NHTSA owner reports · September 18, 2026 snapshot.
Latches/locks/linkages complaints
18 reportsClear category filter83,000 miles · Aug 17, 2008
Latches/locks/linkagesStructure
FRONT DOORS ARE FREEZING UP IN COLD WEATHER. ONCE THE TEMPERATURE RISES THE DOORS WILL OPEN. HAPPENS EARLY IN THE MORNING/ LATE NIGHT WHEN I NEED TO LEAVE FOR WORK. SOMETIMES YOU CAN FORCE THE HANDLE TO OPEN BUT THEN THE DOOR WILL NOT CLOSE AND HAVE TO DRIVE HOLDING THE DOOR SHUT. THERE MUST BE A RECALL ON THIS,THERE HAVE BEEN S…
Read full complaint
FRONT DOORS ARE FREEZING UP IN COLD WEATHER. ONCE THE TEMPERATURE RISES THE DOORS WILL OPEN. HAPPENS EARLY IN THE MORNING/ LATE NIGHT WHEN I NEED TO LEAVE FOR WORK. SOMETIMES YOU CAN FORCE THE HANDLE TO OPEN BUT THEN THE DOOR WILL NOT CLOSE AND HAVE TO DRIVE HOLDING THE DOOR SHUT. THERE MUST BE A RECALL ON THIS,THERE HAVE BEEN SO MANY COMPLAINTS ABOUT THIS ISSUE. THIS HAS HAPPENED TO ME DOZENS OF TIMES. WENT TO DEALER MANY TIMES, REPLACED BOWDEN CABLE/ACTUATORS. COST ME $600.00 TO FIX, WILL SEE IF IT WORKS NEXT WINTER. *TR
NHTSA ODI #10238612
88,000 miles · Jan 3, 2008
Engine And Engine CoolingLatches/locks/linkages
MY 2001 BMW X5 HAS SERIOS ISSUES WITH ITS DESIGN THAT BMW CORP REFUSES TO ACKNOWLEDGE OR FIX. 1ST THERE IS A FAULTY DESIGN ON THE PVC CAUSING THE VALVE TO FREEZE AND DRAIN THE OIL INTO THE ENGINE. THIS ALMOST CAUSED A FIRE IN MY CAR. AND COST ME ABOUT $1200 TO FIX. 2ND THERE IS A DESIGN FLAW WITH THE FRONT DOORS WHEREBY THE EI…
Read full complaint
MY 2001 BMW X5 HAS SERIOS ISSUES WITH ITS DESIGN THAT BMW CORP REFUSES TO ACKNOWLEDGE OR FIX. 1ST THERE IS A FAULTY DESIGN ON THE PVC CAUSING THE VALVE TO FREEZE AND DRAIN THE OIL INTO THE ENGINE. THIS ALMOST CAUSED A FIRE IN MY CAR. AND COST ME ABOUT $1200 TO FIX. 2ND THERE IS A DESIGN FLAW WITH THE FRONT DOORS WHEREBY THE EITHER FREEZE SHUT OR REFUSE TO LOCK IN TEMPERATURES BELOW 17F. THIS IS A HAZARD WAITING TO HAPPEN. PLEASE HELP US ( CONSUMERS) SINCE BMW APPARENTLY HAS NO INTEREST IN ADRESSING THESE ISSUES.*CN
NHTSA ODI #10213628
67,000 miles · Jan 31, 2006
Latches/locks/linkages
DT*: THE CONTACT STATED IN FREEZING CONDITIONS, THE DRIVER SIDE DOOR LATCH FREEZES SHUT. THE DEALERSHIP DETERMINED THE LATCH NEEDS TO BE REPLACED. THE CONTACT IS UNAWARE IF THIS IS A PROBLEM WITH THE OTHER DOORS, SINCE THEY ARE NOT USED. UPDATED 03/09/06
NHTSA ODI #10149111
5,000 miles · Jan 16, 2006
Latches/locks/linkages
