ENGINE STOPPED (BUT DID NOT SEIZE) AND VEHICLE STARTED RAPID DECELERATION. THE LOSS OF POWER WAS INSTANTANEOUS, BUT APPROXIMATELY 1 MINUTE EARLIER THE INSTRUMENT DISPLAY HAD GONE BLANK. THERE WERE NO PRIOR INDICATIONS OF TROUBLE. WHEN POWER LOSS OCCURRED, I PULLED IN THE CLUTCH AND COASTED TO A STOP AT THE SIDE OF THE ROAD. SUBS…
Read full complaint
ENGINE STOPPED (BUT DID NOT SEIZE) AND VEHICLE STARTED RAPID DECELERATION. THE LOSS OF POWER WAS INSTANTANEOUS, BUT APPROXIMATELY 1 MINUTE EARLIER THE INSTRUMENT DISPLAY HAD GONE BLANK. THERE WERE NO PRIOR INDICATIONS OF TROUBLE. WHEN POWER LOSS OCCURRED, I PULLED IN THE CLUTCH AND COASTED TO A STOP AT THE SIDE OF THE ROAD. SUBSEQUENTLY TESTING SHOWED THAT BATTERY WAS DISCHARGED AND LOSS OF POWER WAS DUE TO FAILURE OF CHARGING SYSTEM, SPECIFICALLY, FAILURE OF GENERATOR STATOR (GENERATOR IN THIS VEHICLE USES PERMANENT MAGNET ROTOR AND WOUND STATOR). *TR
NHTSA ODI #10505122
23,815 miles · Jul 13, 2012
EngineFuel/propulsion System
I WAS TRAVELING ON INTERSTATE 95 SOUTH IN MARYLAND NEAR COLUMBIA DOING APPROXIMATELY 65 MPH AND HAD TO SLOW FOR TRAFFIC AHEAD. I SLOWED TO 50 MPH AND DISENGAGED THE CLUTCH TO SHIFT GEARS AND THE ENGINE STALLED. I WAS NOT INITIALLY AWARE THAT IT HAD STALLED DUE TO THE GENERAL TRAFFIC NOISE. WHEN I ENGAGED THE CLUTCH IN THE LOW…
Read full complaint
I WAS TRAVELING ON INTERSTATE 95 SOUTH IN MARYLAND NEAR COLUMBIA DOING APPROXIMATELY 65 MPH AND HAD TO SLOW FOR TRAFFIC AHEAD. I SLOWED TO 50 MPH AND DISENGAGED THE CLUTCH TO SHIFT GEARS AND THE ENGINE STALLED. I WAS NOT INITIALLY AWARE THAT IT HAD STALLED DUE TO THE GENERAL TRAFFIC NOISE. WHEN I ENGAGED THE CLUTCH IN THE LOWER GEAR MY REAR TIRE SKIDDED AND I ALMOST LOST CONTROL OF THE BIKE. THEN I REALIZED THE ENGINE HAD STALLED. I WAS ABLE TO ROLL START THE BIKE BY SHIFTING TO YET A LOWER GEAR AND ENGAGING THE CLUTCH RAPIDLY BUT THE ENGINE STALLED ALMOST IMMEDIATELY AGAIN. I ENDED UP HAVING TO DISMOUNT THE BIKE IN THE MIDDLE OF THE HIGHWAY TRAFFIC AND (VERY QUICKLY) PUSH IT TO THE SIDE OF THE ROAD. I WAS THEN ABLE TO RESTART IT BUT IT WOULD NOT IDLE AT ALL. THIS WAS A VERY DANGEROUS INCIDENT THAT OCCURRED WITHOUT WARNING. NO WARNING LIGHTS WERE ILLUMINATED ON THE DASH. I'M AWARE THAT THERE IS A SAFETY RECALL FOR THIS MODEL BIKE BUT WHEN I CHECKED WITH THE DEALER ABOUT 2MONTHS AGO THEY TOLD ME THAT THE RECALL SERVICE HAD ALREADY BEEN PERFORMED ON THIS BIKE. *TR
BMW IS RECALLING CERTAIN 2008 THROUGH 2010 F 650 GS MOTORCYCLES MANUFACTURED FROM JANUARY 11, 2008, THROUGH DECEMBER 8, 2009. A WASHER MAY INTERFERE WITH THE FRONT DISC BRAKE FASTENERS' TORQUE. AS A RESULT, OVER TIME, A FASTENER OR MUTIPLE FASTENERS COULD BECOME LOOSE, ALLOWING THE BRAKE DISC TO BECOME LOOSE.
Consequence & remedy
Consequence: A LOOSE BRAKE DISC MAY INTERFERE WITH PROPER BRAKING PERFORMANCE AND MAY INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 13, 2011. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
BMW IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 F650 GS AND F 800 GS MOTORCYCLES MANUFACTURED FROM SEPTEMBER 27, 2007 THROUGH MARCH 30, 2009. THE DRIVE CHAINS MAY NOT HAVE BEEN PRODUCED TO SPECIFICATION. AS A RESULT, OVER TIME THE DRIVE CHAIN COULD BREAK.
Consequence & remedy
Consequence: IF THE BROKEN CHAIN BECOMES TRAPPED BETWEEN THE REAR WHEEL AND THE FRAME, THE REAR WHEEL COULD LOCK UP, POSSIBLY RESULTING IN A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE DRIVE CHAIN AND SPROCKETS ON THE AFFECTED MOTORCYCLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 30, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
BMW IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 F650 GS AND F800 GS MOTORCYCLES MANUFACTURED BETWEEN JANUARY 2008 AND DECEMBER 2009. DURING ENGINE OPERATION, A VACUUM IS CREATED IN ORDER TO DRAW FRESH AIR INTO THE CANISTER. THIS AIR THEN MIXES WITH THE FUEL VAPORS CAPTURED BY THE CANISTER, AND IS SUBSEQUENTLY COMBUSTED. DUE TO THE ROUTING OF THE VENTILATION HOSE, WATER NEAR THE END OF THE HOSE COULD BE DRAWN INTO THE CHARCOAL CANISTER.
Consequence & remedy
Consequence: WATER COULD FLOW INTO THE CANISTER CAUSING A STALLING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND ADD AN ADDITIONAL HOSE AND ROUTE IT SUCH THAT THE PRESENT DEFECT IS PREVENTED. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 13, 2010. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE09051 · Motorcycle Stalling
Opened Nov 5, 2009 · Closed Jan 4, 2010
Status: closed (inferred from source dates) · Vehicle Speed Control
SUBJECT MOTORCYCLES MAY STALL WHEN WATER IS DRAWN INTO THE AIR INTAKE SYSTEM THROUGH THE CHARCOAL CANISTER VENTILATION HOSE WITHIN THE EVAPORATIVE EMISSION CONTROL SYSTEM.BMW IS RECALLING THE SUBJECT MOTORCYCLES TO ADD A HOSE THAT WILL BE ROUTED DIFFERENTLY THAN THE EXISTING HOSE.IN ADDITION TO THE SUBJECT MOTORCYCLES ((BMW F650, MODEL YEAR 2009), ALSO INCLUDED IN THE RECALL WILL BE MODEL YEARS 2008 AND 2010.ADDITIONALLY THE F800 MODEL ISBEING INCLUDEDFOR MODEL YEARS 2008-2010.WITH BMW'S SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
2009 BMW F 650 Gs Problems, Complaints & Recalls | Skip That Year
Illustration