2004 BMW 530I

I WAS DRIVING MY GIRLFRIEND TO WORK WHEN OUT OF NOWHERE I SMELLED SOMETHING BURNING. AT FIRST I THOUGHT IT WAS COMING FROM MY SURROUNDING AREA, NOT MY CAR. I CONTINUED TO DRIVE NOT THINKING TOO MUCH OF IT. AS I CONTINUED TO DRIVE THE SMELL GOT STRONGER. I DECIDED TO PULL OVER AT A CONVENIENCE STORE JUST AS PRECAUTION. WHEN I STEPPED OUT OF THE CAR THERE WAS NO SMELL, I OPEN THE HOOD, EVERYTHING LOOKED NORMAL AND THERE WAS NO SMELL. I CONCLUDED THAT THE SMELL WAS COMING FROM THE VENTILATION SYSTEM. I TURN OF THE HEAT, IT WAS VERY COLD THAT MORNING, TURNED OFF THE HEATED SEATS, AND CONTINUED TO DRIVE. TEN MINUTES LATER, I ARRIVED AT MY GIRLFRIEND WORK PLACE, THAT'S WHEN WE REALIZE THE SMELL WAS COMING FROM THE PASSENGER HEAT. WE WHERE SHOCKED TO SEE THE RIGHT SIDE OF HER SEAT HAD A TWO INCH BURNT MARK IT. WHEN I GOT HOME I DECIDED TO DO AN INTERNET SEARCH ON THAT MATTER, AND FIND OUT THAT'S A COMMON OCCURRENCE ON THIS VEHICLE. LUCKY FOR US, MY GIRLFRIEND WAS WEARING JEAN, A COAT, AND HAD HER CELL PHONE IN HER BACK POCKET THAT MORNING. IF THAT WAS NOT THE CASE SOME SERIOUS INJURIOUS COULD HAVE OCCURRED. SHE HAD TO GET RID OF THE HER COAT, JEAN, AND CELL PHONE CASE, BUT THAT'S FAR BETTER THAN GOING TO THE HOSPITAL. I NO LONGER USE THE HEATED SEATS. *TR

PASSENGER RESTRAINT SYSTEM FAILURE. DUE TO FAULTY PASSENGER SEAT SENSOR MAT. SAME YEAR AND MODEL VEHICLES UNDER RECALL/EXTENDED WARRANTY - FOR UNCLEAR REASONS MY CAR NOT INCLUDED IN RECALL (CHECKED BY VIN AND WITH DEALER) BUT WAS UNDER EXTENDED WARRANTY. SPOKE WITH BMW AND THEY ARE UNABLE OR UNWILLING TO EXPLAIN WHY MY CAR IS NOT INCLUDED IN RECALL. FAILURE OCCURRED 2 MONTHS AFTER EXTENDED WARRANTY EXPIRED. SEE NHTSA CAMPAIGN ID # 08V384000. *TR

MY 2004 BMW 530I HAS BOTH THE SEATBELT AND AIRBAG LIGHT ON DISPLAY AT ALL TIMES ON MY DASHBOARD. THESE LIGHTS ON ARE CAUSED BY A FAULTY FRONT PASSENGER SEAT OCCUPANT DETECTION MAT WHICH BMW HAS AN EXTENDED WARRANTY ON. AFTER DROPPING MY CAR TO THE BMW DEALERSHIP TO GET THIS REPAIRED, I WAS INFORMED MY EXTENDED WARRANTY EXPIRED ROUGHLY 2 MONTHS PRIOR AND I CANNOT HAVE THIS WORK PERFORMED UNDER WARRANTY. THEY CHARGED ME $140 FOR THE DIAGNOSTICS AND SAID I WOULD HAVE TO PAY $1050 OUT OF POCKET TO GET REPAIRED. I IMMEDIATELY REACHED OUT TO BMW OF NORTH AMERICA AND INFORMED THEM OF MY SITUATION AS THIS OCCURRED WHILE MY VEHICLE WAS STILL UNDER WARRANTY. I WAS HOPING THEY COULD FIX MY CAR IN GOOD FAITH AS THIS IS A KNOWN ISSUE OR EVEN PROVIDE ME WITH A DISCOUNTED REPAIR. UNFORTUNATELY TWO MONTHS WENT BY WITH NO RESPONSE. WHEN I REACHED OUT AGAIN THEY SAID NO THIS IS NOT THEIR HEADACHE AND I AM RESPONSIBLE FOR ALL COSTS AND REPAIRS RELATED TO THIS. THIS IS A SERIOUS MALFUNCTION WHICH I AM SURPRISED IS NOT CONSIDERED A RECALL. IN THE SAFETY RECALL NOTICE IT SPECIFICALLY STATES IF BOTH WARNING LAMPS ARE ILLUMINATED SIMULTANEOUSLY, BMW RECOMMENDS NOT TO USE THE FRONT PASSENGER SEAT UNTIL THE VEHICLE HAS BEEN SERVICED. ALSO, THE SAFETY RECALL NOTICE SAYS THAT THE FRONT PASSENGER AIRBAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WILL NOT BE POSSIBLE. OBVIOUSLY THIS IS A HUGE SAFETY ISSUE WHICH BMW NEEDS TO ADDRESS. AN EXTENDED WARRANTY ON SUCH A SENSITIVE MATTER IS NOT SUFFICIENT AND A RECALL SHOULD BE ISSUED. *TR