THE DRIVER AND FRONT PASSENGER DOOR MECHANISM FREEZES (FREQUENTLY) IN COLD WEATHER SUCH THAT THE DOOR WILL OPEN BUT WILL NOT LATCH WHEN CLOSED. THE RESULT IS THAT A DRIVER MUST DRIVE HOLDING THE DOOR CLOSED OR NOT DRIVE THE CAR AT ALL, WHICH IS DIFFICULT IF YOU NEED TO GET HOME. *JB
NHTSA ODI #10147840
Mileage unknown · Sep 1, 2005
Latches/locks/linkages
MY 2001 BMW X5 DOOR LOCKS GET STUCK WHEN IT IS VERY COLD, USUALLY BELOW 15 DEGREES FAHRENHEIT. THE KEY REMOTE DOES NOT WORK & IF I CAN GET THE KEY TO MANUALLY UNLOCK THE DOOR, AND GET INTO THE VEHICLE, WHEN I GO TO SHUT THE DOOR THE LATCH IS STUCK "OPEN" AND WILL NOT CLOSE, THEREFORE MAKING THE CAR UN-DRIVABLE BECAUSE THE DOOR …
Read full complaint
MY 2001 BMW X5 DOOR LOCKS GET STUCK WHEN IT IS VERY COLD, USUALLY BELOW 15 DEGREES FAHRENHEIT. THE KEY REMOTE DOES NOT WORK & IF I CAN GET THE KEY TO MANUALLY UNLOCK THE DOOR, AND GET INTO THE VEHICLE, WHEN I GO TO SHUT THE DOOR THE LATCH IS STUCK "OPEN" AND WILL NOT CLOSE, THEREFORE MAKING THE CAR UN-DRIVABLE BECAUSE THE DOOR WILL NOT LATCH CLOSE. I HAVE DISCUSSED THIS W/ BMW ON 8/16/05 & THEY REVIEWED IT. A BMW DISTRICT REPRESENTATIVE SAID THAT THEY HAVE NOTICED THAT THE CURRENT "LATCHING/LOCKING" SYSTEM CAN ALLOW MOISTURE TO GET INTO THE LOCKS & MAKE THEM UNUSABLE. THEY OFFERED TO REPLACE ALL 4 LOCKING MECHANISMS BUT I WOULD HAVE TO PAY 1/2 PART & LABOR, COST TO ME $450.00 OUT OF POCKET. THIS SOUNDS LIKE AN ENGINEERING PROBLEM THAT BMW SHOULD RECALL. I WOULD LIKE TO HAVE THIS INVESTIGATED. *NM
NHTSA ODI #10135132
63,200 miles · Sep 1, 2005
Electrical SystemExterior LightingLatches/locks/linkages
1. HAD CAR SERVICED AT 60,000 MILES, ONLY 3 WEEKS LATER THE GREEN DASHES STARTED APPEARING AGAIN AND STAYING ON, AS IF I NEEDED TO HAVE CAR SERVICED. CALLED DEALER AND THEY SAID NOT TO WORRY, THIS HAS BEEN KNOW TO HAPPEN, JUST IGNORE IT. 2. VERY LOUD NOISE FROM SUN ROOF (CLOSED) WHILE TRAVELING ON FREEWAY AND LEAKS DURING C…
Read full complaint
1. HAD CAR SERVICED AT 60,000 MILES, ONLY 3 WEEKS LATER THE GREEN DASHES STARTED APPEARING AGAIN AND STAYING ON, AS IF I NEEDED TO HAVE CAR SERVICED. CALLED DEALER AND THEY SAID NOT TO WORRY, THIS HAS BEEN KNOW TO HAPPEN, JUST IGNORE IT. 2. VERY LOUD NOISE FROM SUN ROOF (CLOSED) WHILE TRAVELING ON FREEWAY AND LEAKS DURING CAR WASHES? DEALER SAID THEY CAN REPLACE THE SEAL AND THIS SHOULD FIX THE PROBLEM. 