Engine. Review the 110 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports15 fire reports3 injury reports

What owners actually said

263 reports

60,000 miles · Sep 17, 2014

Power Train

ONE YEAR AGO, MADE A LEFT HAND TURN FROM COMPLETE STOP, ACCELERATING TO 40 MPH? MAYBE? WHEN I HEARD AN AWFUL CRUNCHING NOISE, I STOPPED AND SAW MY X5'S DRIVE SHIFT DROPPED DOWN SOME OIL CAME OUT. THE PROBLEM BECAUSE THE FRONT DRIVE SHIFTS U-JOINT FAILURES. *TR

NHTSA ODI #10637140

78,000 miles · Sep 8, 2014

EnginePower Train

Read full complaint

THE CAR WARNING LIGHT CAME ON AS "REDUCED POWER". TOOK THE CAR INTO CREVIER BMW IN SANTA ANA. THERE IS A RECALL ON THE VANOS SYSTEM FOR OUR CAR. WE HAVE HAD MULTIPLE PROBLEMS BEFORE THIS AS WELL. LAST JUNE, THE ENGINE OIL HOUSING UNIT WAS REPLACED. NOW THE PROBLEM POINTS TO THE VANOS ON THE DIAGNOSTIC TEST DONE AT THE DEALER. HOWEVER, THE DEALER AND BMW NORTH AMERICA WILL NOT ADDRESS THE ISSUES. BOTH KEEP TELLING US THAT THE "PARTS ARE NOT AVAILABLE" AND THAT THERE IS A RECALL ON THE VEHICLE BUT WILL LOOK INTO IT ONLY WHEN OR IF THE PARTS BECOME AVAILABLE. THUS, FOR THEM TO REPAIR THE ISSUES RIGHT NOW, WE WOULD NEED TO PAY. THIS SEEMS TO BE A SCAM AND CONVENIENCE ON THEIR PART NOT TO ADDRESS THE ISSUES. I WOULD ASK NHTSA TO PLEASE LOOK INTO THIS TYPE OF PRACTICE AND MAKE BMW RESPONSIBLE AND ACCOUNTABLE TO THEIR CUSTOMERS. THANK YOU. *TR

NHTSA ODI #10631473

Mileage unknown · Aug 21, 2014

Engine And Engine Cooling

TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE AND ENGINE COOLING) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER STATED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT DID NOT EX…

Read full complaint

NHTSA ODI #10627306

50,500 miles · Aug 19, 2014

Vehicle Speed Control

Read full complaint

IN MARCH OF THIS YEAR MY X5 HAD THE INCREASED ENGINE NOISE, CHECK ENGINE LIGHT COMING ON, AND STALLED ON I-80 IN OMAHA. I GOT THE CAR PULLED OVER AND STARTED AGAIN. I THEN HAD HUSKER AUTO OF LINCOLN NE (BMW SHOP) LOOK AT IT. THIS HAS NOT HAPPENED AGAIN TO DATE. IN JUNE I GET A LETTER FROM BMW ABOUT THE SAFETY RECALL OF VANOS ASSEMBLY BOLTS. THE DESCRIPTION OF THE PROBLEM FIT MY SITUATION BACK IN MARCH. I TOOK THE LETTER TO HUSKER AUTO BUT THEY SAID I HAD TO WAIT FOR ANOTHER LETTER FROM BMW. I HAVE APPROACHED HUSKER AUTO TWICE MORE SINCE JUNE, WITH SAME STORY FROM THEM. MY QUESTION TO YOU, IS THERE ANYTHING YOUR ADMINISTRATION CAN DO ABOUT BMW NOT ACTING TIMELY ON THE X5 RECALL ISSUE? *TR

