IllustrationHEATED SEAT CAUGHT FIRE, BURNING THROUGH THICK LEATHER UPHOLSTERY. 2005 BMW X3, 36,000 MILES. NOT REPAIRED, OUT OF WARRANTY, BMW ONLY WILLING TO PAY FOR HALF OF REPLACEMENT, CONSUMER COST 700 DOLLARS. *TR
2005 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1325–50K
1650–75K
2275–100K
26100–150K
9150K+
93 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports18 fire reports17 injury reports
What owners actually said
103 reportsHATCH BACK IS LEAKING WATER INTO THE HATCHBACK OF X3. WATER LEAKAGE IN FRONT OF CAR FROM HOOD INTO BILATERAL SIDES OF DASH BOARD WHICH DAMAGED CARPET AND BELONGINGS. *TR
TL*THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THEY HAD TO REPLACE THE WATER HOSE THREE TIMES SINCE PURCHASING THE VEHICLE. THE DEALER REPLACED THE HOSES BUT THEY CONTINUED TO BURST. THE CONTACT WAS CONCERNED ABOUT THE DAMAGE BEING DONE TO THE ENGINE WHEN THE FAILURE OCCURRED. THE FAILURE MILEAGE WAS APPROXIMATELY 10…
Read full complaint
TL*THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THEY HAD TO REPLACE THE WATER HOSE THREE TIMES SINCE PURCHASING THE VEHICLE. THE DEALER REPLACED THE HOSES BUT THEY CONTINUED TO BURST. THE CONTACT WAS CONCERNED ABOUT THE DAMAGE BEING DONE TO THE ENGINE WHEN THE FAILURE OCCURRED. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 67,000.
WATER LEAVING IN THE REAR PASSENGER SIDE. *TR
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THE VEHICLE EXHIBITED AN ELECTRICAL SHORTAGE AND WAS TAKEN TO THE DEALER. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE BUT DID ADVISED THAT THE SUN ROOF EXHIBITED A LEAK AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THE VEHICLE EXHIBITED AN ELECTRICAL SHORTAGE AND WAS TAKEN TO THE DEALER. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE BUT DID ADVISED THAT THE SUN ROOF EXHIBITED A LEAK AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 51,000
I WAS IN A UNSAFE AREA SO I LOCKED THE DOORS AN CLOSED ALL THE WINDOWS WITH MY KEYS INSIDE WITH ME TO WAIT FOR MY HUSBAND TO RETURN. WHEN HE RETURNED A FEW MINTUES LATER I COULD NOT OPEN THE CAR TO LET HIM IN. I WAS LOCKED INSIDE MY CAR WITH KEYS IN HAND. POWER WINDOWS WOULD NOT OPEN,SUNROOF WOULD NOT OPEN, DOOR LOCKS WOULD NO…
Read full complaint
I WAS IN A UNSAFE AREA SO I LOCKED THE DOORS AN CLOSED ALL THE WINDOWS WITH MY KEYS INSIDE WITH ME TO WAIT FOR MY HUSBAND TO RETURN. WHEN HE RETURNED A FEW MINTUES LATER I COULD NOT OPEN THE CAR TO LET HIM IN. I WAS LOCKED INSIDE MY CAR WITH KEYS IN HAND. POWER WINDOWS WOULD NOT OPEN,SUNROOF WOULD NOT OPEN, DOOR LOCKS WOULD NOT OPEN. THE CAR WOULD NOT MANUALLY OPEN EVEN WHEN TRIED ON ALL DOORS MANY TIMES USING THE "2 PULL" METHOD. I COULD DRIVE THE CAR AND DROVE TO THE DEALER WHERE I BOUGHT IT AT. THEY COULD NOT FIGURE OUT HOW TO UNLOCK THE CAR AND THEY HAD ME CRAWL TO THE BACK HATCH TO TRY TO USE A RELEASE BUT THERE WAS NONE. I HAD BEEN IN THE CAR A FEW HOURS AAT THIS POINT AND BEGAN TO FEEL PANICKED. AT THAT POINT THEY HAD TO BREAK A WINDOW TO GET ME OUT. THE CAR IS STILL AT DEALER AND I WAS TOLD THEY ARE LOOKING INTO WHY AND NO RESPONSE IS YET AS TO WHY THE MANUAL UNLOCK WOULD NOT WORK WHEN ALL THE ELECTRIC STOPPED WORKING. I HAD PAID FOR A EXTRA WARRENTY ON THE CAR AND IT IS CURRENTLY COVERED.