3. BRAKE LIGHT INDICATOR ON DASH COMES ON AND OFF, AS IF BULB IS OUT, BUT JUST REPLACED BULB, THEN REPLACED AGAIN, SOMETIMES THIS BRAKE LIGHT WORKS AND SOMETIMES IT DOESN'T. 4. WINDOW ON FRONT PASSENGER WINDOW WOULD NOT GO BACK UP AFTER OPENED, THEN A DAY LATER, THE DOOR WOULD NOT OPEN OR CLOSE. DEALER REPLACED THE WINDOW MECHANISM THAT CONTROLS BOTH THE DOOR HANDLE AND THE WINDOW AT MY COST MIND YOU THE REAR WINDOW AND DOOR HAD BEEN DONE ONLY A YEAR BEFORE. THE DEALER TOLD ME THAT THIS HAPPENS ON ALL GERMAN CARS, DOESN'T MATTER THE AGE OF CAR OR MAKE. HOW FRUSTRATING - SPEND $45,000 AND KNOW WINDOWS WILL EVENTUALLY QUIT WORKING?? 5. FRONT RIGHT HEADLAMP GETS MOISTURE IN IT AND IT TAKES 3-5 DAYS TO CLEAR UP. 6. DRIVER CUP HOLDERS, WHAT IS UP WITH THAT - CAN ONLY PUT ONE CUP IN IT, WHEN TRY TO PUT 2 IN, THEY OVERLAP, VERY FRUSTRATING WHEN DRIVING. 7. STORAGE IN FRONT MINIMAL AND A HASSLE, YOU HAVE TO REACH BACK AND SORT OF BEHIND YOU TO GET INTO COMPARTMENT - DANGEROUS WHILE DRIVING. 8. LEATHER SEATS ARE VERY HARD, NEED A PLUSHIER LEATHER. 9. WHEELS, BRAKE "DUST" GETS ALL OVER THE WHEELS MUCH MUCH MORE THAN ANY OTHER LUXURY CAR I HAVE EVER HAD. 10. CARGO COVER IN REAR NEEDS WORK, CHECK OUT THE ONE LEXUS USES IN RX30. 11. NEED MORE CARGO SPACE - COMPARED TO RX330 AND THE VOLVO X90, SPACE IS EXTREMELY SMALL. 12. DISAPPOINTED IN MY CAR - WANT TO SELL IT, WILL NOT BUY ANOTHER BMW. *NM
NHTSA ODI #10135032
42,000 miles · Aug 18, 2005
Latches/locks/linkages
ELECTRONIC DOOR LOCKS FAIL, NO ENTRY IN TO THE VEHICLE. WAS REPAIRED AND THEN FAILED AGAIN. *JB
NHTSA ODI #10133293
33,000 miles · Feb 10, 2005
Latches/locks/linkages
I HAVE A 2001 BMW X5 WHICH HAS PROBLEMS WITH FREEZING FRONT DOORS (BMW HAS ACKNOWLEDGED THE DESIGN DEFECT, REFERENCE # 200503100195, SI 510204, AND S.I. 51 51 02 DATED MARCH 2002.) THAT POSE A SIGNIFICANT SAFETY HAZARD, AND HAVE NOT RECEIVED AN ADEQUATE RESPONSE IN DEALING WITH THE MATTER. I HAVE FILED A COMPLAINT WITH THE NHTS…
Read full complaint
I HAVE A 2001 BMW X5 WHICH HAS PROBLEMS WITH FREEZING FRONT DOORS (BMW HAS ACKNOWLEDGED THE DESIGN DEFECT, REFERENCE # 200503100195, SI 510204, AND S.I. 51 51 02 DATED MARCH 2002.) THAT POSE A SIGNIFICANT SAFETY HAZARD, AND HAVE NOT RECEIVED AN ADEQUATE RESPONSE IN DEALING WITH THE MATTER. I HAVE FILED A COMPLAINT WITH THE NHTSA. I AM AN ACTIVE DUTY ARMY OFFICER STATIONED IN GARMISCH, GERMANY. THE CAR WAS WITH US IN CALIFORNIA AND KANSAS FROM 2001 TO 2004. THE CAR DID NOT HAVE THE DOOR FREEZING PROBLEMS WHILE UNDER WARRANTY; WE KEPT IT IN A GARAGE AND