NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
24 reportsClear category filter77,900 miles · Nov 28, 2006
Electrical SystemExterior Lighting
DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, ALL EXTERIOR LIGHTS FAILED, AS WELL AS, POWER BRAKES, POWER STEERING AND THE ENGINE. AFTER COASTING TO A STOP, THE CONTACT WAS ABLE TO RESTART THE VEHICLE, AFTER 25 MINUTES, BUT THE VEHICLE WAS IN FAILSAFE MODE FOR THE ENGINE AND THE TRANSMISSION. THE VEHICLE WAS DRIVEN HOME ABOUT …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, ALL EXTERIOR LIGHTS FAILED, AS WELL AS, POWER BRAKES, POWER STEERING AND THE ENGINE. AFTER COASTING TO A STOP, THE CONTACT WAS ABLE TO RESTART THE VEHICLE, AFTER 25 MINUTES, BUT THE VEHICLE WAS IN FAILSAFE MODE FOR THE ENGINE AND THE TRANSMISSION. THE VEHICLE WAS DRIVEN HOME ABOUT A MILE AWAY. THE VEHICLE WAS DRIVEN TO THE SERVICE DEALER FOR SERVICE. THERE WERE NO SYMPTOMS OF THE PREVIOUS NIGHT. THE PROBLEM WAS NOT RECREATED, ALTHOUGH THE IGNITION SWITCH WAS REPLACED. THE MANUFACTURER WAS NOTIFIED AND WAS WILLING TO SEND A TECHNICIAN FOR FURTHER INVESTIGATION.
NHTSA ODI #10174528
78,000 miles · Nov 27, 2006
Electrical System
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON A DARK RURAL ROAD, THE VEHICLE LOST ALL LIGHTS AND POWER. EVENTUALLY THE ENGINE COMPLETELY DIED. AFTER 25 MINUTES, THE VEHICLE WAS RESTARTED, AND WAS TAKEN TO A DEALER WHERE THE IGNITION SWITCH WAS REPLACED. THE PROBLEM WAS THAT THE IGNITION SWITCH WAS REPLACED A YEAR AGO FOR IN…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON A DARK RURAL ROAD, THE VEHICLE LOST ALL LIGHTS AND POWER. EVENTUALLY THE ENGINE COMPLETELY DIED. AFTER 25 MINUTES, THE VEHICLE WAS RESTARTED, AND WAS TAKEN TO A DEALER WHERE THE IGNITION SWITCH WAS REPLACED. THE PROBLEM WAS THAT THE IGNITION SWITCH WAS REPLACED A YEAR AGO FOR INTERMITTENT START PROBLEMS. THE CONTACT'S SPOUSE WAS VERY CONCERNED ABOUT THE SAFETY OF DRIVING THE VEHICLE WITH THE FAMILY.
NHTSA ODI #10174388
78,000 miles · Nov 27, 2006
Electrical System
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON A COUNTRY ROAD AT NIGHT, THERE WAS A LOSS OF THE HEADLIGHTS FOLLOWED BY THE ENGINE STALLING WITHOUT WARNING. THE ENGINE RESTARTED AFTER SEVERAL ATTEMPTS, AND AN EXTENDED PERIOD OF TIME. THERE WERE NO FURTHER INCIDENTS OF HEADLIGHT FAILURE. THE VEHICLE WAS INSPECTED BY A DEALER, …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON A COUNTRY ROAD AT NIGHT, THERE WAS A LOSS OF THE HEADLIGHTS FOLLOWED BY THE ENGINE STALLING WITHOUT WARNING. THE ENGINE RESTARTED AFTER SEVERAL ATTEMPTS, AND AN EXTENDED PERIOD OF TIME. THERE WERE NO FURTHER INCIDENTS OF HEADLIGHT FAILURE. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THE IGNITION SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALERTED.
