THUMPING NOISES FROM UNDER REAR SEAT OF CAR WHILE DRIVING. FUEL TANK IMPLODING SUCKING ITSELF INWARDS THEN CRACKING CAUSING FUEL TO LEAK ON TO PAVEMENT WHILE DRIVING DOWN THE ROAD. DRIVER NOT AWARE OF THIS UNTIL PARKING AND SMELLING FUEL WHILE STANDING NEAR THE CAR. AFTER FURTHER RESEARCH FOUND A SERVICE BULLETIN DATED FEBRUARY…
Read full complaint
THUMPING NOISES FROM UNDER REAR SEAT OF CAR WHILE DRIVING. FUEL TANK IMPLODING SUCKING ITSELF INWARDS THEN CRACKING CAUSING FUEL TO LEAK ON TO PAVEMENT WHILE DRIVING DOWN THE ROAD. DRIVER NOT AWARE OF THIS UNTIL PARKING AND SMELLING FUEL WHILE STANDING NEAR THE CAR. AFTER FURTHER RESEARCH FOUND A SERVICE BULLETIN DATED FEBRUARY 1998 ON THIS VERY ISSUE WHICH NEVER BECAME A RECALL.
NHTSA ODI #10567195
Mileage unknown · Dec 3, 2002
Fuel System, Gasoline
I HAD TO REPLACE ALL THE ITEMS MENTIONED, HOWEVER I DON'T HAVE THE CAR ANYMORE IT WAS REOPENED ON DEC. 3, 2002 AND I'M TRYING TO FIGHT THE FINANCE CO. WFS. DT
NHTSA ODI #770386
Mileage unknown · Apr 13, 2001
Fuel System, Gasoline
FUEL IS LEAKING AT POINT WHERE HOSE MEETS METAL FUEL LINE, CAUSING FIRE HAZARD. DEFECT IS SAME AS MENTIONED IN RECALL 95V238000. BUT, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
Consequence & remedy
Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE LOWER SUSPENSION ARM MOUNTING EYE ON THE RIGHT SIDE REAR AXLE HUB CARRIER WAS PRODUCED WITH A CASTING FLAW.
Consequence & remedy
Consequence: IT IS POSSIBLE THAT THE RIGHT SIDE REAR AXLE CARRIER EYE COULD CRACK AND BREAK WHILE DRIVING CAUSING A LOSS OF CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR A CASTING FLAW IN THE RIGHT SIDE REAR AXLE CARRIER AND IF FOUND, REPLACE THE CARRIER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1995 BMW 740I Problems, Complaints & Recalls | Skip That Year
Illustration