THE BOWDEN CABLES DID NOT GET WET DURING COLD WEATHER. WE HAVE NO GARAGE HERE, AND ANY TIME THE WEATHER GETS A FEW DEGREES BELOW FREEZING, THE FRONT DOORS CEASE TO OPERATE. ONE MUST RUN THE CAR BETWEEN 15 MINUTES TO 1.5 HOURS BEFORE THE DOORS OPERATE NORMALLY. WHEN THE CAR COOLS DOWN, THE DOORS FREEZE AGAIN. THE PROBLEM WITH THE DOORS HERE IN GERMANY IS SEVERE AND POSES A SIGNIFICANT SAFETY RISK; DOES BMW REALLY WANT TO RISK LITIGATION FOR SOMEONE TRAPPED IN THE CAR IN THE EVENT OF AN ACCIDENT? I DO NOT UNDERSTAND WHY THE CAR WAS NOT RECALLED FOR SUCH A SERIOUS AND ACKNOWLEDGED SAFETY DESIGN DEFECT. OUR LOCAL DEALERSHIP IN GARMISCH IS UNABLE TO LOCATE THE BELOW SI IN HIS DATABASE. HE DOES NOT KNOW HOW TO FIX THE PROBLEM. I AM ALSO DISTURBED THAT I WILL HAVE TO PAY UPWARDS OF $1000 TO FIX THE PROBLEM---THIS WOULD HAVE BEEN COVERED UNDER WARRANTY AND SHOULD HAVE BEEN FIXED WHEN THE CAR WENT UNDER SERVICES IN LATE WINTER OF 2004 (AND ALSO HAD OTHER SI WORK DONE, SUCH AS A FAULTY RADIATOR FAN THAT COULD HAVE CAUSED THE CAR TO BURN----HECK OF A COMBINATION IF THE FREEZING DOORS HAD BEEN ACTING UP AT THE SAME TIME!).*AK
NHTSA ODI #10110233
96,000 miles · Jan 27, 2005
Latches/locks/linkages
I HAVE 2001 BMW X5 3.0. AFTER LAST WEEK'S SNOW STORM AND COLD WEATHER IN BOSTON AREA, MY 2001 X5 DOORS ARE FROZEN. ACTUALLY, I OPENED THEM FROM OUTSIDE YESTERDAY MORNING (FEELS LIKE DOOR HANDLE GOT FROZEN). BUT THEN I COULD NOT GET THEM CLOSED. SO, I HAD TO PUSH DOWN DOOR LOCK (LITTLE KNOB) BY WINDOW AND PULL HARD TO GET THEM CL…
Read full complaint
I HAVE 2001 BMW X5 3.0. AFTER LAST WEEK'S SNOW STORM AND COLD WEATHER IN BOSTON AREA, MY 2001 X5 DOORS ARE FROZEN. ACTUALLY, I OPENED THEM FROM OUTSIDE YESTERDAY MORNING (FEELS LIKE DOOR HANDLE GOT FROZEN). BUT THEN I COULD NOT GET THEM CLOSED. SO, I HAD TO PUSH DOWN DOOR LOCK (LITTLE KNOB) BY WINDOW AND PULL HARD TO GET THEM CLOSED. NOW, I COULD NOT OPEN THEM AT ALL. I AM CLIMBING IN AND OUT OF THE TRUNK DOOR TO GET INSIDE. FORTUATELY, THERE IS NO ACCIDENT. BUT, I THINK THIS IS A SERIOUS SAFETY ISSUE WHEN AN ACCIDENT DOES OCCUR (HARD TO ESCAPE). BMW NORTH AMERICA IS AWARE OF THIS PROBLEM (SI 51 51 02), HOWEVER THERE IS NO PROPER ACTION FROM THEM.*AK
NHTSA ODI #10108039
Mileage unknown · Jan 21, 2005
Latches/locks/linkages
