID NOT DISPLAY INFORMATION AND TOWING WAS NECESSARY. SEVERAL DAYS AFTER DELIVERY TO THE BMW SERVICE CENTER, TECHNICIANS ADVISED THEY HAD ATTEMPTED TO REPAIR THE PROBLEM. THE STATED CAUSE WAS VANOS BOLTS SHEARING OFF INTO THE ENGINE. HOWEVER, ON THE TEST DRIVE THE VEHICLE SUFFERED ANOTHER COMPLETE FAILURE, LEAVING IT DISABLED. 56 DAYS LATER A REMANUFACTURED ENGINE HAD REPLACED THE ORIGINAL DUE TO FAILED REPAIR ATTEMPTS. *TT
NHTSA ODI #10583416
30,000 miles · Apr 14, 2014
Electrical SystemSteering
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT THE STEERING WHEEL WOULD SPORADICALLY BECOME DIFFICULT TO TURN. ADDITIONALLY, THERE WAS AN ELECTRICAL FAILURE WITHIN THE INSTRUMENT PANEL. THE FAILURE WAS RECURRING. THE CHECK ENGINE WARNING LIGHT WAS ALSO ILLUMINATED WHENEVER THE CONTACT REVERSED FROM HIS DRIVEWAY. THE…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT THE STEERING WHEEL WOULD SPORADICALLY BECOME DIFFICULT TO TURN. ADDITIONALLY, THERE WAS AN ELECTRICAL FAILURE WITHIN THE INSTRUMENT PANEL. THE FAILURE WAS RECURRING. THE CHECK ENGINE WARNING LIGHT WAS ALSO ILLUMINATED WHENEVER THE CONTACT REVERSED FROM HIS DRIVEWAY. THE CONTACT ALSO STATED THAT THE VEHICLE COULD NOT BE SHIFTED FROM PARK TO REVERSE OR DRIVE. THE VEHICLE WAS TOWED TWICE TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE IDLE PULLEY BOLT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED TWICE. THE AUTHORIZED DEALER REPLACED THE IDLER PULLEY BELT A THIRD TIME AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #10579534
39,000 miles · Apr 6, 2014
Engine
VANOS INTAKE AND EXHAUST UNITS NEED TO BE REPLACED, ALONG WITH SOME OTHER PARTS RELATED TO THIS. CAR HAS BEEN AT THE BMW CENTER FOR ALMOST 1 WEEK. WHILE I WAS DRIVING DOWN A BUSY ROAD, THE "ENGINE MALFUNCTION, REDUCED POWER" ERROR MESSAGE CAME ON. I ALSO NOTICED, THE CAR HAD TURNED OFF AND I HAD NOT CONTROL OVER THE POWER…
Read full complaint
VANOS INTAKE AND EXHAUST UNITS NEED TO BE REPLACED, ALONG WITH SOME OTHER PARTS RELATED TO THIS. CAR HAS BEEN AT THE BMW CENTER FOR ALMOST 1 WEEK. WHILE I WAS DRIVING DOWN A BUSY ROAD, THE "ENGINE MALFUNCTION, REDUCED POWER" ERROR MESSAGE CAME ON. I ALSO NOTICED, THE CAR HAD TURNED OFF AND I HAD NOT CONTROL OVER THE POWER STEERING WHEEL OR BRAKES. MY MAIN CONCERN IS THIS HAPPENING AGAIN, LUCKILY I WAS NOT ON THE HIGHWAY AND HAD NO ONE IN FRONT OF ME, OTHERWISE IT COULD HAVE BEEN MUCH WORSE DUE TO NO POWER STEERING AVAILABILITY OR BRAKES. *TR
NHTSA ODI #10577747
24,000 miles · Feb 28, 2014
EnginePower TrainVehicle Speed Control
MY 2011 X5 35I HAS AN ACCELERATION DELAY. BMW HAS RECOGNIZED IT AS AN ISSUE IN THE 535I MODELS, CALLING IT AN "ACCELERATION DELAY" AND HAVE ISSUED AN SIB SOFTWARE UPDATE TO REPAIR IT, BUT HAVE NOT DONE SO FOR THE X5 MODEL. I FEEL THIS ISSUE IS DANGEROUS AND A SAFETY ISSUE. *TR
NHTSA ODI #10566454
60,000 miles · Jan 2, 2014
Wheels
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT HIS TIRE CONSTANTLY LOST AIR PRESSURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE RIM WAS CRACKED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 60,000. . ..UPDATED 03-12-14 *BF TH…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT HIS TIRE CONSTANTLY LOST AIR PRESSURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE RIM WAS CRACKED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 60,000. . ..UPDATED 03-12-14 *BF THE CONSUMER STATED THE RIM HAD A STRESS FRACTURE/ UPDATED 04/01/14