NHTSA ODI #10626465

71,000 miles · Aug 5, 2014

EngineEngine And Engine Cooling

Read full complaint

ONLY AFTER ABOUT 10 MINUTES OF DRIVING IN THE NEIGHBORHOOD, WE GOT A WARNING "ENGINE HOT, DRIVE MODERATELY" THEN A FEW MINUTES LATER, IT SAID TO ENGINE HOT, AND TO STOP THE CAR IMMEDIATELY. WE HAD TO PULL THE CAR OVER AND AFTER ENGINE COOLED A BIT, TAKE OUR 2011 X5 TO THE NEAREST SHOP IN AN EMERGENCY. THE SHOP MECHANIC HAD TO REPLACE THE WATER PUMP AND SAID THAT IT IS A COMMON PROBLEM WITH BMW X5, EVEN THOUGH WE ONLY HAD 71,000 MILES. I LOOKED ONLINE AND THERE IS A RECALL AFFECTING WATER PUMPS FOR BMW X5 2011 (ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER RECALL NUMBER: 11V521000) BUT WHEN I CALLED BMW, IT SAID THAT MY PARTICULAR ENGINE IS NOT RECALLED. THE MECHANIC SAYS THIS IS UNUSUAL FOR SUCH A NEW CAR TO HAVE ENGINE OVERHEATING DUE TO WATER PUMP FAILURE, THIS SHOULD BE INVESTIGATED FOR SAFETY ISSUE. *TR

NHTSA ODI #10619011

65,000 miles · Jul 18, 2014

Engine

TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THERE WAS A MALFUNCTION IN THE ENGINE WITH THE TORQUE SCREW. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF…

Read full complaint

NHTSA ODI #10614581

71,000 miles · Jun 10, 2014

Engine And Engine Cooling

Read full complaint

HI, I JUST PURCHASED THE ABOVE VEHICLE ON 5/13/14 AND ABOUT TWO WEEKS LATER MY CAR STARTED OVERHEATING. I KIND OF KNEW THAT THERE IS A PROBLEM WITH WATER PUMP SO I STARTED DOING SOME RESEARCH ONLINE TO SEE IF BMW X5 WAS ANY RECALLS AND TO MY SURPRISE THEY RECALLED NUMEROUS X5'S DUE TO WATER PUMP. I ALSO CALLED THEIR CUSTOMER SERVICE TO SEE IF THERE WAS A RECALL ON MY CAR AND UNFORTUNATELY I WAS TOLD THAT THERE ISN'T. I TOOK MY CAR TO INTERNATIONAL AUTOS ON 6/9/14 FOR A DIAGNOSTICS CHECK AND THEY HAVE CONFIRMED THAT WATER PUMP NEEDS TO BE REPLACED. I BELIEVE THAT MY CAR SHOULD BE UNDER RECALL AS WELL SINCE BMW SEEMS TO HAVE A LOT OF TROUBLE WITH THIS. *TR

NHTSA ODI #10597364

59,238 miles · May 31, 2014

Engine

Read full complaint

OON FRIDAY, MAY 2, 2014 I WAS DOING ABOUT 75MPH ON THE EXPRESSWAY IN ATLANTA HEADING HOME FORM A MOVIE AT AROUND 1120PM AND IMMEDIATELY WITHOUT ANY WARNING OR A ENGINE LIGHT WITHIN MY 2011, BMW X5 BEGAN TO GO INTO SAFE MODE DECREASING MY SPEED FROM 75 TO 0 IN LESS THAN 60 SECONDS ' EVENTUALLY STALLING AND UNABLE TO RESTART. THE CAR TOOK OVER AND WENT INTO NEUTRAL BY ITSELF AND I WAS UNABLE TO ACCELERATE OR CONTROL THE SPEED ON MY OWN. ATLANTAS 285 EXPRESSWAYS HAS MULTIPLE LANES AND THOUGH TRAFFIC WAS NOT AS HEAVY AS IT GENERALLY IS DURING RUSH HOURS, I HAD TO FRANTICALLY NAVIGATE MYSELF OVER SIX LANES TO THE SHOULDER ROAD (AVOIDING THE MAIN LANE BY THE EXTERIOR WALL OUT OF FEAR OF SOMEONE HITTING ME FROM BEHIND). I BEGAN TO CRY UNCONTROLLABLY AND IMMEDIATELY HIT THE SOS OPTION WITHIN THE CAR AND EXPLAIN WHAT JUST OCCURRED TO THE REPRESENTATIVE ON THE PHONE. THE LADY WAS EXTREMELY PLEASANT AND DID HER BEST TO PUT ME AT EASE AND ASSURED ME ASSISTANCE WAS ON THE WAY. I THEN CALLED MY HUSBAND AND HAD HIM MEET ME THERE AS WELL. WITHIN AN HOUR A TOWING COMPANY HAD COME AND ASKED ME IF I WANTED THEM TO TAKE IT TO THE NEAREST BMW DEALERSHIP AND I STATED SURE THAT DEALERSHIP WAS NALLEY BMW. *TR