2001 BMW X5. IN COLD WEATHER THE DOORS FREEZE UP NOT ALLOWING ACCESS IN OR OUT OF THE VEHICLE. I HAVE HAD TO CRAWL THROUGH THE HATCH OR REAR DOORS TO GET OUT OF THE VEHICLE. THIS HAS HAPPENED NUMEROUS TIMES AND CREATES A REAL HAZARD AS YOU CANNOT EGRESS THE VEHICLE QUICKLY. ALSO THE LATCH FREEZES AND WILL NOT ALLOW THE DOOR TO C…
Read full complaint
2001 BMW X5. IN COLD WEATHER THE DOORS FREEZE UP NOT ALLOWING ACCESS IN OR OUT OF THE VEHICLE. I HAVE HAD TO CRAWL THROUGH THE HATCH OR REAR DOORS TO GET OUT OF THE VEHICLE. THIS HAS HAPPENED NUMEROUS TIMES AND CREATES A REAL HAZARD AS YOU CANNOT EGRESS THE VEHICLE QUICKLY. ALSO THE LATCH FREEZES AND WILL NOT ALLOW THE DOOR TO CLOSE SO THE DOOR CAN FLY OPEN WHILE DRIVING. I AM AN ACTIVE MEMBER ON A BMW OWNERS MESSAGE BOARD AND THIS IS A RECURRING PROBLEM FOR MANY DRIVERS. *NM
NHTSA ODI #10107665
Official recalls
12Oct 31, 2025
BMW of North America, LLC (BMW) is recalling certain 2000-2001 X5 vehicles that may be equipped with a sport steering wheel containing a Takata PSDI-4 air bag inflator. The inflator may explode during deployment due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature, and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is complete. Dealers will inspect and replace the driver's front air bag, as necessary, free of charge. Owner notification letters were mailed December 29, 2025. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 23, 2025. This recall expands previous NHTSA recall number 19V015.
Jan 20, 2017
BMW of North America, LLC (BMW) is recalling certain 2000-2002 BMW 320i, 323i, 325i, 325xi, 330i, 330xi, 323Ci, 325Ci, 330Ci, M3, 323iT, 325iT and 325xiT vehicles, 2001-2002 525i, 530i, 540i, M5, 525iT and 540iT vehicles, and 2001-2003 X5 3.0i, X5 4.4i, and X5 4.6is vehicles. These vehicles may have had a driver-side air bag module installed as replacement equipment such as after a vehicle crash necessitating replacement of the original air bag, or as a remedy part for a prior recall. These replacement modules contain an air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to lower absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will inspect the driver side air bag module, replacing it as necessary, free of charge. The recall began March 15, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Jan 9, 2003
ON CERTAIN SPORT UTILITY VEHICLES, IT MAY BE POSSIBLE FOR THE FRONT BRAKE LINE TO SLIP OUT OF THE RETAINING BRACKET LOCATED AT THE FRONT STRUT. THE BRAKE HOSE THAT IS ATTACHED TO THE BRAKE LINE COULD COME IN CONTACT WITH THE TIRE AND BE SUBJECTED TO WEAR AND ABRASION.