NHTSA ODI #10558177
15,000 miles · Sep 11, 2013
Power TrainSteeringWheelsCrashInjury
OUR 2011 BMW X5D (DIESEL) STARTED HAVING STEERING ISSUES IN JUN OF 2012. MULTIPLE REPAIR ATTEMPTS HAVE BEEN UNSUCCESSFUL. LATER IT WAS INVOLVED IN A LOW SPEED CRASH, INJURING THE DRIVER IN DEC 2012 DUE TO A SUDDEN LOSS OF POWER STEERING. THIS WAS JUST MONTHS BEFORE ISSUING A RECALL FOR THE IDENTICAL PROBLEM ALTHOUGH BMW IDENT…
Read full complaint
OUR 2011 BMW X5D (DIESEL) STARTED HAVING STEERING ISSUES IN JUN OF 2012. MULTIPLE REPAIR ATTEMPTS HAVE BEEN UNSUCCESSFUL. LATER IT WAS INVOLVED IN A LOW SPEED CRASH, INJURING THE DRIVER IN DEC 2012 DUE TO A SUDDEN LOSS OF POWER STEERING. THIS WAS JUST MONTHS BEFORE ISSUING A RECALL FOR THE IDENTICAL PROBLEM ALTHOUGH BMW IDENTIFIED PROBLEMS BEFORE THE INITIAL PROBLEM WAS NOTICED. THE VEHICLE STILL TO THIS DAY HAS A PROBLEM WITH THE SUDDEN LOSS OF POWER STEERING, DIFFICULT LOW SPEED MANEUVERS AND UNUSUAL TIRE WEAR. WE DO HAVE A RECORDING OF A BMW OF NORTH AMERICA MASTER TECHNICIAN ADMITTING TO THE PROBLEM THAT BMW REFUSES TO CORRECT. IN FACT BMW REFUSES TO EVEN PERFORM WORK ON OUR VEHICLE EVEN THOUGH IT'S ADVERTISED AS "NO MAINTENANCE FOR 4YEARS/50,000 MILES" THIS IS AT ANY DEALERSHIP WE HAVE GONE TO DUE TO A NOTE IN THE DATABASE FROM BMW OF NORTH AMERICA. ALSO VEHICLE SERVICE HISTORY HAS BEEN FRAUDULENTLY ERASED FROM THEIR DATABASE AND BMW REFUSES TO FURTHER INVESTIGATE THE SAFETY OF THIS VEHICLE WHICH WAS PURCHASED NEW IN 2010 AND IS STILL UNDER FULL FACTORY WARRANTY. THEY INSIST THE VEHICLE IS SAFE TO DRIVE OFFICIALLY, WHILE UNOFFICIALLY ADMITTING THAT IT IS DANGEROUS. *TR
NHTSA ODI #10543104
18,000 miles · Jul 18, 2013
Electrical SystemTiresFire
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE TPM ERROR LIGHT ILLUMINATED AS THE VEHICLE SURGED. IN ADDITION, SMOKE WAS SEEN COMING FROM UNDER THE HOOD AREA. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE REAR DRIVER'S SIDE TIRE SENSOR NEEDED TO B…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE TPM ERROR LIGHT ILLUMINATED AS THE VEHICLE SURGED. IN ADDITION, SMOKE WAS SEEN COMING FROM UNDER THE HOOD AREA. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE REAR DRIVER'S SIDE TIRE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 18,000. THE VIN WAS NOT AVAILABLE. *TR
NHTSA ODI #10525563
59,000 miles · Jul 10, 2013
EngineService BrakesSteering
WHILE DRIVING MY ENGINE SUDDENLY SHUT OFF ALONG WITH POWER STEERING AND POWER BRAKES. IT STARTED AGAIN AND I TOOK IT TO A BMW DEALER THAT SAID I NEEDED A $325 SOFTWARE UPDATE. I ASKED IF THAT MEANT MY ENGINE WOULD SHUT OFF WHILE DRIVING SHOULD BY SOFTWARE EVER GO OUT OF DATE. THEY SAID YES, IT HAPPENS BUT NOT ON ALL SOFTWARE …
Read full complaint