NHTSA ODI #10595286

54,000 miles · May 14, 2014

Power Train

Read full complaint

MY BMW X5 2011 STARTED GIVING ME LIGHT WHILE I WAS DRIVING POWER REDUCED ENGINE MALFUNCTION AND IMMEDIATELY AFTER 10 MIN ENGINE STOPPED WHILE I WAS DRIVING CALLING BMW FOR IT BUT FORTUNATELY I WAS DRIVING AT 10-20 MILES AN HOUR VERY SLOW AND WAS ABLE TO PULL ON SIDE BUT IT WAS HORRIBLE EXPERIENCE WITH MY KIDS ,WIFE WHOLE FAMILY IN CAR ..........COULD HAVE BEEN TERRIBLE ......VERY SCARED NOW ....SPENDING BIG MONEY FOR BMW AND ONLY AFTER 54000MILES ....SUCH THING HAPPENING ..ITS TERRIBLE .I IMPORTED THIS VEHICLE TO CANADA SO DON'T HAVE OPTION BELOW FOR CANADA AND ZIP CODE BUT STILL WANT TO REPORT THIS SERIOUS PROBLEM .....VERY IMPORTANT. *TR

NHTSA ODI #10588436

70,000 miles · May 6, 2014

Power Train

Read full complaint

WHILE ACCELERATING TO ENTER THE HIGHWAY, A LOUD POP OCCURRED AT APPROX. 35MPH. THE POP WAS FOLLOWED BY A LOSS OF DRIVE TORQUE TO THE FRONT AXLE. I BEGAN TO IMMEDIATELY PULL OVER AND A SECOND LOUD POP WAS HEARD FOLLOWED BY THE SOUND OF METAL CRASHING TO THE GROUND. I EXPERIENCED A COMPLETE LOSS OF DRIVE TORQUE TO THE FRONT AXLE AND COASTED TO RELATIVE SAFETY ON THE ENTRANCE OF AN EXIT RAMP. UPON EXPECTING THE UNDERSIDE OF THE VEHICLE, I COULD SEE A SEPARATED FRONT DRIVESHAFT, MISSING UNIVERSAL JOINT AND THE TRANSFER CASE WAS TOUCHING THE GROUND AND THERE WAS A PUDDLE OF FLUID DIRECTLY UNDERNEATH THE CAR. THERE WAS A TRAIL OF FLUID ON THE EXIT RAMP LEADING TO WHERE I PULLED OVER INDICATING THAT THE FLUID WAS LEAKING AND EVENTUALLY DUMPED COMPLETELY WHEN I PULLED OVER. THE VEHICLE WAS TOWED TO THE NEARED BMW DEALERSHIP FOR SERVICE AND DIAGNOSIS. *TR

NHTSA ODI #10586797

Official recalls

23V707000 · Engine And Engine Cooling:engine

Oct 20, 2023

BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.

Consequence & remedy

Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.

Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.

20V016000 · Air Bags:frontal:passenger Side:inflator Module

Jan 15, 2020

BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.

20V017000 · Air Bags:frontal:driver Side:inflator Module

Jan 15, 2020

BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.

19V017000 · Air Bags:frontal:passenger Side:inflator Module

Jan 14, 2019

BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.

18V336000 · Engine And Engine Cooling:engine

May 23, 2018

BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.

Consequence & remedy

Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.

18V248000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Apr 18, 2018

BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.

Consequence & remedy

Consequence: If the circuit board were to overheat, it can increase the risk of a fire.

Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.

Additional source detail variants (2)

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Consequence: If the circuit board were to overheat, it can increase the risk of a fire.

Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.

Engine And Engine Cooling:engine

Consequence: If the circuit board were to overheat, it can increase the risk of a fire.

18V030000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.

17V683000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Oct 30, 2017

BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence & remedy

Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.

Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.

17V138000 · Power Train:driveline:driveshaft

Mar 2, 2017

BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.

Consequence & remedy

Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.

16V746000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 17, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Consequence & remedy

Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

16V364000 · Air Bags:frontal:passenger Side:inflator Module

May 25, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.

16V311000 · Power Train:driveline:driveshaft

May 17, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.

Consequence & remedy

Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.

11V521000 · Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Oct 20, 2011

BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.

Consequence & remedy

Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.

Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.

10V233000 · Equipment:other:labels

Jun 2, 2010

BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.

Consequence & remedy

Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ18001 · Idler Pulley Bolt Failure

Opened Apr 18, 2018 · Closed Dec 1, 2018

Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections

In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.

Additional source detail variants (3)

Steering

Steering:hydraulic Power Assist:hose, Piping, And Connections

Steering:hydraulic Power Assist System