NHTSA ODI #10174385
40,200 miles · Jun 21, 2006
Electrical System
AT 40K MILES 4.4 X 5 HAD ELECTRICAL FAILURE, ALL DASH LIGHTS AND DIGITAL GAUGES WENT OUT WHEN I TURNED THE CAR ON. DROVE WITH ONLY SPEEDOMETER AND NON DIGITAL GAUGES WORKING. CHECKED FUSES AND CHANGED A FEW BUT COULD NOT GET THEM TO WORK. CHARGED FOR SERVICE TO REPAIR 200. DIGITAL GAUGES ARE STILL NOT ALL LIT. ONLY PARTIAL D…
Read full complaint
AT 40K MILES 4.4 X 5 HAD ELECTRICAL FAILURE, ALL DASH LIGHTS AND DIGITAL GAUGES WENT OUT WHEN I TURNED THE CAR ON. DROVE WITH ONLY SPEEDOMETER AND NON DIGITAL GAUGES WORKING. CHECKED FUSES AND CHANGED A FEW BUT COULD NOT GET THEM TO WORK. CHARGED FOR SERVICE TO REPAIR 200. DIGITAL GAUGES ARE STILL NOT ALL LIT. ONLY PARTIAL DIGITS FOR TIME AND ODOMETER READING. THESE GAUGES SHOULD WORK UNTIL AT LEAST 100,000 MILES ON ANY CAR. I AM CONSIDERING A CLASS ACTION LAW SUIT AS I FEEL ROBBED AND CHEATED TO BY BMW ALONG WITH MANY OTHERS. *JB
NHTSA ODI #10160316
63,200 miles · Sep 1, 2005
Electrical SystemExterior LightingLatches/locks/linkages
1. HAD CAR SERVICED AT 60,000 MILES, ONLY 3 WEEKS LATER THE GREEN DASHES STARTED APPEARING AGAIN AND STAYING ON, AS IF I NEEDED TO HAVE CAR SERVICED. CALLED DEALER AND THEY SAID NOT TO WORRY, THIS HAS BEEN KNOW TO HAPPEN, JUST IGNORE IT. 2. VERY LOUD NOISE FROM SUN ROOF (CLOSED) WHILE TRAVELING ON FREEWAY AND LEAKS DURING C…
Read full complaint
1. HAD CAR SERVICED AT 60,000 MILES, ONLY 3 WEEKS LATER THE GREEN DASHES STARTED APPEARING AGAIN AND STAYING ON, AS IF I NEEDED TO HAVE CAR SERVICED. CALLED DEALER AND THEY SAID NOT TO WORRY, THIS HAS BEEN KNOW TO HAPPEN, JUST IGNORE IT. 2. VERY LOUD NOISE FROM SUN ROOF (CLOSED) WHILE TRAVELING ON FREEWAY AND LEAKS DURING CAR WASHES? DEALER SAID THEY CAN REPLACE THE SEAL AND THIS SHOULD FIX THE PROBLEM. 3. BRAKE LIGHT INDICATOR ON DASH COMES ON AND OFF, AS IF BULB IS OUT, BUT JUST REPLACED BULB, THEN REPLACED AGAIN, SOMETIMES THIS BRAKE LIGHT WORKS AND SOMETIMES IT DOESN'T. 4. WINDOW ON FRONT PASSENGER WINDOW WOULD NOT GO BACK UP AFTER OPENED, THEN A DAY LATER, THE DOOR WOULD NOT OPEN OR CLOSE. DEALER REPLACED THE WINDOW MECHANISM THAT CONTROLS BOTH THE DOOR HANDLE AND THE WINDOW AT MY COST MIND YOU THE REAR WINDOW AND DOOR HAD BEEN DONE ONLY A YEAR BEFORE. THE DEALER TOLD ME THAT THIS HAPPENS ON ALL GERMAN CARS, DOESN'T MATTER THE AGE OF CAR OR MAKE. HOW FRUSTRATING - SPEND $45,000 AND KNOW WINDOWS WILL EVENTUALLY QUIT WORKING?? 5. FRONT RIGHT HEADLAMP GETS MOISTURE IN IT AND IT TAKES 3-5 DAYS TO CLEAR UP. 6. DRIVER CUP HOLDERS, WHAT IS UP WITH THAT - CAN ONLY PUT ONE CUP IN IT, WHEN TRY TO PUT 2 IN, THEY OVERLAP, VERY FRUSTRATING WHEN DRIVING. 7. STORAGE IN FRONT MINIMAL AND A HASSLE, YOU HAVE TO REACH BACK AND SORT OF BEHIND YOU TO GET INTO COMPARTMENT - DANGEROUS WHILE DRIVING. 8. LEATHER SEATS ARE VERY HARD, NEED A PLUSHIER LEATHER. 9. WHEELS, BRAKE "DUST" GETS ALL OVER THE WHEELS MUCH MUCH MORE THAN ANY OTHER LUXURY CAR I HAVE EVER HAD. 10. CARGO COVER IN REAR NEEDS WORK, CHECK OUT THE ONE LEXUS USES IN RX30. 11. NEED MORE CARGO SPACE - COMPARED TO RX330 AND THE VOLVO X90, SPACE IS EXTREMELY SMALL. 12. DISAPPOINTED IN MY CAR - WANT TO SELL IT, WILL NOT BUY ANOTHER BMW. *NM
