2021 BMW 530I

The contact owns a 2021 BMW 530I. The contact stated that the edge of the air bag leather cover was folding in, which enlarged the split between the air bag cover and the steering wheel. The vehicle was taken to an unknown dealer, where it was inspected, and the dealer informed the contact that the air bag leather cover was of poor quality. The dealer recommended the air bag replacement. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 18,000.

RCTA system does not work (other than on rare, unpredictable occasions, and generally only when the alert is worthless) - when another vehicle or pedestrian is too close to the car to make any difference. I have had cars with RCTA for years and none of them failed to detect objects/vehicles/people at much greater distances from my vehicle that could reasonably be expected to collide with my vehicle if I continued to back up. All these other cars provided an adequate advance warning of an impending danger (another car, bike, pedestrian, etc. approaching my vehicle with which I might collide, etc.) allowing the driver to react and avoid the problem. THIS PROBLEM OCCURRED REPEATEDLY STARTING IMMEDIATELY AFTER I TOOK POSSESSION OF THE CAR IN MARCH 2021. After repeated attempts to get BMW to fix the problem, I gave up. I will note the first serious occurrence of the issue below, but it has been repeated every time I use the car and pull out of a parking space in reverse. Probably 150 times? I can compensate for this failure somewhat, but it is vastly inferior to having a properly working RCTA. I have visited BMW dealerships on multiple occasions and each time asked that this issue be addressed. The car is reviewed, and I am told the system is working as designed. My response is that the car is therefore designed to be unsafe? However, on my latest visit for regular service (24 months since start of lease) I went to a different dealership, the service advisor told me that the problem was widespread in BMW 5 series sedans and SUVs. He indicated that there is no fix available at this time. It's been two years since I brought this to BMW's attention. Service Invoice that I am attaching is from March 3, 2022 - one of the trips to the dealership to get regular service where I asked again that this issue get addressed. See Item # 4 on pages 1 and 2.

After pulling into a parking space and stopping, the braking system became unresponsive. While stopped with the foot on the brakes, attempts to place the car in park failed. After pumping the brakes, the car rolled forward as the car idled and the brakes were unresponsive as it rolled through a corrugated metal wall and the car only stopped after pressing the ignition button to turn off the car, putting anyone in or near the car at that time at risk. The problem has been reported to the dealer and the dealer inspection is pending but the problem has not been isolated and not reproduced. No prior warning lights or symptoms of a problem was noticed in this car before this incident.

The contact owns a 2021 BMW 530i. The contact stated that while driving at approximately 55 MPH, the sunroof exploded and glass entered into the cabin of the vehicle. The vehicle was taken to the dealer where it was diagnosed and the contact was informed that the failure was due to the weather. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Driver’s sport seat bottom has 19 degrees of rear tilt in the lowest setting. I am unable to flatten seat bottom causing Sciatica nerve pain which causes my legs to fall asleep while driving. I have owned several BMWs with sport seats and this is the first one that has caused problems. Base sport seat needs more adjust to lower degree of rear facing tilt.