Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1325–50K
1650–75K
2275–100K
26100–150K
9150K+
93 reports with mileage · 10 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Seats. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports18 fire reports17 injury reports
What owners actually said
103 reports
85,000 miles · Dec 29, 2011
Seats
MY WIFE'S HEATED DRIVER SEAT BURNED A HOLE IN THE VINYL SEAT COVER AND THROUGH HER SWEATER. DEALER SAYS THIS IS NOT COVERED BY WARRANTY, BUT IT APPEARS TO BE A COMMON PROBLEM FOR THE X3. AN INTERNET SEARCH REVEALS SEVERAL COMPLAINTS. ADDITIONALLY, A RECALL WAS ANNOUNCED FOR THE BMW 5 AND 3 SERIES FOR THE SAME ISSUE. I HOPE THE…
Read full complaint
MY WIFE'S HEATED DRIVER SEAT BURNED A HOLE IN THE VINYL SEAT COVER AND THROUGH HER SWEATER. DEALER SAYS THIS IS NOT COVERED BY WARRANTY, BUT IT APPEARS TO BE A COMMON PROBLEM FOR THE X3. AN INTERNET SEARCH REVEALS SEVERAL COMPLAINTS. ADDITIONALLY, A RECALL WAS ANNOUNCED FOR THE BMW 5 AND 3 SERIES FOR THE SAME ISSUE. I HOPE THE NTSB CONDUCTS A QUICK RESPONSE. THANKS. *KB
NHTSA ODI #10441618
78,000 miles · Dec 28, 2011
Seats
A DRIVER SIDE SEAT HEATER OVERHEATED THE SEAT AND BURNED THROUGH LEAVING A HOLE. THIS HAPPENED WHILE I WAS DRIVING AND CAUSED ME TO STEP ACCELERATOR MISTAKENLY. THIS IS A SERIOUS SAFETY ISSUE AND BMW NEEDS TO RECALL ALL DEFECTED PARTS. *TR
NHTSA ODI #10441427
70,500 miles · Dec 11, 2011
SeatsFire
I HAVE A 2005 X3! THIS MORNING MY DRIVER SIDE SEAT NEARLY WENT UP IN FLAMES!! SO SCARY!! LUCKY I WASN'T IN TRAFFIC OR ON THE HIGHWAY, I WAS ABLE TO JUMP OUT AND ADDRESS THE PROBLEM. IS THERE A RECALL NUMBER FOR THE HEATED SEATS YET? I HAVE SEEN ALLOT OF ISSUES WITH THE BMW 04-08 X3 HEATED SEATS. MOST PEOPLE ARE GETTING BURNT AND…
Read full complaint
I HAVE A 2005 X3! THIS MORNING MY DRIVER SIDE SEAT NEARLY WENT UP IN FLAMES!! SO SCARY!! LUCKY I WASN'T IN TRAFFIC OR ON THE HIGHWAY, I WAS ABLE TO JUMP OUT AND ADDRESS THE PROBLEM. IS THERE A RECALL NUMBER FOR THE HEATED SEATS YET? I HAVE SEEN ALLOT OF ISSUES WITH THE BMW 04-08 X3 HEATED SEATS. MOST PEOPLE ARE GETTING BURNT AND THIS COULD BE VERY DANGEROUS FOR US OWNER WHILE DRIVING. SOMETHING NEED TO BE DONE, LUCKY IT WAS ME DRIVING AND NOT MY WIFE. THANK YOU *TR
NHTSA ODI #10439333
83,869 miles · Dec 5, 2011
Electrical SystemSeatsFire
SEAT WARMER CAUGHT ON FIRE! WHILE PARKED IN THE DRIVEWAY WITH THE ENGINE RUNNING, I TURNED ON BOTH MANUFACTURER-INSTALLED FRONT SEAT WARMERS (OUTSIDE TEMP. 36 DEGREES FARENHEIT) FOR MY SON AND I. I FELT A PINCHING ON UPPER LEFT THIGH / BUTTOCK. THOUGHT IT WAS A BUG. SHIFTED IN THE SEAT, AND FELT IT AGAIN, MORE PAINFUL THIS TIME.…
Read full complaint
SEAT WARMER CAUGHT ON FIRE! WHILE PARKED IN THE DRIVEWAY WITH THE ENGINE RUNNING, I TURNED ON BOTH MANUFACTURER-INSTALLED FRONT SEAT WARMERS (OUTSIDE TEMP. 36 DEGREES FARENHEIT) FOR MY SON AND I. I FELT A PINCHING ON UPPER LEFT THIGH / BUTTOCK. THOUGHT IT WAS A BUG. SHIFTED IN THE SEAT, AND FELT IT AGAIN, MORE PAINFUL THIS TIME. LIFTED MYSELF FROM THE SEAT A BIT TO LOOK AT THE SEAT AND SEE WHAT WAS POKING OR PINCHING ME, SAW SMOKE COMING OUT OF A NEW HOLE ON THE LEFT SIDE OF THE SEAT. LOOKED THROUGH THE HOLE, AND SAW FLAMES AND SMELLED BURNING. IMMEDIATELY, TURNED OFF THE SEAT WARMER, GOT OUT OF THE VEHICLE, REACHED OVER AND TURNED OFF THE VEHICLE. THE SEAT SMOLDERED FOR ANOTHER COUPLE OF MINUTES. CALLED MY SPOUSE TO CHECK IF IT WAS STILL SMOLDERING, BUT IT HAD STOPPED. TOOK THE VEHICLE TO THE DEALER TO GET IT CHECKED OUT.