NHTSA ODI #10135032
72,000 miles · Aug 3, 2005
Electrical SystemFire
DT: CONTACT STATD BMW X5 2001 CAUGHT ON FIRE ON JULY 21, 2005. THE TEMPERATURE GAUGE WAS AT HOT, THE CAR STARTED TO LOSE POWER, THE TACHOMETER WAS OVER 4 AND WHITE SMOKE STARTED TO COME OUT OF THE ENGINE AREA WHILE HE WAS DRIVING THE CAR ON THE HIGHWAY GOING APPROX. 30 MPH. AS THE SMOKE GOT WORSE, HE PULLED OFF AND THE SMOKE BE…
Read full complaint
DT: CONTACT STATD BMW X5 2001 CAUGHT ON FIRE ON JULY 21, 2005. THE TEMPERATURE GAUGE WAS AT HOT, THE CAR STARTED TO LOSE POWER, THE TACHOMETER WAS OVER 4 AND WHITE SMOKE STARTED TO COME OUT OF THE ENGINE AREA WHILE HE WAS DRIVING THE CAR ON THE HIGHWAY GOING APPROX. 30 MPH. AS THE SMOKE GOT WORSE, HE PULLED OFF AND THE SMOKE BECAME VERY WHITE AND DENSE AND THEN IGNITED INTO A FIRE. THE FIRE DEPT. DID COME OUT. THE FIRE DID ORIGINATE FROM UNDER THE HOOD. PRIOR TO THIS HE HAD NO PROBLEMS WITH THE CAR HEATING UP. THE CAR WAS TOTALED. *AK
NHTSA ODI #10131387
820,136 miles · Jun 7, 2005
Electrical SystemFuel System, Other
AFTER EXPERIENCING PREVIOUS HESITATION WHEN ACCELERATING AND AFTER DEALER INSPECTION, NO FAULTS WERE FOUND AND NO CORRECTIVE ACTION WAS TAKEN BY THE BMW DEALER. WHILE DRIVING ON A HIGH SPEED EXPRESSWAY, THE X5 SUDDENLY AND WITHOUT WARNING SHUT DOWN ALL SYSTEMS AND ALL WARNING LIGHTS CAME ON. AFTER FINALLY GETTING OFF THE ROAD, T…
Read full complaint
AFTER EXPERIENCING PREVIOUS HESITATION WHEN ACCELERATING AND AFTER DEALER INSPECTION, NO FAULTS WERE FOUND AND NO CORRECTIVE ACTION WAS TAKEN BY THE BMW DEALER. WHILE DRIVING ON A HIGH SPEED EXPRESSWAY, THE X5 SUDDENLY AND WITHOUT WARNING SHUT DOWN ALL SYSTEMS AND ALL WARNING LIGHTS CAME ON. AFTER FINALLY GETTING OFF THE ROAD, THE CAR WAS TOWED TO MY HOME. THE NEXT DAY, THE CAR WAS ABLE TO START AND, ALTHOUGH THE CAR WAS NOT ABLE TO GO OVER 30 MPH, I DROVE TO MY BMW DEALER. THE SERVICE TECHNICIAN DIAGNOSED THE PROBLEM QUICKLY AND INFORMED ME THAT A SERVICE BULLETIN WAS ISSUED IN AUGUST, 2003 ON THIS PROBLEM. THE ENTIRE WIRING HARNESS AND THROTTLE HAD TO BE REPLACED AND BECAUSE THE CAR WAS OUT OF WARRANTY, BMW ASSUMED NONE OF THE COST WHICH WAS ABOUT $1,200.00. I BELIEVE THAT OWNERS SHOULD HAVE BEEN NOTIFIED OF THIS PROBLEM WHEN IT WAS RECOGNIZED BY BMW. THE SERVICE BULLETIN STATED THAT THE PROBLEM SHOULD ONLY BE CORRECTED "UPON A CUSTOMER'S COMPLAINT" WHICH I BELIEVE IS TOTALLY IRRESPONSIBLE AND JEOPARDIZES THE SAFETY OF OCCUPANTS.
NHTSA ODI #10124417
530,000 miles · Dec 2, 2004
Electrical SystemLatches/locks/linkages
FAILURE OF PASSENGER DOOR WIRING HARNESS, CONNECTIONS WERE CORRODED, CAUSING THE DOOR TO STOP FUNCTIONING I.E. DOOR OPENING, DOOR LOCK, WINDOW WOULD NOT WORK. THE DOOR HAD PREVIOUSLY BEEN REPAIRED FOR A BROKEN DOOR LOCK HANDLE. THERE WERE 3-X5'S AT THE SHOP WITH SAME PROBLEM THAT WEEK.*AK
NHTSA ODI #10100924
Mileage unknown · Aug 8, 2003
Electrical SystemFire
CONSUMER STATED HER VEHICLE HAS CAUGHT FIRE TWICE, AND IT LOCKED HER INSIDE. SHE ALSO STATED THAT HER AUX. FAN WAS THE CAUSE OF THE FIRES. SHE STATED THE FAN WAS CHANGED 4 TIMES. IT WAS TOLD TO HER AND HER HUSBAND THAT THESE WERE ELECTRICAL FIRES. SHE STATED THAT SHE HAD AN APPOINTMENT WITH THE CUSTOMER SVC REP OF BMW, AND …
Read full complaint
CONSUMER STATED HER VEHICLE HAS CAUGHT FIRE TWICE, AND IT LOCKED HER INSIDE. SHE ALSO STATED THAT HER AUX. FAN WAS THE CAUSE OF THE FIRES. SHE STATED THE FAN WAS CHANGED 4 TIMES. IT WAS TOLD TO HER AND HER HUSBAND THAT THESE WERE ELECTRICAL FIRES. SHE STATED THAT SHE HAD AN APPOINTMENT WITH THE CUSTOMER SVC REP OF BMW, AND THEIR SVC REP THE FOLLOWING WEEK TO TRY TO FIX HER VEHICLE. *PH
NHTSA ODI #10032520
3,000 miles · Jul 12, 2003
Electrical System
ELECTRICAL PROBLEMS. SUCH AS RIGHT REAR BRAKE LIGHT KEEPS GOING OUT AND VEHICLE BRAKES FEEL LIKE THIER NOT STOPPING, LEFT TURN SIGNAL FAST, STEERING WHEEL DOESN'T EXTEND FULLY, DURING WINTER MONTHS THE FRONT AND REAR THERMOSTAT DO NOT WORK. DOOR HANDLES FREEZES. *AK
NHTSA ODI #10025940
Official recalls
12Oct 31, 2025
BMW of North America, LLC (BMW) is recalling certain 2000-2001 X5 vehicles that may be equipped with a sport steering wheel containing a Takata PSDI-4 air bag inflator. The inflator may explode during deployment due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature, and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is complete. Dealers will inspect and replace the driver's front air bag, as necessary, free of charge. Owner notification letters were mailed December 29, 2025. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 23, 2025. This recall expands previous NHTSA recall number 19V015.
Jan 20, 2017
BMW of North America, LLC (BMW) is recalling certain 2000-2002 BMW 320i, 323i, 325i, 325xi, 330i, 330xi, 323Ci, 325Ci, 330Ci, M3, 323iT, 325iT and 325xiT vehicles, 2001-2002 525i, 530i, 540i, M5, 525iT and 540iT vehicles, and 2001-2003 X5 3.0i, X5 4.4i, and X5 4.6is vehicles. These vehicles may have had a driver-side air bag module installed as replacement equipment such as after a vehicle crash necessitating replacement of the original air bag, or as a remedy part for a prior recall. These replacement modules contain an air bag inflator that may rupture due to propellant degradation occurring after long-term exposure to lower absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the vehicle has been remedied. BMW will notify owners, and dealers will inspect the driver side air bag module, replacing it as necessary, free of charge. The recall began March 15, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Jan 9, 2003
ON CERTAIN SPORT UTILITY VEHICLES, IT MAY BE POSSIBLE FOR THE FRONT BRAKE LINE TO SLIP OUT OF THE RETAINING BRACKET LOCATED AT THE FRONT STRUT. THE BRAKE HOSE THAT IS ATTACHED TO THE BRAKE LINE COULD COME IN CONTACT WITH THE TIRE AND BE SUBJECTED TO WEAR AND ABRASION.
