Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 19 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports0 injury reports
What owners actually said
19 reports
75,000 miles · Jan 3, 2004
Engine And Engine Cooling
THERE'S A MAJOR FLAW DESIGN IN THE BMW 740I AND 740IL FGROM YEARS 1995-200. I WAS JUST DRIVING AND IT FAILED WITHOUT HESITATION. I SPOKE WITH A LOT OF OTHER OWNERS OF THIS MODEL AND THEY HAD THE SAME PEOBLEM. TO SOME PEOPLE IT HAPPEND AS THEY WERE DRIVING ON THE HIGHWAY SPILLING COOLANT ALL OVER THEIR WINDSHIELD AND LOSING CONT…
Read full complaint
THERE'S A MAJOR FLAW DESIGN IN THE BMW 740I AND 740IL FGROM YEARS 1995-200. I WAS JUST DRIVING AND IT FAILED WITHOUT HESITATION. I SPOKE WITH A LOT OF OTHER OWNERS OF THIS MODEL AND THEY HAD THE SAME PEOBLEM. TO SOME PEOPLE IT HAPPEND AS THEY WERE DRIVING ON THE HIGHWAY SPILLING COOLANT ALL OVER THEIR WINDSHIELD AND LOSING CONTROL OF THEIR VEHICLE. *AK
NHTSA ODI #10052306
89,000 miles · Jan 3, 2004
Equipment
WHILE USING THE FACTORY JACK TO CHANGE A TIRE, THE JACK BECAME UNSTABLE DUE TO THE SMALL BASE THAT IS PROVIDED AND THE CAR FELL OFF OF THE JACK. THE JACK WAS BEING OPERATED ON AN ASPHALT SURFACE. THIS WAS A NEAR MISS ACCIDENT THAT COULD HAVE EASILY TRAPPED ME UNDER MY CAR. THE CAR IS A 1997 740IL BMW.*AK
NHTSA ODI #10052305
71,000 miles · May 24, 2003
Engine And Engine Cooling
I HAVE HAD THREE SEPARATE FAILURES OF PLASTIC RADIATOR COMPONENTS IN MY 1997 BMW 740IL IN THE SPACE OF 5 MONTHS. AT FIRST INSPECTION, THESE APPEAR TO ME TO BE THERMAL FATIGUE FAILURES INDICATING SOME MANUFACTURING DEFECT IN THE PLASTIC. BMW DENIES ANY SUCH ISSUE AND REFUSED TO REPLACE THE FAILED COMPONENTS UNDER WARRANTY. THE…
Read full complaint
I HAVE HAD THREE SEPARATE FAILURES OF PLASTIC RADIATOR COMPONENTS IN MY 1997 BMW 740IL IN THE SPACE OF 5 MONTHS. AT FIRST INSPECTION, THESE APPEAR TO ME TO BE THERMAL FATIGUE FAILURES INDICATING SOME MANUFACTURING DEFECT IN THE PLASTIC. BMW DENIES ANY SUCH ISSUE AND REFUSED TO REPLACE THE FAILED COMPONENTS UNDER WARRANTY. THE FIRST INSTANCE WAS A MINOR LEAK THAT DEVELOPED FROM A SMALL PIPE THAT EXITS THE TOP OF THE RADIATOR. BEFORE I HAD THAT REPAIRED, THE NECK OF THE TOP INLET TO THE RADIATOR BROKE OFF WHILE I WAS DRIVING. THE RADIATOR HAD TO BE REPLACED. A LITTLE OVER A MONTH LATER, I SAW STEAM EMERGING FROM THE RADIATOR AND NOTED A 1/4" SPLIT IN THE CENTER OF THE INTERGRAL FLUID RESERVOIR WHERE WATER WAS SPRAYING OUT. THIS COMPONENT HAD NOT BEEN REPLACED WHEN THE RADIATOR WAS REPLACED. AS THIS WAS NOT IN A TYPICAL STRESS AREA LIKE A CORNER, SEAM OR BOTTOM, I BELIEVE THIS WAS CAUSED BY FATIGUE. THE FACT THAT ALL OF THESE FAILURES OCCURRED ON PLASTIC COMPONENTS SO CLOSE TOGETHER IN THEIR LIFE IMPLIES A COMMON FAILURE MECHANISM TO ME. THE DEALER COMMENTED THAT "THEY SEE A LOT OF THESE KINDS OF FAILURES." AS THE VEHICLE HAS ONLY 70,000 MILES ON IT, THIS WOULD SEEM UNUSUAL UNLESS THERE WERE SOME UNDERLYING FLAW IN BMW'S DESIGN OR MANUFACTURING OF THE COOLING SYSTEM. *NLM
NHTSA ODI #10019215
Mileage unknown · Dec 8, 2002
Vehicle Speed Control
ENGINE RPM WILL SUDDENLY SURGE FROM 8OO TO 2500 RPM WITH NO WARNING. IDLE WILL VARY FROM 800 RPM TO 400 RPM AND THEN POSSIBLY SHOOT UP TO 12-2500 RPM. AFTER 5 ATTEMPTS DEALER UNABLE TO CORRECT. CONSIDER THIS A MAJOR SAFETY HAZARD. DT
NHTSA ODI #770596
Mileage unknown · Jul 24, 2002
Engine And Engine Cooling
WHILE DRIVING 60MPH WATER PUMP FAILED, CAUSING STEAM TO COME UP FROM HOOD, RESULTING IN LOSS OF CONTROL.*AK CONSUMER STATED THE RADIATOR HOSE BLEW OFF AND THE SERPENTINE BELT FAILED WHEN THE WATER PUMP WENT OUT.*JB
NHTSA ODI #8014686
Mileage unknown · Feb 19, 2002
Engine And Engine Cooling
THERE WAS A RECALL FOR A GAS LEAK. HAD VEHICLE SERVICED A YEAR LATER AND GAS LEAK CONTINUES.*AK
NHTSA ODI #8004205
Mileage unknown · Feb 1, 1999
Air Bags
AIR BAG INDICATOR LIGHT FAILED TWICE. *YC
NHTSA ODI #607444
Mileage unknown · Aug 11, 1998
Structure
PASSENGER UNABLE TO UNLOCK POWER LOCKS MANUALLY, LEAVING PASSENGER TRAPPED IN VEHICLE W/WINDOWS UP IN 95 DEGREE HEAT. QCAW
NHTSA ODI #540954
Mileage unknown · May 14, 1998
Air BagsCrash
WHILE DRIVING BETWEEN 40-50 MPH HIT A CONCRETE POST DIRECT CENTER OF VEHICLE. THEERE WAS DEPLOYMENT OF DRIVER'S OR PASSENGER'S SIDE AIRBAGS. ALSO THIS VEHICLE IS EQUIPPED WITH SIDE AIRBAGS WHICH DID NOT DEPLOY. CAUSE UNKNOWN.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
Consequence & remedy
Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 BMW 740IL Problems, Complaints & Recalls | Skip That Year
Illustration