NHTSA ODI #10438587
68,000 miles · Nov 23, 2011
Electrical SystemSeatsFire
HEATED DRIVERS SEAT BURNED THROUGH LEATHER AND SCORCHED DRIVERS PANTS. *TR
NHTSA ODI #10436835
70,000 miles · Jul 14, 2011
Air Bags
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE FRONT PASSENGER AIR BAG LIGHT WOULD CONSTANTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 70,…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW X3. THE CONTACT STATED THAT THE FRONT PASSENGER AIR BAG LIGHT WOULD CONSTANTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10412277
35,000 miles · Jul 6, 2011
Air BagsUnknown Or Other
AIRBAG WARNING LIGHT ILLUMINATED AND WILL NOT TURN OFF. BMW DIAGNOSED PROBLEM AS FAILURE OF PASSENGER SEAT MAT SENSOR. NOW PASSENGER AIRBAG STATUS LAMP WILL NOT TURN OFF.
NHTSA ODI #10411268
41,500 miles · Mar 13, 2011
Engine And Engine Cooling
ON DECEMBER 26TH, 2010 MY DAUGHTER WAS DRIVING OUR 2005 BMW X3 WHEN IT STOPPED IN THE MIDDLE OF A STREET ABOUT A BLOCK FROM OUR HOUSE. THERE WAS A LOT OF SMOKE AND FOR A MOMENT SHE THOUGHT THAT THE VEHICLE WAS ON FIRE. WE GOT IT TOWED TO A LOCAL SERVICE STATION THAT DIAGNOSED THE PROBLEM AS HYDRO-LOCKING. THEY CLEANED IT UP BUT …
Read full complaint
ON DECEMBER 26TH, 2010 MY DAUGHTER WAS DRIVING OUR 2005 BMW X3 WHEN IT STOPPED IN THE MIDDLE OF A STREET ABOUT A BLOCK FROM OUR HOUSE. THERE WAS A LOT OF SMOKE AND FOR A MOMENT SHE THOUGHT THAT THE VEHICLE WAS ON FIRE. WE GOT IT TOWED TO A LOCAL SERVICE STATION THAT DIAGNOSED THE PROBLEM AS HYDRO-LOCKING. THEY CLEANED IT UP BUT DID NOT HAVE A FIX FOR THE PROBLEM. I CALLED MOTORWERKS BMW IN MINNEAPOLIS AND EXPLAINED THE PROBLEM AND WAS TOLD I WILL GET A CALL BACK. I DIDN'T HEAR BACK AND CALLED AGAIN AFTER A COUPLE OF DAYS. I WAS ASKED TO BRING IT TO THE DEALERSHIP AND THE EARLIEST APPOINTMENT WAS JANUARY 24TH, 2011. ON JANUARY 20, 2011, MY WIFE WAS DRIVING THE SAME VEHICLE HOME FROM WORK AT 11:30 PM WHEN IT STOPPED IN THE MIDDLE OF A BUSY AND DANGEROUS INTERSECTION IN FARGO, NORTH DAKOTA. THE TEMPERATURE OUTSIDE WAS -22F. SHE MUST HAVE DRIVEN THE CAR ABOUT 2 MILES WHEN SHE SAW A HUGE WHITE SMOKE COMING OUT OF TAIL PIPE AND WITHIN A FEW MINUTES THE VEHICLE COMPLETELY STOPPED. WE GOT IT TOWED TO THE SAME SERVICE STATION AS BEFORE AND CALLED MY INSURANCE AGENT THE NEXT MORNING. THE AGENT DID SOME INVESTIGATION AND ADVISED US TO GET IT TOWED TO ANOTHER SERVICE STATION IN MOORHEAD MN THAT WORKS MOSTLY ON IMPORTS. THIS SERVICE STATION KNEW WHAT THE PROBLEM WAS AS THEY HAD FIXED FIVE TO SIX OTHERS IN THE LAST COUPLE OF MONTHS. THEY GOT THE PARTS FROM THE MOTORWERKS BMW DEALERSHIP, FIXED THE PROBLEM AND I GOT THE VEHICLE BACK ON 1/27/2011. THEY ALSO MENTIONED THAT SOMEBODY HAD TRIED FIXING THE PROBLEM EARLIER BUT DID NOT QUITE FINISH IT. WE ARE THE ORIGINAL OWNERS OF IT AND HAVE ALWAYS TAKEN IT TO MOTORWERKS BMW IN MINNEAPOLIS FOR ALL WORK. THE TOTAL WITHOUT THE TWO TOWING WAS $1028. I HAVE READ THAT OTHER BWM OWNERS LIVING IN COLD PLACES WITH HIGH HUMIDITY HAVE HAD THE SAME PROBLEM. I AM SCARED TO HAVE ANY FAMILY MEMBER DRIVE THE VEHICLE. HAVE OTHERS HAD THE SAME PROBLEM? CAN IT HAPPEN AGAIN? WHAT SHOULD I DO? *TR
NHTSA ODI #10389957
90,000 miles · Mar 8, 2011
SeatsFire
2005 BMX X3 SEAT WARMER ON THE DRIVER'S SIDE BURNT THROUGH THE SEAT AND BURNT MY LEG. THE DEALER REFUSES TO RECOGNIZE THIS IS A PRODUCT DEFECT AND WILL REPLACE THE SEAT. *TR
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
2005 BMW X3 Problems, Complaints & Recalls | Skip That Year
Illustration