WHILE DRIVING, A SMELL OF BURNING MATTER RAPIDLY INCREASED IN THE CAR, THEN IMMEDIATELY FOLLOWED BY A SHARP BURNING SENSATION IN MY LEFT THIGH. I STOPPED THE CAR, GARBED MY EXTINGUISHER AND LOOKED AROUND THE SEAT FOR ANY SIGNS OF FIRE. THEN I NOTICED A BLACK BURNED HOLE ON THE SEAT BOTTOM LEFT BOLSTER EXACTLY WHERE MY THIGH BURNED. IT SEEMED THAT THE SEAT WARMER OVERHEATED, AND BURNED A HOLE IN THE LEATHER. TURNING ON THE CAR AND WARMER AGAIN FOR COUPLE SECONDS, RESULTED IN SPARKS APPEARING THROUGH THE HOLE. I CONTACTED BMW OF NORTH AMERICA, AND THEY INFORMED ME THAT THE CAR IS NOT COVERED BY A WARRANTY ANYMORE, AND THAT THERE WAS NO RECALLS RELATED TO THE SEATS ISSUED FOR MY CAR. TO CONTACT MY BMW DEALERSHIP FOR REPAIRS. THAT I WOULD BE RESPONSIBLE FOR THE DIAGNOSTIC FEE AND THAT THEY MIGHT COVER A PORTION OF THE REPAIRS. CHECKING SIMILAR COMPLAINTS ON NHTSA, I AM SURPRISED BMW HAS NOT ISSUED A RECALL FOR THE SEAT HEATERS FOR OUR CARS, SPECIALLY SINCE IT IS A SERIOUS SAFETY ISSUE. *TR

MY VEHICLE IS A 530I WITH A PRODUCTION DATE IN DECEMBER 2003, IT IS MY CONTENTION THAT THE VEHICLE SHOULD BE SUBJECT TO RECALL RCDNN-04V575. DESPITE THE DECEMBER 2004 NOTICE TO NTSHA INDICATING THAT 100% OF VEHICLES WITH THE SEAT HEATING OPTION PRODUCED BETWEEN JUNE 17TH 2003 AND APRIL 30TH 2004. BMW INSISTS THAT MY VEHICLE (PRODUCTION DATE IN DECEMBER 2003 AND CONTAINING THE SEAT HEATER IN QUESTION) IS, ACCORDING TO INTERNAL DOCUMENTS WHICH THEY WILL NOT RELEASE TO ME, NOT IN FACT SUBJECT TO THE RECALL. WHAT I FIND INEXPLICABLE AND BEYOND BELIEF, IS THAT THEY WOULD ISSUE A NOTIFICATION TO NTSHA IN NOVEMBER 2004, A FULL SIX MONTHS AFTER ALLEGEDLY REMEDYING DEFECTS IN CARS PRODUCED FROM MID-MARCH 2004 THROUGH APRIL 30TH 2004 WITHOUT CORRECTING THOSE DATES IN THE NOTIFICATION LETTER. BMW REFUSES TO REPAIR OR EVEN INSPECT MY PASSENGER SIDE SEAT BOLSTER HEATING ELEMENT DESPITE CLEAR EVIDENCE THAT IT IS IN FACT DEFECTIVE AND SUBJECT TO THE RECALL. *TR