Consequence & remedy
Consequence: THIS COULD INITIALLY CAUSE SOME BRAKE FLUID LEAKAGE, AND EVENTUALLY LEAD TO A SUBSTANTIAL LOSS OF BRAKE FLUID. THERE COULD BE A NOTICEABLE REDUCTION IN BRAKE PERFORMANCE IF A LOSS OF FRONT BRAKE PERFORMANCE OCCURS.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL RETAINING CLIP TO FURTHER SECURE THE BRAKE LINE TO THE FRONT STRUT. ADDITIONALLY, IF INSPECTION OF ANY BRAKE HOSE INDICATES THAT IT HAS EXPERIENCED DAMAGE, THE HOSE WILL BE REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jul 24, 2002
ON CERTAIN PASSENGER VEHICLES, DUE TO A MANUFACTURING PROBLEM, THE BRAKE PEDAL ARM PIVOT SHAFT COULD LOOSEN FROM ITS SUPPORT BRACKET.
Consequence & remedy
Consequence: EVENTUALLY, THE BRAKE PEDAL ARM COULD DETACH FROM THE BRACKET, RENDERING THE SERVICE BRAKING SYSTEM INEFFECTIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL CHECK THE BRAKE PEDAL ARM PIVOT SHAFT FOR PROPER SEATING IN ITS SUPPORT BRACKET. IN ADDITION, A PIN WILL BE INSTALLED TO SECURE THE SHAFT TO THE BRACKET. OWNER NOTIFICATION BEGAN AUGUST 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-332-4269.
May 16, 2002
ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. THIS IS A SUPPLEMENT TO A RECALL THAT BEGAN DURING SEPTEMBER 2001 (SEE RECALL CAMPAIGN 01V206). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 21, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 14, 2001
VEHICLE DESCRIPTION: 4.4I SPORT UTILITY VEHICLES. OVER AN EXTENDED PERIOD OF TIME, ABRASION PARTICLES COULD DEPOSIT ON THE ELECTRICAL CONTACTS WITHIN THE SWITCH, CAUSING A DISRUPTION OF THE ELECTRIC CURRENT THROUGH THE CONTACTS. IF THE DISRUPTION OCCURS WHEN THE VEHICLE IS STATIONARY WITH THE TRANSMISSION IN THE NEUTRAL OR PARK POSITIONS, THE TRANSMISSION WILL SWITCH AUTOMATICALLY INTO THE EMERGENCY PROGRAM, WHICH IS DISPLAYED IN THE INSTRUMENT CLUSTER VIA A WARNING LAMP AND A MESSAGE, "TRANS. FAIL-SAFE PROG." IN THIS CASE, THE VEHICLE CAN BE DRIVEN IN LOWER GEARS ONLY WITH LIMITED ENGINE OUTPUT.
Consequence & remedy
Consequence: IF THIS PROBLEM OCCURS, THE ABILITY TO MAINTAIN SPEED IN TRAFFIC AND/OR ACCELERATE COULD BE GREATLY DIMINISHED, POSSIBLY LEADING TO A CRASH.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION GEAR POSITION INDICATOR SWITCH. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 14, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DUE TO AN ASSEMBLY ERROR, ONE OR BOTH SELF-LOCKING NUTS THAT SECURE THE PEDAL ASSEMBLY TO THE BOOSTER MAY HAVE BEEN CROSS-THREADED ON THE BOOSTER STUDS THAT PROTRUDE THROUGH THE FIREWALL. IN SUCH A CASE, THE NUT(S) WOULD NOT BE FULLY SEATED ON THE STUD(S).
Consequence & remedy
Consequence: IF THIS OCCURRED, THE EFFECTIVE BRAKE PEDAL TRAVEL COULD BE REDUCED DUE TO RELATIVE MOVEMENT BETWEEN THE PEDAL AND BOOSTER. BRAKING PERFORMANCE WHILE DRIVING COULD BE ADVERSELY AFFECTED. IN ADDITION, IT IS POSSIBLE THAT THE BOOSTER COULD DEVELOP A LEAK AFTER AN EXTENDED PERIOD OF TIME RESULTING IN A REDUCTION IN BRAKE POWER ASSIST.
Remedy: DEALERS WILL INSPECT THE TWO LOCK NUTS TO DETERMINE IF THEY ARE PROPERLY SEATED. IF THE NUTS ARE NOT PROPERLY SEATED OR ARE CROSS-THREADED, THE BRAKE BOOSTER WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
May 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO AN ASSEMBLY ERROR DURING VEHICLE PRODUCTION, ANY OF THE THREE BOLTS THAT SECURE THE PULLEY TO THE PUMP MAY HAVE BEEN INADEQUATELY TIGHTENED.
Consequence & remedy
Consequence: IN SUCH A CASE, THE BOLTS COULD ULTIMATELY LOOSEN CAUSING THE PULLEY TO THROW OFF THE DRIVE BELT. THIS WOULD RESULT IN THE LOSS OF CERTAIN ENGINE AUXILIARY FUNCTIONS, I.E., POWER STEERING ASSIST, WATER PUMP, OR ALTERNATOR. STEERING EFFORT WOULD THEN BE INCREASED.
Remedy: DEALERS WILL INSPECT THE POWER STEERING PUMP PULLEY TO SEE IF IT IS LOOSE. IF THE PULLEY IS NOT LOOSE ON THE PUMP, THE RETAINING BOLTS WILL BE TORQUED TO SPECIFICATION. IF THE PULLEY IS LOOSE, THE PUMP, PULLEY, ATTACHING BOLTS, AND DRIVE BELT WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Feb 6, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING ASSEMBLY OF THESE VEHICLES, THE LOWER END OF THE SPINDLE MAY NOT HAVE BEEN INSERTED COMPLETELY INTO THE COUPLING. IN SUCH A CASE, THE FASTENING BOLT USED TO SECURE THE CONNECTION MAY NOT COMPLETELY ENGAGE THE SPINDLE WITHIN THE COUPLING. DURING DRIVING, IT WOULD BE POSSIBLE FOR THE SPINDLE TO DISCONNECT.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CAPABILITY AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE SPINDLE TO ENSURE PROPER INSERTION IN THE COUPLING, AND, IF NECESSARY, THE SPINDLE WILL BE FULLY INSERTED AND THE FASTENING BOLT REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Oct 24, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE NUT THAT SECURES THE AXIAL JOINT OF THE LEFT STEERING TIE ROD TO THE STEERING GEAR BOX MAY HAVE NOT HAVE BEEN TIGHTENED SECURELY. THIS COULD LEAD TO LOOSENING OF THE NUT AND, INITIALLY TO STEERING WHEEL PLAY AND/OR MISALIGNMENT, AS WELL AS NOISE FROM THE STEERING LINKAGE. IF VEHICLE OPERATION CONTINUES, THE TIE ROD COULD DISCONNECT FROM THE STEERING GEAR BOX.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, LOSS OF STEERING CONTROL COULD RESULT.
Remedy: DEALERS WILL INSPECT AND RE-TORQUE THE NUT SECURING THE AXIAL JOINT OF THE LEFT STEERING TIE ROD. IF THE TORQUE OF THE NUT IS FOUND TO BE LOOSE, THE RIGHT NUT WILL ALSO BE CHECKED AND CORRECTED IF NECESSARY, AND A FRONT WHEEL ALIGNMENT WILL BE PERFORMED.
Sep 11, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SAFETY BELT LOWER OUTBOARD ANCHORAGE BOLT ON THE DRIVER'S AND FRONT PASSENGER'S SEATS MAY NOT HAVE BEEN SECURED PROPERLY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SAFETY BELT SYSTEM MIGHT NOT BE ABLE TO PROVIDE ITS MAXIMUM RESTRAINT FUNCTION.
Remedy: DEALERS WILL INSPECT THE BOLTS AND CORRECT THE TORQUE IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration