NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
28 reports50,000 miles · Jan 3, 2011
Visibility
TL* THE CONTACT OWNS A 2004 BMW 745I SERIES. THE CONTACT STATED HE WAS NOT ABLE TO SEE OUT OF THE DRIVER SIDE REARVIEW MIRROR. THE CONTACT STATED THAT THE PLASMA FRACTURED FROM THE MIRROR CAUSING THE MIRROR TO BECOME CLEAR AND DARK WITH CIRCLE SPOTS THAT CREATED A DOUBLE VISION. THE DEALER ADVISED THAT HE WOULD HAVE TO PAY FOR T…
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW 745I SERIES. THE CONTACT STATED HE WAS NOT ABLE TO SEE OUT OF THE DRIVER SIDE REARVIEW MIRROR. THE CONTACT STATED THAT THE PLASMA FRACTURED FROM THE MIRROR CAUSING THE MIRROR TO BECOME CLEAR AND DARK WITH CIRCLE SPOTS THAT CREATED A DOUBLE VISION. THE DEALER ADVISED THAT HE WOULD HAVE TO PAY FOR THE MIRROR REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 88,000.
NHTSA ODI #10373867
58,500 miles · Dec 8, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2004 BMW 745I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER10V446000, SERVICE BRAKES, HYDRAULIC POWER ASSIST VACUUM AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. THE DEALER INFORMED THE CONTACT THAT THE BRAKE VACUUM PUMP WAS LEAKING AND NEEDED TO BE REPLACED AND IT WAS NOT A PART OF THE …
Read full complaint
TL*THE CONTACT OWNS A 2004 BMW 745I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER10V446000, SERVICE BRAKES, HYDRAULIC POWER ASSIST VACUUM AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. THE DEALER INFORMED THE CONTACT THAT THE BRAKE VACUUM PUMP WAS LEAKING AND NEEDED TO BE REPLACED AND IT WAS NOT A PART OF THE RECALL. THE CONTACT STATED THAT REPLACING THE HOSE WOULD ONLY BE A TEMPORARY REPAIR THAT WOULD CAUSE FUTURE PROBLEMS. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 58,500.
NHTSA ODI #10369661
88,750 miles · Dec 7, 2010
SeatsInjury
I STARTED MY BMW 745I TO WARM IT UP ALONG WITH THE HEATED SEATS. CAME OUT OF MY HOUSE THREE MINUTES LATER TO LEAVE AND SMELLED SOMETHING BURNING ON THE INSIDE OF THE CAR. I LOOKED AROUND BUT DIDN'T SEE ANYTHING OUTRIGHT OBVIOUS. I STARTED TO DRIVE AWAY WHEN I FELT BURNING SENSATION TO MY LEFT SIDE. I TURNED TO LOOK AND SAW THAT …
Read full complaint
I STARTED MY BMW 745I TO WARM IT UP ALONG WITH THE HEATED SEATS. CAME OUT OF MY HOUSE THREE MINUTES LATER TO LEAVE AND SMELLED SOMETHING BURNING ON THE INSIDE OF THE CAR. I LOOKED AROUND BUT DIDN'T SEE ANYTHING OUTRIGHT OBVIOUS. I STARTED TO DRIVE AWAY WHEN I FELT BURNING SENSATION TO MY LEFT SIDE. I TURNED TO LOOK AND SAW THAT SEAT HEATER WAS BURNING THROUGH THE LEATHER ON THE LEFT SIDE OF THE BACK OF THE SEAT. I MADE LEFT A MESSAGE WITH A SERVICE REP AT "NEW COUNTRY BMW" OF HARTFORD,CT WITH NO RETURN CALL WITHIN 24 HOURS AS THERE ANSWERING SERVICE PROMISES. I THEN BROUGHT THE VEHICLE TO "NEW COUNTRY BMW" OF HARTFORD, CT WHERE THE SERVICE REP TOLD MYSELF HE HAD "NEVER HEARD OF THERE BEING A SEAT HEATER RECALL". *TR
NHTSA ODI #10369561
67,000 miles · Dec 3, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2004 BMW 745I. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR ROUTINE REPAIR AND THE TECHNICIAN DETECTED OIL LEAKING FROM THE BRAKE VACUUM PUMP INTO THE ENGINE. THE VEHICLE WAS REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V446000 (SERVICE BRAKES, HYDRAULIC: POW…
Read full complaint
TL*THE CONTACT OWNS A 2004 BMW 745I. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR ROUTINE REPAIR AND THE TECHNICIAN DETECTED OIL LEAKING FROM THE BRAKE VACUUM PUMP INTO THE ENGINE. THE VEHICLE WAS REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V446000 (SERVICE BRAKES, HYDRAULIC: POWER ASSIST: VACUUM). IN CONJUNCTION TO THE RECALL REPAIR THE BRAKE VACUUM PUMP WAS REPLACED AT THE OWNER'S EXPENSE. THE CONTACT STATED THAT THE RECALL REMEDY WAS NOT SUFFICIENT AND FAILED TO CORRECT THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.
NHTSA ODI #10369057
Mileage unknown · Mar 20, 2010
Engine And Engine Cooling
THE ENGINE OIL FILTER DRAIN PLUG IS INSUFFICIENT, CAUSING A LARGE LOSS OF OIL TO LEAK. THIS HAS AFFECTED AND DAMAGED THE TRANSMISSION. *TR
NHTSA ODI #10321125
70,000 miles · Oct 8, 2008
Air Bags
SHORTLY AFTER PURCHASE OF A USED 2004 BMW 745LI, THE AIRBAG LIGHT REMAINED ILLUMINATED AND THE PASSENGER OCCUPANCY LIGHT REMAINED ILLUMINATED AT ALL TIMES. CAR WOULD NOT PASS INSPECTION, THEREFORE I PAID $1700 TO BMW OF SILVER SPRING TO HAVE THIS CORRECTED. *TR
NHTSA ODI #10244725
44,827 miles · Aug 19, 2008
Electrical SystemEngine And Engine Cooling
TL*THE CONTACT OWNS A 2004 BMW 745I. THE CONTACT STATED THAT THE ENGINE WOULD OVERHEAT AND THE VEHICLE WOULD SHUT DOWN AND LOSE POWER. THE SAFETY MECHANISM IN THE VEHICLE WOULD SHUT DOWN IF IT SENSED A FAILURE WITH THE VEHICLE. THE FAILURE OCCURRED A TOTAL OF THREE TIMES WHILE DRIVING 40 MPH. ON ONE OCCASION, SHE WAS ABLE TO…
Read full complaint
TL*THE CONTACT OWNS A 2004 BMW 745I. THE CONTACT STATED THAT THE ENGINE WOULD OVERHEAT AND THE VEHICLE WOULD SHUT DOWN AND LOSE POWER. THE SAFETY MECHANISM IN THE VEHICLE WOULD SHUT DOWN IF IT SENSED A FAILURE WITH THE VEHICLE. THE FAILURE OCCURRED A TOTAL OF THREE TIMES WHILE DRIVING 40 MPH. ON ONE OCCASION, SHE WAS ABLE TO DRIVE TO THE DEALER AROUND THE CORNER AND THE OTHER TWO TIMES, SHE HAD TO HAVE THE VEHICLE TOWED TO THE DEALER. THE DEALER COULD NOT DIAGNOSE THE CAUSE OF THE FAILURE BECAUSE THE CODE WAS LOST. THE CONTACT SHOWED THE MECHANIC PICTURES OF THE MESSAGE ON THE INSTRUMENT PANEL THAT READ, "DO NOT DRIVE, ENGINE OVERHEATING, TURN ENGINE OFF". THE CONTACT WAS INFORMED THAT A NEW BATTERY WAS NEEDED AND SHE WOULD HAVE TO PAY $600. SHE DID NOT BELIEVE THAT THE ISSUE CENTERED AROUND THE BATTERY. THE MANUFACTURER STATED THAT BECAUSE NO CODE DISPLAYED, THEY COULD NOT ASSIST. THE CURRENT MILEAGE WAS APPROXIMATELY 70,000 AND FAILURE MILEAGE WAS APPROXIMATELY 44,827. UPDATED 09/17/08.*LJ UPDATED 09/25/08. *JB
NHTSA ODI #10238847
55,000 miles · Jul 15, 2008
Steering
WHEN VEHICLE COMES TO A COMPLETE STOP ON AN INCLINE WITH THE STEERING WHEEL TURNED FULL CHOCKED TO EITHER THE LEFT OR RIGHT THE STEERING WHEEL FREEZES AND CANNOT BE TURNED TO THE OPPOSITE DIRECTION. IT WILL NOT FREE UP UNTIL I SHIFT THE TRANSMISSION IN REVERSE AND BACK UP A FEW FEET. AT THAT POINT IT WILL UNFREEZE WITH A JERK AN…
Read full complaint
WHEN VEHICLE COMES TO A COMPLETE STOP ON AN INCLINE WITH THE STEERING WHEEL TURNED FULL CHOCKED TO EITHER THE LEFT OR RIGHT THE STEERING WHEEL FREEZES AND CANNOT BE TURNED TO THE OPPOSITE DIRECTION. IT WILL NOT FREE UP UNTIL I SHIFT THE TRANSMISSION IN REVERSE AND BACK UP A FEW FEET. AT THAT POINT IT WILL UNFREEZE WITH A JERK AND OPERATE CORRECTLY. THIS HAS HAPPENED ON ABOUT 6 OCCASIONS. I NOTIFIED THE LOCAL DEALER WHERE I PURCHASED THE CAR, USED WITH 52,000 MILES. IT NOW HAS 55,000 MILES AND I'VE HAD THE VEHICLE FOR ABOUT 9 MONTHS. THE DEALERS SERVICE SHOP COULD NOT DUPLICATE THE FAILURE AND COULD NOT FIND ANY ERROR CODES IN THE OBD. I BELIEVE THAT THE VEHICLE HAS TO BE ON AN INCLINE, WHICH IS THE CASE WITH MY DRIVEWAY, WHERE IT HAPPENED 4 OF THE 6 TIMES. THE MOST RECENT INCIDENCE HAPPENED ON MY NEXT DOOR NEIGHBOR'S DRIVEWAY WHICH ALSO HAS A MODERATELY STEEP INCLINE. (*** UPDATE***) LOCAL DEALERSHIP CONTACTED THE FACTORY IN GERMANY AND WAS TOLD THAT A FIX WAS TO INSTALL 'BUMPERS" ON EACH END OF THE STEERING MECHANISM THAT WOULD PREVENT THE WHEELS FROM TURNING TOO FAR AND RIDING UP ONTO THE FACTORY INSTALLED STEERING STOPS. THE DEALER OBTAINED THE "BUMPERS" AND INSTALLED THEM AT NO CHARGE. I WAS TOLD THAT I'D RECEIVE PAPERWORK ON THE MODIFICATIONS SOON. *TR
NHTSA ODI #10234466
54,500 miles · Jun 24, 2008
Steering
WHEN VEHICLE COMES TO A COMPLETE STOP ON AN INCLINE WITH THE STEERING WHEEL TURNED FULL CHOCKED TO EITHER THE LEFT OR RIGHT THE STEERING WHEEL FREEZES AND CANNOT BE TURNED TO THE OPPOSITE DIRECTION. IT WILL NOT FREE UP UNTIL I SHIFT THE TRANSMISSION IN REVERSE AND BACK UP A FEW FEET. AT THAT POINT IT WILL UNFREEZE WITH A JERK …
Read full complaint
WHEN VEHICLE COMES TO A COMPLETE STOP ON AN INCLINE WITH THE STEERING WHEEL TURNED FULL CHOCKED TO EITHER THE LEFT OR RIGHT THE STEERING WHEEL FREEZES AND CANNOT BE TURNED TO THE OPPOSITE DIRECTION. IT WILL NOT FREE UP UNTIL I SHIFT THE TRANSMISSION IN REVERSE AND BACK UP A FEW FEET. AT THAT POINT IT WILL UNFREEZE WITH A JERK AND OPERATE CORRECTLY. THIS HAS HAPPENED ON ABOUT 6 OCCASIONS. I NOTIFIED THE LOCAL DEALER WHERE I PURCHASED THE CAR, USED WITH 52,000 MILES. IT NOW HAS 55,000 MILES AND I'VE HAD THE VEHICLE FOR ABOUT 9 MONTHS. THE DEALERS SERVICE SHOP COULD NOT DUPLICATE THE FAILURE AND COULD NOT FIND ANY ERROR CODES IN THE OBD. I BELIEVE THAT THE VEHICLE HAS TO BE ON AN INCLINE, WHICH IS THE CASE WITH MY DRIVEWAY, WHERE IT HAPPENED 4 OF THE 6 TIMES. THE MOST RECENT INCIDENCE HAPPENED ON MY NEXT DOOR NEIGHBOR'S DRIVEWAY WHICH ALSO HAS A MODERATELY STEEP INCLINE. *TR
NHTSA ODI #10232203
51,200 miles · Jul 26, 2007
SeatsFireInjury
TL*THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT RECEIVED A WARNING FROM THE COMPUTER TO ENGAGE HIS SEAT BELT. THE SEAT BELTS WERE ALREADY ENGAGED, HOWEVER, HE CONTINUED TO RECEIVE THE MESSAGE. THE DEALER STATED THAT THERE WAS A GLITCH IN THE PROGRAM AND THEY WOULD NEED TO SERVICE THE COMPUTER. APPROXIMATELY THREE WEEKS LAT…
Read full complaint
TL*THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT RECEIVED A WARNING FROM THE COMPUTER TO ENGAGE HIS SEAT BELT. THE SEAT BELTS WERE ALREADY ENGAGED, HOWEVER, HE CONTINUED TO RECEIVE THE MESSAGE. THE DEALER STATED THAT THERE WAS A GLITCH IN THE PROGRAM AND THEY WOULD NEED TO SERVICE THE COMPUTER. APPROXIMATELY THREE WEEKS LATER, THE FRONT PASSENGER SEAT CAUGHT FIRE. THE DEALER DID NOT PROVIDE AN EXPLANATION AS TO THE CAUSE OF THE FIRE. THE DEALER REPLACED THE LEATHER AND WIRING IN THE FRONT SEAT. THE CONTACT WAS INJURED. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 51,200.
NHTSA ODI #10197541
Official recalls
4Oct 1, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Consequence & remedy
Consequence: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Dec 6, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH FRONT SEAT HEATING SYSTEMS, UPON ENTERING AND EXITING THE VEHICLE, EXCESSIVE CONTACT WITH THE SIDE BOLSTER THAT IS CONTAINED IN THE SEAT'S BACKREST MAY DAMAGE THE HEATING MAT LOCATED IN THIS AREA. IF SUCH DAMAGE WERE TO OCCUR, WITH THE SYSTEM TURNED ON, THE VEHICLE OCCUPANT MAY FEEL EXCESSIVE HEAT FROM THIS AREA.
Consequence & remedy
Consequence: IT IS POSSIBLE THAT THE HEATING MAT IN THE BACKREST'S SIDE BOLSTER COULD OVERHEAT AND DAMAGE, OR MELT A SMALL HOLE IN, THIS AREA OF THE SEAT COVER. IF THIS HAPPENED, IT COULD LEAD TO AN OCCUPANT BEING BURNED.
Remedy: DEALERS WILL MODIFY THE SEAT HEATING CIRCUIT. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Aug 9, 2004
ON CERTAIN PASSENGER VEHICLES, THE SOFTWARE PROGRAMMING OF THE DRIVER'S SEAT OCCUPANT DETECTION SYSTEM (ODS) MAY NOT BE ABLE TO RELIABLY DETERMINE IF THE DRIVER'S SEAT IS OCCUPIED.
Consequence & remedy
Consequence: IN CERTAIN CRASH CONDITIONS, THE DRIVER'S FRONT AIR BAG, HEAD PROTECTION SYSTEM, SAFETY BELT PRETENSIONER, AND KNEE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF INJURY TO A SEAT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE SOFTWARE FOR THE DRIVER'S SEAT OCCUPANT DETECTION SYSTEM. THE RECALL BEGAN OCTOBER 13, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Jul 14, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
Consequence & remedy
Consequence: AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA12002 · Vehicle Rollaway
Opened Apr 10, 2012 · Closed Jan 24, 2013
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:switch; Power Train:automatic Transmission
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Additional source detail variants (4)
Electrical System
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Electrical System:ignition
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Electrical System:ignition:switch
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
Power Train:automatic Transmission
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the vehicle is stopped with the service brakes applied and the transmission in Drive or Reverse, the driver can push the engine start/stop button one time, stopping the engine and automatically shifting the transmission to Park.In its DIR, BMW identified a condition such that if the driver depressed the start-stop button multiple times in rapid succession, the transmission could shift to Neutral instead of Park.With the transmission in neutral, depending on the slope of the road, the vehicle could rollaway if unattended.In review of data submitted to the Office of Defects Investigation (ODI) and of reports submitted to BMW, ODI identified 20 reports alleging vehicle rollaway involving vehicles equipped with Comfort Access.The vehicles identified in these reports are all subject to recall 12V-502.Ten of these reports were identified as likely related to the defect described in recall 12V-502.Two of the reports are likely related to other mechanical failures.The remaining 8 allegations of vehicle rollaway could not be associated with a specific cause.There are 32 reports alleging vehicle rollaway in the subject vehicles not equipped with the Comfort Access option.A vehicle based safety defect trend was not identified in these reports.Subject vehicles not equipped the Comfort Access option will automatically shift to Park once the key fob is removed from the key slot.In this regard these vehicles behave similarly to those with traditional mechanical keys where the key cannot be removed from the ignition unless the vehicle is shifted to Park.The difference between these vehicles and the subject vehicles with the Comfort Access option is that in the Comfort Access equipped vehicles, the engine can be started and stopped without the key fob in the key slot.ODI reports 10429922 and 10419177 noted in the EA opening resume were determined to be vehicles not equipped with the Comfort Access option and ODI did not identify a vehicle based safety defect associated with these incidents.This investigation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10185770
PE11025 · Vehicle Rollaway
Opened Aug 5, 2011 · Closed Apr 23, 2012
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
Additional source detail variants (2)
Electrical System
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
Power Train:automatic Transmission
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional mechanical connection (e.g., cable or linkage) between the gearshift and automatic transmission with an electronic connection controlled by a computer module. When parking the vehicle, the driver has the capability to manually shift the vehicle to park by pressing the Park button on the end of the electronic gearshift lever. However, the instructions for engine shutoff provided in the owner's manual state that pressing the Start/Stop button serves the dual function of switching off the engine and automatically shifting the transmission to Park.In response to ODI's information request for PE11-025, BMW described several circumstances where the subject vehicles may shift to neutral when the driver may expect it to automatically shift to park. First, for Comfort Access System (CAS) vehicles, if the transmission is in neutral when the key fob is in the ignition slot and the Start/Stop button is pressed to shut-off the engine, the transmission will remain in neutral. This is referred to as the Carwash mode and is a normal operating feature of the vehicles that is described in the owner's manual. BMW also described two circumstances that are not normal operating features and are not described in the owners' manual: (1) with the transmission in drive or reverse and the engine running, if the Start/Stop button is pushed 2 or 3 times within a 0.3 second to 0.5 second interval, the engine will stop and the transmission will shift to Neutral; and 2) if the Park button on the gearshift lever is pressed at the same time that the gearshift lever is actuated (i.e., toggled up or down) to select drive, reverse or neutral; the transmission will shift to neutral or remain in neutral.Beginning in model year (MY) 2005, BMW introduced CAS as an optional feature package for the subject vehicles.The key for CAS equipped vehicles is an electronic code that is sent to the engine control module by a remote transmitter (key fob). An optional docking port (key slot) is provided for driver convenience or to put the vehicle into Car Wash mode, which allows for engine shutoff in neutral. BMW sold approximately 45,000 subject vehicles with CAS and approximately 94 percent of the CAS equipped vehicles were produced from MY 2006 through 2008. Non-CAS subject vehicles were produced from MY 2002 through 2008 and require the remote control to be in the ignition slot located next to the Start/Stop button to start the engine.The 50 incidents identified by ODI's analysis of complaints and field reports include 18 involving CAS vehicles (39.6 incidents per 100,000 vehicles) and 32 involving non-CAS vehicles (42.0 incidents per 100,000 vehicles). Because the incidents are considered random events, the failure rates were also adjusted for vehicle exposure, resulting in rat
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Illustration