I HAD A BULB FAILURE WARNING ILLUMINATE ON THE DASH. I BOUGHT THE PARKING LIGHT BULB, WENT TO REPLACE IT, AND FOUND ALL OF THE WIRING INSIDE OF THE HEADLIGHT HOUSING CRUMBLING TO BITS. THERE WERE LITERALLY BARE WIRES CROSSING ON TOP OF ONE ANOTHER, WHICH IS CLEARLY A FIRE HAZARD. WHEN I ASKED MY BMW DEALER ABOUT THIS, THEY SAID IT IS A COMMON PROBLEM, IS NOT COVERED UNDER WARRANTY, AND I HAVE TO BUY NEW HEADLIGHTS. I HAD NEVER HEARD OF INTERNAL HEADLIGHT WIRING BEING CONSIDERED A WEAR ITEM, BUT BMW SAYS OTHERWISE. I HAVE A 30 YEAR OLD CAR WITH ALL OF ITS WIRING INTACT; THIS BMW HAD THIS PROBLEM BEFORE IT HAD HIT 10 YEARS OLD. I SPENT APPROXIMATELY $2000 FOR NEW HEADLIGHTS. CLEARLY THIS IS A MAJOR DESIGN FLAW THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR, AS IT PRESENTS A CLEAR FIRE HAZARD. I DO KNOW OF ONE PERSON WHO EXPERIENCED A VEHICLE FIRE DUE TO THIS DEFECT IN A '05 525I. *TR

THE FRONT PASSENGER SEAT OCCUPANCY DETECTOR HAS A FAULT WHICH INCAPACITATES THE PASSENGER FRONT AIR BAG. THIS CREATES AN EXTREMELY UNSAFE PASSENGER SITUATION IN THE EVENT OF A CRASH. THE BMW SBSR SYSTEM SHOWS FAULT 0095B8. THIS SPECIFIC ISSUE IS A KNOWN BMW PROBLEM AND HAS ISSUED A RECALL, BUT BMW HAS INDICATED MY VIN IS NOT COVERED FOR THIS ISSUE FOR SOME UNKNOWN REASON. *TR

TL* THE CONTACT OWNS A 2004 BMW 530I. THE CONTACT STATED THAT THE AIR BAG SENSOR REMAINED ILLUMINATED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:08V384000 (AIR BAGS). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FLOOR MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000. UPDATED 01/20/15*LJ THE VEHICLE WAS REPAIRED. UPDATED 01/20/15*JB

WHILE DRIVING SUDDENLY THE DRIVE CONTROL MALFUNCTION ALERT APPEARED, A FEW SECONDS LATER, ACTIVE STEERING MALFUNCTION ALERT OCCURRED. IT DID NOT AFFECT MY DRIVING AT ALL, SO I CONTINUED UNTIL ABLE TO PULL OVER, AND TURN THE CAR OFF, WHEN I RESTARTED THE CAR, BOTH ALERTS CLEARED. NEXT DAY, AFTER DRIVING FOR 20 MINUTES IT HAPPENED AGAIN, ONCE CAR IS TURNED OFF AND TURNED BACK ON, ALERTS DISAPPEARED AGAIN. SOME DAYS DOES NOT COME ON AT ALL, BUT NOTICED IT OCCURS MORE FREQUENT WHEN WEATHER IS HOT. I LIVE IN PHOENIX, AZ THE TEMPS ARE IN 105-109 RANGE. WHEN COOLER WEATHER THE ALERTS DO NOT COME ON. I AM TOLD IT WILL COST OVER $2000 TO REPLACE BOTH SENSORS. THAT IS NUTS... *TR

THE AIRBAG LIGHT IS ON IN MY CAR, AS WELL AS SEAT BELT LIGHT. IT APPEARS THE AFTER DOING SOME RESEARCH THAT THE PAD IN THE PASSENGER SEAT HAS FAILED WITH VERY LOW MILES, AND VERY LITTLE USE. ALL OF THESE CARS WITH THESE PADS IN THE PASSENGER SEATS SHOULD BE REPLACED UNDER RECALL. THERE WAS A PREVIOUS RECALL TO REPOSITION THE PAD OR SOMETHING TO AVOID CRACKING, BUT THESE SAFETY RELATED PARTS ARE CLEARLY JUNK THAT WERE INSTALLED WHEN NEW WEATHER THEY WERE REWORKED, OR REPOSITIONED IN THE SEAT. BMW SHOULD BE REPLACING ALL THESE SEAT SENSOR PADS UNDER RECALL AND SOON, MANY OF THESE CARS NOW HAVE NON WORKING AIRBAGS DUE TO THIS ISSUE, AND IT AFFECTS THE SAFETY AND FUNCTIONALITY OF THE CAR ALL TOGETHER. MODEL YEARS AFFECTED ARE 2004 2005 2006 2007 AT THE VERY LEAST IT SEAMS AFTER READING EXTENSIVELY ON THE ISSUE. *TR