Consequence & remedy
Consequence: THIS COULD INITIALLY CAUSE SOME BRAKE FLUID LEAKAGE, AND EVENTUALLY LEAD TO A SUBSTANTIAL LOSS OF BRAKE FLUID. THERE COULD BE A NOTICEABLE REDUCTION IN BRAKE PERFORMANCE IF A LOSS OF FRONT BRAKE PERFORMANCE OCCURS.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL RETAINING CLIP TO FURTHER SECURE THE BRAKE LINE TO THE FRONT STRUT. ADDITIONALLY, IF INSPECTION OF ANY BRAKE HOSE INDICATES THAT IT HAS EXPERIENCED DAMAGE, THE HOSE WILL BE REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jul 24, 2002
ON CERTAIN PASSENGER VEHICLES, DUE TO A MANUFACTURING PROBLEM, THE BRAKE PEDAL ARM PIVOT SHAFT COULD LOOSEN FROM ITS SUPPORT BRACKET.
Consequence & remedy
Consequence: EVENTUALLY, THE BRAKE PEDAL ARM COULD DETACH FROM THE BRACKET, RENDERING THE SERVICE BRAKING SYSTEM INEFFECTIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL CHECK THE BRAKE PEDAL ARM PIVOT SHAFT FOR PROPER SEATING IN ITS SUPPORT BRACKET. IN ADDITION, A PIN WILL BE INSTALLED TO SECURE THE SHAFT TO THE BRACKET. OWNER NOTIFICATION BEGAN AUGUST 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-332-4269.
May 16, 2002
ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. THIS IS A SUPPLEMENT TO A RECALL THAT BEGAN DURING SEPTEMBER 2001 (SEE RECALL CAMPAIGN 01V206). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 21, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 14, 2001
VEHICLE DESCRIPTION: 4.4I SPORT UTILITY VEHICLES. OVER AN EXTENDED PERIOD OF TIME, ABRASION PARTICLES COULD DEPOSIT ON THE ELECTRICAL CONTACTS WITHIN THE SWITCH, CAUSING A DISRUPTION OF THE ELECTRIC CURRENT THROUGH THE CONTACTS. IF THE DISRUPTION OCCURS WHEN THE VEHICLE IS STATIONARY WITH THE TRANSMISSION IN THE NEUTRAL OR PARK POSITIONS, THE TRANSMISSION WILL SWITCH AUTOMATICALLY INTO THE EMERGENCY PROGRAM, WHICH IS DISPLAYED IN THE INSTRUMENT CLUSTER VIA A WARNING LAMP AND A MESSAGE, "TRANS. FAIL-SAFE PROG." IN THIS CASE, THE VEHICLE CAN BE DRIVEN IN LOWER GEARS ONLY WITH LIMITED ENGINE OUTPUT.
Consequence & remedy
Consequence: IF THIS PROBLEM OCCURS, THE ABILITY TO MAINTAIN SPEED IN TRAFFIC AND/OR ACCELERATE COULD BE GREATLY DIMINISHED, POSSIBLY LEADING TO A CRASH.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION GEAR POSITION INDICATOR SWITCH. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Jun 14, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. DUE TO AN ASSEMBLY ERROR, ONE OR BOTH SELF-LOCKING NUTS THAT SECURE THE PEDAL ASSEMBLY TO THE BOOSTER MAY HAVE BEEN CROSS-THREADED ON THE BOOSTER STUDS THAT PROTRUDE THROUGH THE FIREWALL. IN SUCH A CASE, THE NUT(S) WOULD NOT BE FULLY SEATED ON THE STUD(S).
