Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
225–50K
650–75K
675–100K
6100–150K
0150K+
23 reports with mileage · 6 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
What owners actually said
29 reports
71,000 miles · Feb 7, 2011
Air Bags
DRIVER SIDE FRONT AIRBAG DEPLOYMENT FAULT BECAUSE OF DEFECTIVE MAT IN DRIVER SIDE FRONT SEAT. I HAVE HAD IT TO THE DEALER FOUR TIMES AND THEY HAVE SAID THERE WAS A RECALL FOR THE SAME FAULT ON THE PASSENGER SIDE BUT BMW HAS NOT YET RECALLED THE DRIVER SIDE MAT. THIS FAULT RENDERS THE DRIVER SIDE FRONT AIRBAG INACTIVE AND WILL …
Read full complaint
DRIVER SIDE FRONT AIRBAG DEPLOYMENT FAULT BECAUSE OF DEFECTIVE MAT IN DRIVER SIDE FRONT SEAT. I HAVE HAD IT TO THE DEALER FOUR TIMES AND THEY HAVE SAID THERE WAS A RECALL FOR THE SAME FAULT ON THE PASSENGER SIDE BUT BMW HAS NOT YET RECALLED THE DRIVER SIDE MAT. THIS FAULT RENDERS THE DRIVER SIDE FRONT AIRBAG INACTIVE AND WILL NOT DEPLOY EVEN IF THE APPROPRIATE LEVEL OF IMPACT OCCURS. *LN
NHTSA ODI #10380972
59,000 miles · Jan 19, 2011
Engine And Engine Cooling
I AM SEEKING ASSISTANCE IN THE MATTER OF HAVING A DEFECTIVE ENGINE IN MY 2006 750I BMW. WE HAVE HAD THIS VEHICLE SINCE OCT. 2008 AND WE HAVE KEPT SCHEDULED MAINTENANCE ON IT AS PRESCRIBED. RECENTLY AFTER TAKEN THE CAR TO THE SHOP FOR LIGHT SMOKE COMING OUT OF THE TAIL PIPE IT WAS DISCOVERED THAT OUR ENGINE WAS POSSIBLY BAD AND N…
Read full complaint
I AM SEEKING ASSISTANCE IN THE MATTER OF HAVING A DEFECTIVE ENGINE IN MY 2006 750I BMW. WE HAVE HAD THIS VEHICLE SINCE OCT. 2008 AND WE HAVE KEPT SCHEDULED MAINTENANCE ON IT AS PRESCRIBED. RECENTLY AFTER TAKEN THE CAR TO THE SHOP FOR LIGHT SMOKE COMING OUT OF THE TAIL PIPE IT WAS DISCOVERED THAT OUR ENGINE WAS POSSIBLY BAD AND NEEDED TO BE REPLACED. THAT FIRST WE WERE TOLD THAT BMW WOULD MOST LIKELY COVER PARTS IF WE WERE TO HAVE THE ENGINE BROKE DOWN TO SEE EXACTLY WHAT THE PROBLEM WAS. WHICH WE AGREE TO; BEFORE THE ENGINE WAS BROKE DOWN AND THE CAUSE WAS KNOWN WE WERE TOLD THAT REGARDLESS OF WHAT WAS WRONG WITH THE ENGINE THEY WERE NOT GOING TO HELP. WE CONTINUED WITH THE BREAK DOWN TO DISCOVER THAT THE ENGINE IS IN FACT BAD AND IT IS "VERY UNUSUAL" FOR THE ENGINE TO BE IN THE SHAPE IT WAS IN. MIND YOU THE ENGINE ONLY HAS 59000 MILES ON IT AND WAS UNDER WARRANTY UP UNTO 50000 MILES. THE 2011 BMW THEY SAY WILL RUN UP 300000 MILES THE AVERAGE BMW ENGINE WILL RUN OVER 200000 MILE AND MY ONLY WENT UP TO 59000 MILE WHICH WAS TIME OF DETERMINING THAT THE ENGINE WAS BAD. THAT ISN'T EVEN A QUARTER OF WHAT BMW ENGINES WILL DO, SO IT IS CLEAR THAT THE ENGINE IS ONE OUT OF THE FEW THAT COME OFF THE LINE WITH MAJOR DEFECTS. I WOULD LIKE BMW TO TAKE RESPONSIBLY FOR THEIR DEFECTED ENGINE AND PAY TO HAVE IT REPLACED. AS OF NOW MY FAMILY AND I ARE HADN'T TO COME OUT OF POCKET FOR AROUND $29,000.00 FOR A NEW ENGINE BECAUSE BMW WILL NOT ASSIST US IN THIS MATTER. ATTACHED ARE THE READING AND MEASUREMENT THAT THE MECHANIC TOOK AND DECLARED THE ENGINE TO BE BAD. FURTHER MORE WE HAD NEVER HAD ANY PROBLEMS WITH OUR CAR UNTIL AFTER GETTING AND OIL CHANGE AT BMW OF NASHVILLE WHERE THE CAR IS STILL CURRENTLY IN THE SHOP.
NHTSA ODI #10378887
59,000 miles · Dec 2, 2010
Engine And Engine Cooling
BMW OF NASHVILLE IS TELLING ME I NEED A NEW MOTOR IN MY 2006 750I BMW; THE ENGINE ONLY HAS 59,000 MILES ON IT. THEY SAY THE ENGINE BLOCK IS BAD. I AM 9,000 MILES OUT OF WARRANTY SO THEY ARE SAYING IS ALL ON ME. I HAVE HAD ALL SERVICES REQUIRED AND NOT ONCE WAS IT BROUGHT TO MY ATTENTION THAT MY ENGINE WAS GOING BAD AND NOW IT'S …
Read full complaint
BMW OF NASHVILLE IS TELLING ME I NEED A NEW MOTOR IN MY 2006 750I BMW; THE ENGINE ONLY HAS 59,000 MILES ON IT. THEY SAY THE ENGINE BLOCK IS BAD. I AM 9,000 MILES OUT OF WARRANTY SO THEY ARE SAYING IS ALL ON ME. I HAVE HAD ALL SERVICES REQUIRED AND NOT ONCE WAS IT BROUGHT TO MY ATTENTION THAT MY ENGINE WAS GOING BAD AND NOW IT'S GONE FROM BEING GOOD TO NEEDING ANOTHER ENGINE? DUE TO THE MILEAGE I HAVE ON THE ENGINE AND I FIND THIS TO BE A DEFECTED ENGINE AND WOULD ASK FOR ASSISTANCE IN THIS MATTER. *TR
NHTSA ODI #10368664
53,000 miles · Nov 11, 2010
Power Train
VEHICLE SLAMS INTO FIRST GEAR UPON DECELERATION AND "SLIPS" IF YOU TAKE YOUR FOOT OFF THE GAS PEDAL AND THEN ACCELERATE IMMEDIATELY, AS IN TRAFFIC CONDITIONS. WHEN TRANSMISSION GETS IN STOP AND GO TRAFFIC IT WILL SLAM INTO GEAR BEFORE ACCELERATION OCCURS. CAR WAS AT BMW DEALER FOR SEVEN DAYS WITH ALL SOFTWARE UPGRADES THAT DEALE…
Read full complaint
VEHICLE SLAMS INTO FIRST GEAR UPON DECELERATION AND "SLIPS" IF YOU TAKE YOUR FOOT OFF THE GAS PEDAL AND THEN ACCELERATE IMMEDIATELY, AS IN TRAFFIC CONDITIONS. WHEN TRANSMISSION GETS IN STOP AND GO TRAFFIC IT WILL SLAM INTO GEAR BEFORE ACCELERATION OCCURS. CAR WAS AT BMW DEALER FOR SEVEN DAYS WITH ALL SOFTWARE UPGRADES THAT DEALER SUGGESTED WERE PERFORMED AND STILL SAME PROBLEM. NO CALL BACKS TO DATE. SPOKE WITH BMW OF NORTH AMERICA AND THEY REFERRED ME BACK TO DEALER. UNWILLING TO ADMIT THERE IS A PROBLEM WITH THE TRANSMISSION EVEN THOUGH THEY HAVE ISSUED INTERCOMPANY TECH. BULLETINS REGARDING THE EXACT PROBLEM. *TR
NHTSA ODI #10365392
95,286 miles · Nov 3, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2006 BMW 750. THE CONTACT STATED THAT SHE PLACED BOTH FEET ON THE BRAKE PEDAL IN ORDER TO BRING THE VEHICLE TO A STOP. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE DIAGNOSTIC TEST LOCATED THE FAILURE AS THE BRAKE ASSIST SYSTEM AND THE VEHICLE WOULD NOT PASS STATE INSPECTION, BECAUSE OF THE …
Read full complaint
TL*THE CONTACT OWNS A 2006 BMW 750. THE CONTACT STATED THAT SHE PLACED BOTH FEET ON THE BRAKE PEDAL IN ORDER TO BRING THE VEHICLE TO A STOP. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE DIAGNOSTIC TEST LOCATED THE FAILURE AS THE BRAKE ASSIST SYSTEM AND THE VEHICLE WOULD NOT PASS STATE INSPECTION, BECAUSE OF THE BRAKE FAILURE. THE DEALER WAS CONTACTED AND STATED THAT RECALL 10V446000 SERVICE BRAKES HYDRAULIC POWER ASSIST VACUUM REMEDY WASN'T AVAILABLE; THEREFORE, THEY COULDN'T REPAIR THE VEHICLE. THE VEHICLE WASN'T REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 95,826.
NHTSA ODI #10363889
77,547 miles · Oct 28, 2010
Tires
I PURCHASED 2 PIRELLI ROSSO TIRES FOR THE REAR OF MY 2006 BMW 760LI. I WAS DRIVING ON I-24W IN NASHVILLE, TN ON THE NIGHT OF 10/24/10. IT WAS POURING DOWN RAIN AND I COULD NOT KEEP MY CAR ON THE ROAD IF I WENT OVER 40 MPH. WHEN I CHECKED MY TIRES THE NEXT MORNING, I NOTICED THEY WERE COMPLETELY BALD. THEY ARE HIGH PERFORMANCE T…
Read full complaint
I PURCHASED 2 PIRELLI ROSSO TIRES FOR THE REAR OF MY 2006 BMW 760LI. I WAS DRIVING ON I-24W IN NASHVILLE, TN ON THE NIGHT OF 10/24/10. IT WAS POURING DOWN RAIN AND I COULD NOT KEEP MY CAR ON THE ROAD IF I WENT OVER 40 MPH. WHEN I CHECKED MY TIRES THE NEXT MORNING, I NOTICED THEY WERE COMPLETELY BALD. THEY ARE HIGH PERFORMANCE TIRES, USUALLY LASTING 15,000-20,000 MILES. THESE TIRES ONLY LASTED 3,500 MILES. I PURCHASED THESE TIRES ON 09/30/10. I AM A 36 YEAR OLD WOMAN WITH 2 CHILDREN. I DO NOT HOT-ROD MY CAR OR DRIVE IN EXCESSIVE SPEEDS. I AM THE ONLY ONE WHO DRIVES MY CAR. I CONTACTED PIRELLI CUSTOMER RELATIONS IN ROME, GA. I WAS TREATED VERY RUDELY BY A WOMAN CALLING HERSELF "SANDRA". I WAS ONLY OFFERED 40% OFF A NEW SET OF REAR TIRES. NEVERMIND THAT THIS COULD BE A VERY DANGEROUS ISSUE WITH THE TIRE. I CLEARLY BELIEVE THIS IS A MANUFACTURER DEFECT. THE WOMAN ON THE OTHER LINE WOULD NOT HELP ME. SHE WOULD NOT PUT ME THROUGH TO ANYONE WHO COULD. SHE HUNG UP ON ME ONCE AND PUT ME THROUGH TO A STRANGE VOICEMAIL ANOTHER TIME. SHE BASICALLY TOLD ME I COULD TAKE OR LEAVE THE 40% AND THEY WOULD NOT ATTEMPT TO DO ANYMORE. I TOOK MY CAR TO DISCOUNT TIRE IN MURFREESBORO, TN. THEY CALLED CUSTOMER RELATIONS AND GOT THE SAME REACTION. IT'S GOING ON 3 DAYS NOW, AND PIRELLI HAS NOT FAXED OVER THE 40% DISCOUNT AS PROMISED OR ATTEMPTED TO HELP ME IN THIS SITUATION AT ALL. I HAVE SEARCHED THE INTERNET AND ASKED THE WOMAN ANSWERING THE PHONE FOR ANOTHER NUMBER WHERE I MIGHT GET SOMEONE'S ATTENTION TO THIS MATTER. SHE WOULD NOT HEAR MY COMPLAINT. *TR
NHTSA ODI #10362859
15,439 miles · Oct 8, 2008
Engine And Engine Cooling
PROBLEM WITH ENGINE OIL CONSUMPTION; ON APRIL 2007 -MILEAGE 8936 WARNING -LOW OIL-AD 1.5Q. ON 29 MAY 2007-WARN LOW OIL- AD 1.5Q OIL. ON AUG 2007-WARN LOW OIL-AD 1.5 Q OIL ON DEC 2007-WARN LOW OIL-ADDED 2.5 Q OIL SEPT 30 2008-WARN LOW OIL-ADDED 1 Q OIL AT LOC DEALERSHIP. THIS IS NOT A NORMAL OIL CONSUMPTION OF THE HIGH END…
Read full complaint
PROBLEM WITH ENGINE OIL CONSUMPTION; ON APRIL 2007 -MILEAGE 8936 WARNING -LOW OIL-AD 1.5Q. ON 29 MAY 2007-WARN LOW OIL- AD 1.5Q OIL. ON AUG 2007-WARN LOW OIL-AD 1.5 Q OIL ON DEC 2007-WARN LOW OIL-ADDED 2.5 Q OIL SEPT 30 2008-WARN LOW OIL-ADDED 1 Q OIL AT LOC DEALERSHIP. THIS IS NOT A NORMAL OIL CONSUMPTION OF THE HIGH END VEHICLE BMW SERIES 7 OR ANY OTHER HIGH END VEHICLE. SO FAR I HAVE NOT BEEN GIVEN A REASONABLE EXPLANATION. DEALER SHIP (PEAKE BMW) IS ADVISING THAT NO OIL LEAKS NOTED AND OIL NOT COMING OUT TROUGH THE TAIL PIPE ? SO WHAT IS GOING ON? CAN SOMEONE AT BWM RECOGNIZE AND ACKNOWLEDGE THIS PROBLEM OR DO I HAVE TO GO BACK AND CONTACT BMW IN GERMANY AND ASK FOR THEIR ASSISTANCE. I HAVE HAD AND STILL DO ( MB S500 ,BMW 535I ETC.) AND NEVER HAD ANY PROBLEM LIKE THIS. HAVE OTHER VEHICLES AND TRUCKS AND NEVER HAD TO ADD ANY OIL IN BETWEEN THE SERVICES. THIS IS EMBARRASSING,DRIVING $85K VEHICLE AND HAVE TO STOP AT THE GAS STATION TO FILL UP SOME OIL ??? *TR
NHTSA ODI #10244889
Mileage unknown · Jun 16, 2007
Electrical System
BMW 750 LI 2006. I AM THE FIST OWNER OF THIS CAR. SICNE I GOT THIS CAR IT HAS GIVEN ME MUCH PROBLEM. I HAVE OWED THIS CAR FOR A YEAR, AND HAVE TAKEN IT TO THE DEALER MANY TIMES. THE PROBLEMS WERE NOT SOLVED. WHILE DRIVING THE CAR JERKED, AND AIR CONDITIONING ( A/C )SMELLED. THE LIGHT ALWAYS WENT ON. THERE WERE SO MANY PROBLEMS.…
Read full complaint
BMW 750 LI 2006. I AM THE FIST OWNER OF THIS CAR. SICNE I GOT THIS CAR IT HAS GIVEN ME MUCH PROBLEM. I HAVE OWED THIS CAR FOR A YEAR, AND HAVE TAKEN IT TO THE DEALER MANY TIMES. THE PROBLEMS WERE NOT SOLVED. WHILE DRIVING THE CAR JERKED, AND AIR CONDITIONING ( A/C )SMELLED. THE LIGHT ALWAYS WENT ON. THERE WERE SO MANY PROBLEMS. *AK
NHTSA ODI #10193519
7,000 miles · Mar 21, 2007
Power Train
TL*- THE CONTACT OWNS A 2006 BMW 750. THE VEHICLE HAS A TRANSMISSION THAT SHOULD AUTOMATICALLY SHIFT THE VEHICLE TO THE PARK POSITION WHEN THE START/STOP BUTTON IS DEPRESSED. THE CONTACT DEPRESSED THE START/STOP BUTTON AND NOTICED THAT THE VEHICLE STARTED TO ROLL FORWARD APPROXIMATELY 2 SECONDS AFTER THE ENGINE LOST POWER. HE WA…
Read full complaint
TL*- THE CONTACT OWNS A 2006 BMW 750. THE VEHICLE HAS A TRANSMISSION THAT SHOULD AUTOMATICALLY SHIFT THE VEHICLE TO THE PARK POSITION WHEN THE START/STOP BUTTON IS DEPRESSED. THE CONTACT DEPRESSED THE START/STOP BUTTON AND NOTICED THAT THE VEHICLE STARTED TO ROLL FORWARD APPROXIMATELY 2 SECONDS AFTER THE ENGINE LOST POWER. HE WAS ABLE TO DEPRESS THE BRAKE AND STOP THE VEHICLE. THE CONTACT STATED THIS ALSO OCCURRED APPROXIMATELY 2 WEEKS LATER. THE CONTACT PARKED AND EXITED HIS VEHICLE, UPON HIS RETURN THE VEHICLE ROLLED BACKWARDS APPROXIMATELY A HUNDRED FEET AND CRASHED INTO A LAMPPOST. THE ROAD CONDITIONS WERE CLEAR ON BOTH OCCURRENCES AND THE VEHICLE WAS PARKED ON A FLAT SURFACE. THE PARKING BRAKE WAS NOT ENGAGED. THE DEALER STATED THEY ARE UNABLE TO DIAGNOSE THE FAILURE. THE CURRENT MILEAGE WAS 7,000 MILES.
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Consequence & remedy
Consequence: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
ON CERTAIN PASSENGER VEHICLES, THE LOWER RUBBER MOUNT OF THE REAR SHOCK ABSORBERS MAY NOT HAVE BEEN MANUFACTURED TO SPECIFICATIONS AND MAY NOT ADHERE CORRECTLY TO ITS HOUSING WITHIN THE SHOCK ABSORBER.
Consequence & remedy
Consequence: THE BUSHING COULD LOOSEN AND OVER TIME COULD SEPARATE FROM ITS HOUSING. THE DRIVER WILL EXPERIENCE IMPAIRED VEHICLE HANDLING AND CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR SHOCK ABSORBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 13, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA12002 · Vehicle Rollaway
Opened Apr 10, 2012 · Closed Jan 24, 2013
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:switch; Power Train:automatic Transmission
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Additional source detail variants (4)
Electrical System
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Electrical System:ignition
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Electrical System:ignition:switch
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Power Train:automatic Transmission
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
PE11025 · Vehicle Rollaway
Opened Aug 5, 2011 · Closed Apr 23, 2012
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
Additional source detail variants (2)
Electrical System
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
Power Train:automatic Transmission
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
2006 BMW 7 Series Problems, Complaints & Recalls | Skip That Year
Illustration