TL*THE CONTACT OWNS A 2005 BMW X3. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH ON NORMAL ROAD CONDITIONS. THE DRIVER SIDE HEATED SEAT WAS ACTIVATED. SUDDENLY, AN UNEXPECTED EXCESSIVE HIGH VOLTAGE OF HEAT PENETRATED THROUGH THE BOTTOM OF THE SEAT. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND DEACTIVATED THE HEATED SEAT …
Read full complaint
TL*THE CONTACT OWNS A 2005 BMW X3. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH ON NORMAL ROAD CONDITIONS. THE DRIVER SIDE HEATED SEAT WAS ACTIVATED. SUDDENLY, AN UNEXPECTED EXCESSIVE HIGH VOLTAGE OF HEAT PENETRATED THROUGH THE BOTTOM OF THE SEAT. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND DEACTIVATED THE HEATED SEAT SYSTEM. THE DRIVER SUSTAINED A MINOR BURN TO THE LEFT LEG AND THE DRIVER SEAT COVER EXHIBITED A BURN MARK. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATION. THE DEALER WAS NOTIFIED OF THE MALFUNCTION. THERE WAS CONCERN OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 31,000.
MY DRIVERS SEAT BURNED A HOLE THROUGH THE LEATHER AND SINGED MY PANTS. ALMOST CAUGHT ON FIRE AND I ALMOST LOST CONTROL OF MY VEHICLE. THE CAR FILLED WITH SMOKE AND I NOW HAVE A PEA SIZED HOLE IN MY SEAT. THE HEATING ELEMENT APPARENTLY HAS SHORTED OUT INSIDE THE SEAT. I READ THERE HAVE BEEN OTHER OCCURRENCES OF THIS ON THESE …
Read full complaint
MY DRIVERS SEAT BURNED A HOLE THROUGH THE LEATHER AND SINGED MY PANTS. ALMOST CAUGHT ON FIRE AND I ALMOST LOST CONTROL OF MY VEHICLE. THE CAR FILLED WITH SMOKE AND I NOW HAVE A PEA SIZED HOLE IN MY SEAT. THE HEATING ELEMENT APPARENTLY HAS SHORTED OUT INSIDE THE SEAT. I READ THERE HAVE BEEN OTHER OCCURRENCES OF THIS ON THESE VEHICLES ON SOME OF THE WEBSITES BUT THERE IS NO RECALL OUT, BUT THERE SHOULD BE. THIS IS EXTREMELY DANGEROUS. OCCURRED ON 12/31/2009 ON MY BMX X3 2005. I CALLED THE DEALER AND THEY SAID THE SEAT WOULD NEED TO BE REPLACED AT MY COST OF $1500. *TR
TL*THE CONTACT OWNS A 2005 BMW X3. HE STATED THAT THE AIR BAG LIGHT CAME ON AND CAUSED THE AIR BAG SYSTEM TO MALFUNCTION. THE DEALER CONFIRMED THAT NHTSA CAMPAIGN ID NUMBER: 08V384000 COMPONENT: AIR BAGS FRONTAL WERE RELATED TO THE FAILURE; HOWEVER, HIS VIN WAS NOT INCLUDED. THE CONTACT WAS QUOTED $1100 BY THE DEALER TO REPAIR …
Read full complaint
TL*THE CONTACT OWNS A 2005 BMW X3. HE STATED THAT THE AIR BAG LIGHT CAME ON AND CAUSED THE AIR BAG SYSTEM TO MALFUNCTION. THE DEALER CONFIRMED THAT NHTSA CAMPAIGN ID NUMBER: 08V384000 COMPONENT: AIR BAGS FRONTAL WERE RELATED TO THE FAILURE; HOWEVER, HIS VIN WAS NOT INCLUDED. THE CONTACT WAS QUOTED $1100 BY THE DEALER TO REPAIR THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WILL NOT BE REPAIRED. THE FAILURE MILEAGE WAS 64000 AND CURRENT MILEAGE WAS 64989.
BMW X3 2005. PURCHASED LAST DECEMBER WITH 43,115 MILES. CURRENTLY HAS 48,000+. CAR HAS BEEN IN SHOP FOUR TIMES FOR INTERIOR OF CAR BEING WET. LAST VISIT TO MECHANIC WAS LAST WEEK AND IT IS WET INSIDE AGAIN. MECHANIC HAS CHECKED AND CLEANED DRAINAGE TUBES. HAS CHECKED SUNROOF. HAS NOT FOUND A SPECIFIC MECHANICAL REASON FOR…
Read full complaint
BMW X3 2005. PURCHASED LAST DECEMBER WITH 43,115 MILES. CURRENTLY HAS 48,000+. CAR HAS BEEN IN SHOP FOUR TIMES FOR INTERIOR OF CAR BEING WET. LAST VISIT TO MECHANIC WAS LAST WEEK AND IT IS WET INSIDE AGAIN. MECHANIC HAS CHECKED AND CLEANED DRAINAGE TUBES. HAS CHECKED SUNROOF. HAS NOT FOUND A SPECIFIC MECHANICAL REASON FOR THE LEAKING. *TR
Official recalls
108V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).