WHILE DRIVING MY ENGINE SUDDENLY SHUT OFF ALONG WITH POWER STEERING AND POWER BRAKES. IT STARTED AGAIN AND I TOOK IT TO A BMW DEALER THAT SAID I NEEDED A $325 SOFTWARE UPDATE. I ASKED IF THAT MEANT MY ENGINE WOULD SHUT OFF WHILE DRIVING SHOULD BY SOFTWARE EVER GO OUT OF DATE. THEY SAID YES, IT HAPPENS BUT NOT ON ALL SOFTWARE UPDATES. THEY ALSO SAID SOFTWARE UPDATE COME OUT ABOUT EVERY 3 TO 4 MONTHS MEANING MY ENGINE COULD BE SHUT OFF AGAIN AT ANY TIME. I FELT I HAD NO CHOICE BUT TO PAY THE MONEY SO MY CAR WOULD RUN AGAIN. I AM CONCERNED NOW ABOUT DRIVING AT ANY HIGHER RATE OF SPEED CONSIDERING I COULD LOSE MY STEERING AND BRAKES ANYTIME SOMEONE DECIDES I NEED TO UPDATE SOFTWARE THAT I WAS NEVER INFORMED WAS OUT OF DATE. *TR
NHTSA ODI #10524158
16,000 miles · Feb 13, 2013
Electrical SystemEngine
STARTED THE CAR AND THE ENGINE LIGHT CAME ON WITH "ENGINE MALFUNCTION - REDUCED POWER" AND DROVE A FEW HUNDRED YARDS AND THEN THE CAR COMPLETELY DIED. THE 2011 BMW X5 35I PREMIUM JUST DIED - NO POWER WHATSOEVER. BECAUSE THERE WAS NO POWER, THE CAR COULD NOT BE PUT INTO NEUTRAL TO BE PUT ON A FLATBED. THE X5 HAD TO BE PUT ON A …
Read full complaint
STARTED THE CAR AND THE ENGINE LIGHT CAME ON WITH "ENGINE MALFUNCTION - REDUCED POWER" AND DROVE A FEW HUNDRED YARDS AND THEN THE CAR COMPLETELY DIED. THE 2011 BMW X5 35I PREMIUM JUST DIED - NO POWER WHATSOEVER. BECAUSE THERE WAS NO POWER, THE CAR COULD NOT BE PUT INTO NEUTRAL TO BE PUT ON A FLATBED. THE X5 HAD TO BE PUT ON A CRANE AND LIFTED ONTO A FLATBED TOW TRUCK. BOUGHT THIS VEHICLE IN THE U.S. AND IS U.S. SPEC (CAR WAS IN THE U.S. FOR 2 YEARS) - SHIPPED THE CAR TO GERMANY AND THIS IS WHERE THE INCIDENT HAPPENED (CAR BEEN IN GERMANY JUST A FEW MONTHS). BMW OF MUNICH SAID THAT THERE IS A BOLT THAT CAN BREAK OFF - WHICH IT DID - MUNICH REQUESTED THE LOCAL DEALER TO TAKE THE ENGINE APART TO SEE IF THAT WAS THE FAULT AND THEY CONFIRMED IT WAS. BMW IS REPLACING OUR ENGINE BECAUSE OF THIS FAULT. HOWEVER, THE RECALL AS OF NOW IS ONLY FOR THE X5 DIESELS. THE RECALL SHOULD BE EXPANDED. HAD WE BEEN ON THE AUTOBAHN WHERE THERE AREN'T MANY SPEED LIMIT AREAS, THIS COULD HAVE RESULTED IN A FATAL CRASH IF SOMEONE GOING 100+MPH RAMMED BEHIND US FROM OUR CAR DYING OF CATASTROPHIC FAILURE. AT 16,000 MILES THE VEHICLE SHOULD NOT NEED A NEW ENGINE. *TR
NHTSA ODI #10497968
18,000 miles · Jan 14, 2013
EngineService Brakes
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, EXHAUST FUMES FROM THE ENGINE COULD BE SMELLED WHILE IN THE CABIN. THE CONTACT ALSO STATED THAT THE POWER ASSIST ON THE BRAKES FAILED AND THAT BOTH FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIR…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, EXHAUST FUMES FROM THE ENGINE COULD BE SMELLED WHILE IN THE CABIN. THE CONTACT ALSO STATED THAT THE POWER ASSIST ON THE BRAKES FAILED AND THAT BOTH FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT IN ORDER TO REMEDY THE BRAKE FAILURE, A VALVE WOULD HAVE TO BE REPLACED. THE TECHNICIAN WAS UNABLE TO REPLICATE THE EXHAUST FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 18,000 AND THE CURRENT MILEAGE WAS 20,000.
NHTSA ODI #10492948
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jun 2, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.
Consequence & remedy
Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration