Power Train. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports2 fire reports0 injury reports

Engine complaints

1 reports

Clear category filter

152,000 miles · Oct 20, 2020

EngineFire

Read full complaint

TL* THE CONTACT OWNS A 1999 BMW K1200LT. THE CONTACT STATED THAT UPON START UP OF HIS MOTORCYCLE, THE MOTORCYCLE CAUGHT FIRE WITHOUT WARNING. THE CONTACT ATTEMPTED TO EXTINGUISH THE MOTORCYCLE WITH WATER BUT TO NO AVAIL. THE CONTACT WAS ABLE TO MOVE HIS MOTORCYCLE OUT OF HIS BUILDING AND THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE HAD YET TO BE INSPECTED OR DIAGNOSED; THE MANUFACTURER NOR THE DEALER HAVE YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE REMAINED IN THE POSSESSION OF THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 152,000. THE VIN WAS NOT AVAILABLE. *BF*JB

NHTSA ODI #11365442

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP12001 · M/c Final Drive Ball Bearing Failure

Opened Jan 20, 2012 · Closed Jun 20, 2013

Status: closed (inferred from source dates) · Power Train:driveline:differential Unit

The Office of Defects Investigation (ODI) received a defect petition requesting that it open an investigation into model year (MY) 1998-2009 BMW KLT series motorcycles for final drive bearing failures.The petitioner asked NHTSA to issue an order that [BMW] be required to recall the affected models for inspection ofcomponent wear and proper assembly of the [final drive] bearing.ODI has reviewed the petition, assessed relevant consumer complaints, and gathered other data in the course of investigating this issue.Based on its review, ODI does not believe that a safety-related defect trend currently exists for final drive bearing failures in the subject motorcycles.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to accomplish the agency's safety mission, the petition is denied.However, the agency will continue to monitor information related to this issue and will take further action if warranted.For detailed information, see the Federal Register notice: https://federalregister.gov/a/2013-13779.