Consequence & remedy
Consequence: IF THIS OCCURRED, THE EFFECTIVE BRAKE PEDAL TRAVEL COULD BE REDUCED DUE TO RELATIVE MOVEMENT BETWEEN THE PEDAL AND BOOSTER. BRAKING PERFORMANCE WHILE DRIVING COULD BE ADVERSELY AFFECTED. IN ADDITION, IT IS POSSIBLE THAT THE BOOSTER COULD DEVELOP A LEAK AFTER AN EXTENDED PERIOD OF TIME RESULTING IN A REDUCTION IN BRAKE POWER ASSIST.
Remedy: DEALERS WILL INSPECT THE TWO LOCK NUTS TO DETERMINE IF THEY ARE PROPERLY SEATED. IF THE NUTS ARE NOT PROPERLY SEATED OR ARE CROSS-THREADED, THE BRAKE BOOSTER WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
May 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO AN ASSEMBLY ERROR DURING VEHICLE PRODUCTION, ANY OF THE THREE BOLTS THAT SECURE THE PULLEY TO THE PUMP MAY HAVE BEEN INADEQUATELY TIGHTENED.
Consequence & remedy
Consequence: IN SUCH A CASE, THE BOLTS COULD ULTIMATELY LOOSEN CAUSING THE PULLEY TO THROW OFF THE DRIVE BELT. THIS WOULD RESULT IN THE LOSS OF CERTAIN ENGINE AUXILIARY FUNCTIONS, I.E., POWER STEERING ASSIST, WATER PUMP, OR ALTERNATOR. STEERING EFFORT WOULD THEN BE INCREASED.
Remedy: DEALERS WILL INSPECT THE POWER STEERING PUMP PULLEY TO SEE IF IT IS LOOSE. IF THE PULLEY IS NOT LOOSE ON THE PUMP, THE RETAINING BOLTS WILL BE TORQUED TO SPECIFICATION. IF THE PULLEY IS LOOSE, THE PUMP, PULLEY, ATTACHING BOLTS, AND DRIVE BELT WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Feb 6, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING ASSEMBLY OF THESE VEHICLES, THE LOWER END OF THE SPINDLE MAY NOT HAVE BEEN INSERTED COMPLETELY INTO THE COUPLING. IN SUCH A CASE, THE FASTENING BOLT USED TO SECURE THE CONNECTION MAY NOT COMPLETELY ENGAGE THE SPINDLE WITHIN THE COUPLING. DURING DRIVING, IT WOULD BE POSSIBLE FOR THE SPINDLE TO DISCONNECT.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF STEERING CAPABILITY AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE SPINDLE TO ENSURE PROPER INSERTION IN THE COUPLING, AND, IF NECESSARY, THE SPINDLE WILL BE FULLY INSERTED AND THE FASTENING BOLT REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Oct 24, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE NUT THAT SECURES THE AXIAL JOINT OF THE LEFT STEERING TIE ROD TO THE STEERING GEAR BOX MAY HAVE NOT HAVE BEEN TIGHTENED SECURELY. THIS COULD LEAD TO LOOSENING OF THE NUT AND, INITIALLY TO STEERING WHEEL PLAY AND/OR MISALIGNMENT, AS WELL AS NOISE FROM THE STEERING LINKAGE. IF VEHICLE OPERATION CONTINUES, THE TIE ROD COULD DISCONNECT FROM THE STEERING GEAR BOX.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, LOSS OF STEERING CONTROL COULD RESULT.
Remedy: DEALERS WILL INSPECT AND RE-TORQUE THE NUT SECURING THE AXIAL JOINT OF THE LEFT STEERING TIE ROD. IF THE TORQUE OF THE NUT IS FOUND TO BE LOOSE, THE RIGHT NUT WILL ALSO BE CHECKED AND CORRECTED IF NECESSARY, AND A FRONT WHEEL ALIGNMENT WILL BE PERFORMED.
Sep 11, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SAFETY BELT LOWER OUTBOARD ANCHORAGE BOLT ON THE DRIVER'S AND FRONT PASSENGER'S SEATS MAY NOT HAVE BEEN SECURED PROPERLY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SAFETY BELT SYSTEM MIGHT NOT BE ABLE TO PROVIDE ITS MAXIMUM RESTRAINT FUNCTION.
Remedy: DEALERS WILL INSPECT THE BOLTS AND CORRECT THE TORQUE IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration